NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
44 reportsClear category filter40,000 miles · Apr 29, 2014
Fuel/propulsion SystemService Brakes
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT THE BRAKE LINES AND FUEL PUMP WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN VERIFIED THE FAILURE AND REPLACED BOTH THE BRAKE LINES AND FUEL PUMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT THE BRAKE LINES AND FUEL PUMP WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN VERIFIED THE FAILURE AND REPLACED BOTH THE BRAKE LINES AND FUEL PUMP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 60,000.
NHTSA ODI #10585469
100,000 miles · Apr 23, 2014
Service Brakes
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT THE BRAKE LINES WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE 200,000.
NHTSA ODI #10584385
35,900 miles · Apr 18, 2014
Service Brakes
TRAVELING SOUTH, NY RT. 12. ATTEMPTED TO SLOW FOR A RIGHT TURN. SIGNAL ON, TOWING AN EMPTY TRAILER APPROX WEIGHT 2000 LBS. APPLIED THE SERVICE BRAKE FOR THE TURN, PEDAL WENT TO FLOOR, NO BRAKES. LUCKILY NO INCIDENT. EXAMINED THE UNDERNEATH AND FOUND THAT THE STEEL BRAKE LINES WERE ROUTED OVER THE FRAME ON THE DRIVER SIDE (U…
Read full complaint
TRAVELING SOUTH, NY RT. 12. ATTEMPTED TO SLOW FOR A RIGHT TURN. SIGNAL ON, TOWING AN EMPTY TRAILER APPROX WEIGHT 2000 LBS. APPLIED THE SERVICE BRAKE FOR THE TURN, PEDAL WENT TO FLOOR, NO BRAKES. LUCKILY NO INCIDENT. EXAMINED THE UNDERNEATH AND FOUND THAT THE STEEL BRAKE LINES WERE ROUTED OVER THE FRAME ON THE DRIVER SIDE (UNDERNEATH BODY UNDER THE DRIVER DOOR.) WHEN BRAKE LINE(S) FAILED, THERE WERE NO SIGN OF ANY BRAKING ABILITY. BOTH THE FRONT AND REAR BRAKE SYSTEMS WERE INOPERABLE. THE LINES HAD RUSTED THROUGH FROM APPARENTLY ROAD SALT OR (?), CREATING A VERY DANGEROUS SITUATION. SINCE THE INCIDENT I HAVE SPOKE WITH SEVERAL OTHER DRIVERS WHO HAVE EXPERIENCED THE SAME FAILURE. *TR
NHTSA ODI #10583437
195,000 miles · Apr 7, 2014
Service Brakes
BRAKE LINES HAD RUSTED OUT AND BURST SO THE BRAKES FAILED TO STOP THE TRUCK. TRUCK WAS ON A DOWN HILL INCLINE AND WENT THROUGH A STOP LIGHT (FORTUNATELY IT WAS LATE AT NIGHT AND THERE WAS NO CROSSING TRAFFIC.) HAD TO REPLACE ALL THE BRAKE LINES. *TR
NHTSA ODI #10577982
140,000 miles · Apr 6, 2014
Service Brakes
BRAKE LINES RUSTED AND FAILED CAUSING THE BRAKE PEDAL TO GO TO THE FLOOR. *TR
NHTSA ODI #10577746
66,674 miles · Jan 20, 2014
Service BrakesWheels
WHILE DRIVING, NEEDED TO SLOW DOWN FOR TRAFFIC LIGHT AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STILL DRIVE IT, AS THE BRAKES WOULD STOP THE TRUCK EVENTUALLY. CAUSE WAS THE RUSTED REAR BRAKE LINE THAT RUPTURED. COST TO FIX WAS $400.00 IN ADDITION, ON 12.27.13, I HAD THE FRONT WHEEL BEARING REPLACED AT A COST OF $525.0…
Read full complaint
WHILE DRIVING, NEEDED TO SLOW DOWN FOR TRAFFIC LIGHT AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STILL DRIVE IT, AS THE BRAKES WOULD STOP THE TRUCK EVENTUALLY. CAUSE WAS THE RUSTED REAR BRAKE LINE THAT RUPTURED. COST TO FIX WAS $400.00 IN ADDITION, ON 12.27.13, I HAD THE FRONT WHEEL BEARING REPLACED AT A COST OF $525.00. THE TRUCK ONLY HAS 66,600 MILES ON IT. *TR
NHTSA ODI #10560689
83,000 miles · Dec 26, 2013
Service Brakes
I WAS I 91 SOUTH HEADING IN TO HARTFORD CT, TRAFFIC WAS HEAVY AND AS A RESULT I WAS TRAVELING APPX 20 MPH AS I ENTERED THE RAMP EXIT LANE. I STEPPED ON BRAKE PEDAL AND THE PEDAL WENT TO THE FLOOR, FORTUNATELY I WAS ABLE TO VEER INTO THE BREAKDOWN LANE AND AVOID HITTING OTHER CARS. I SLOWLY MADE IT TO MY PLACE OF EMPLOYMENT AND…
