IllustrationTHE VEHICLE STALLED WITHOUT WARNING, WHICH MADE THE VEHICLE DIFFICULT TO CONTROL. *JB FORD RECALLED THE SAME PROBLEM WITH ALUMINUM HEAD/STEEL BLOCK AND COULD THE CAUSE OF THE GASKET GOING OUT. SCC
1994 GMC Sonoma
Owner reports · Recalls · Investigations
More warning signs than most Sonoma years
Owner complaints for the 1994 GMC Sonoma are substantially higher than the model-year median of 57.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sonoma years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 224 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 131 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports3 injury reports
Engine And Engine Cooling complaints
12 reportsWHEN EGR VALVE FAILS (CAMPAIN NOTICE G96067) POWER BRAKES ARE VERY ERRATIC.
WHENEVER DRIVING VEHICLE WOULD SUDDENLY ACCELERATE FOR NO REASON. COULD STAND ON BRAKES & VEHICLE FAILED TO STOP. VEHICLE WAS NOT CONTROLLABLE. TRIED SHIFTING INTO NEUTRAL ALSO FAILED. VEHICLE THREW A TIE ROD INTO THE MOTOR & DAMAGED IT. IT HAS BE REPLACED. SUDDEN ACCELERATION HAPPENED ON 26 AUGUST,2000 AND 23 SEPTEMBER 20 00…
Read full complaint
WHENEVER DRIVING VEHICLE WOULD SUDDENLY ACCELERATE FOR NO REASON. COULD STAND ON BRAKES & VEHICLE FAILED TO STOP. VEHICLE WAS NOT CONTROLLABLE. TRIED SHIFTING INTO NEUTRAL ALSO FAILED. VEHICLE THREW A TIE ROD INTO THE MOTOR & DAMAGED IT. IT HAS BE REPLACED. SUDDEN ACCELERATION HAPPENED ON 26 AUGUST,2000 AND 23 SEPTEMBER 20 00. TOOK VEHICLE TO DIFFERENT DEALERS FOR REPAIR DUE TO NOT BEING DRIVEABLE.*AK
CRANKSHAFT ROD AND PIN FAILED. NLM
MASTER CYLINDER FAILED. YH
RIGHT MOTOR MOUNT FAILURE SHIFTING ENGINE OIL FILTER INTO MOUNTING BOLT PUNCTURING FILTER AND SPEWING OIL ON HOT ENGINE
EGR VALVE FAILED SEVERAL TIMES, WHEN THIS HAPPENS COMPLETE BRAKE LOSS AND LOSS OF CONTROL ARE EXPERIENCED.
ENGINE SURGES FOWARD INTERMITTENTLY DUE TO EGR FAILURE PRIOR TO/AFTER MANUFACTURER'S RECALL 96I-067.
PEDAL GOES TO FLOOR WITHOUT STOPPING VEHICLE OCCASIONALLY.
BRAKE ROTORS FAILED.
Official recalls
299V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE94046 · Abs Braking System Fails
Opened Jun 17, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available