Read full complaint
I WAS I 91 SOUTH HEADING IN TO HARTFORD CT, TRAFFIC WAS HEAVY AND AS A RESULT I WAS TRAVELING APPX 20 MPH AS I ENTERED THE RAMP EXIT LANE. I STEPPED ON BRAKE PEDAL AND THE PEDAL WENT TO THE FLOOR, FORTUNATELY I WAS ABLE TO VEER INTO THE BREAKDOWN LANE AND AVOID HITTING OTHER CARS. I SLOWLY MADE IT TO MY PLACE OF EMPLOYMENT AND LATER HAD THE TRUCK TOWED HOME. AS IT TURNS OUT I DISCOVERED THE ALL BRAKE LINES HAD CORRODED AND HAD TO BE REPLACED. I CONTACTED GM AS I THOUGHT IT VERY UNUSUAL FOR ALL BRAKES LINES TO BE SO SEVERELY CORRODED. THEY ATTRIBUTED THE SEVERE CORROSION TO THE FACT THAT THE TRUCK WAS 10 YEARS OLD AND REFUSED TO COVER THE EXPENSE AND CONSIDERED THE CASE CLOSED. BY DOING A SIMPLE INTERNET SEARCH I FOUND THAT THIS SAME PROBLEM IS QUITE COMMON AND MY MECHANIC ALSO INFORMED THAT GM ( POSSIBLY AS A RESULT OF THIS BEING A COMMON ISSUE) HAS MADE A AVAILABLE A BRAKE LINE REPLACEMENT KIT. *TR
NHTSA ODI #10557297
41,000 miles · Nov 13, 2013
Service Brakes
TL* THE CONTACT OWNS A 2004 GMC SIERRA DENALI. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS ABLE TO BE FULLY DEPRESSED BUT DID STOP THE VEHICLE. THE VEHICLE WAS DOWNSHIFTED AND THE PARKING BRAKE WAS APPLIED WHEN THE BRAKE WARNING LAMP ILLUMINATED. THE VEHICLE WAS LEFT TO BE TOWED TO THE CONTA…
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC SIERRA DENALI. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS ABLE TO BE FULLY DEPRESSED BUT DID STOP THE VEHICLE. THE VEHICLE WAS DOWNSHIFTED AND THE PARKING BRAKE WAS APPLIED WHEN THE BRAKE WARNING LAMP ILLUMINATED. THE VEHICLE WAS LEFT TO BE TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 41,000.
NHTSA ODI #10552089
78,000 miles · Nov 7, 2013
Service Brakes
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT WHILE REVERSING INTO HER RESIDENTIAL GARAGE, THE BRAKES FAILED. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE, SHE NOTICED THAT ONE OF THE BRAKE LINES HAD FRACTURED AND ALL THE REST OF THE BRAKE LINES WERE COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO …
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT WHILE REVERSING INTO HER RESIDENTIAL GARAGE, THE BRAKES FAILED. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE, SHE NOTICED THAT ONE OF THE BRAKE LINES HAD FRACTURED AND ALL THE REST OF THE BRAKE LINES WERE COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 78,000.
NHTSA ODI #10551235
144,000 miles · Nov 5, 2013
Service Brakes
AFTER EXITING ONTO THE HIGHWAY AND ATTEMPTING TO BRAKE TO MAKE A RIGHT TURN I EXPERIENCED CATASTROPHIC BRAKE FAILURE. WHEN THE BRAKE PEDAL WAS APPLIED THERE WAS NO PRESSURE, AND THE PEDAL WENT STRAIGHT TO THE FLOOR. NO WARNING LIGHTS OR SENSORS WERE ACTIVATED BEFORE THE TOTAL BRAKE FAILURE. THE VEHICLE WAS TOWED TO A LOCAL GMC D…
Read full complaint
AFTER EXITING ONTO THE HIGHWAY AND ATTEMPTING TO BRAKE TO MAKE A RIGHT TURN I EXPERIENCED CATASTROPHIC BRAKE FAILURE. WHEN THE BRAKE PEDAL WAS APPLIED THERE WAS NO PRESSURE, AND THE PEDAL WENT STRAIGHT TO THE FLOOR. NO WARNING LIGHTS OR SENSORS WERE ACTIVATED BEFORE THE TOTAL BRAKE FAILURE. THE VEHICLE WAS TOWED TO A LOCAL GMC DEALERSHIP. THE DEALERSHIP ADVISED ME THAT THE BRAKE LINE "BLEW OUT" FROM THE FRONT LEFT CALIPER BECAUSE OF RUST. I RESEARCHED SUCH PROBLEMS AND FOUND THAT SIMILAR COMPLAINTS WERE NUMEROUS AND THAT THE NHTSA HAD INITIATED AN INQUIRY/INVESTIGATIONS INTO EXCESSIVE RUST ON BRAKE COMPONENTS OF GMC VEHICLES CAUSING THIS TYPE OF TOTAL BRAKE FAILURE. *TR
NHTSA ODI #10550935
Official recalls
7Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration