IllustrationCONSUMER STATES WHILE DRIVING THERE WAS A BURNING SMELL, THEN SHE FELT SOMETHING HOT ON HER LEG, WHEN LOOKING SHE SAW VEHICLE HAD CAUGHT ON FIRE AND HER LEG WAS ALSO ON FIRE, FIRE WAS CAUSED BY A FAULTY WIRING HARNESS. *SLC
1998 GMC Sierra
Owner reports · Recalls · Investigations
More warning signs than most Sierra years
Owner complaints for the 1998 GMC Sierra are substantially higher than the model-year median of 53.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
725–50K
1850–75K
1175–100K
10100–150K
2150K+
50 reports with mileage · 140 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports8 fire reports8 injury reports
Electrical System complaints
9 reportsVEHICLE FIRE CAUSED BY A SHORT IN THE WIRING OF THE DOOR, CLAIM 42-1295-954. *SLC
CONSUMER PARKED VEHICLE AND WENT TO WORK, CAME OUT AND VEHICLE HAD CAUGHT ON FIRE, THE FIRE PUT ITSELF OUT, THE FIRE STARTED IN THE AREA OF THE POWER MIRROR SWITCH, CLAIM 22-V226-581. *SLC
VEHICLE FIRE CAUSED BY A SHORT IN THE WIRING OF THE DOOR, CLAIM 42-1295-954. *SLC
CONSUMER PARKED VEHICLE AND WENT TO WORK, CAME OUT AND VEHICLE HAD CAUGHT ON FIRE, THE FIRE PUT ITSELF OUT, THE FIRE STARTED IN THE AREA OF THE POWER MIRROR SWITCH, CLAIM 22-V226-581. *SLC
THE VEHICLE HAD BEEN PARKEDT AND SHUT OFF FOR APPROXIMATELY FOR FOUR HOURS WHEN THE CUSTOMER NOTICED FLAMES AND SMOKE, DASH HERNESS FAULTY (ATTORNEY FOR CLIENT).
WHILE DRIVING THE TREAD OF THE REAR PASSENGER SIDE TIRE SEPARATED, INSPECTION OF THE SECOND REAR TIRE REVEALED SEPARATION OF THE TREAD AND AIR LEAKAGE (THE TIRE MAKE/MODEL WAS NOT GIVEN). NLM
POSITIVE POST FOT DELCO BATTERY HAD PULLED OUT AND WAS LEAKING ACID AND RELEASING HYDROGEN ACID. CONSUMER REPLACED BATTERY, AND NOTICED THAT THERE WAS NOT ENOUGH SLACK FROM THE CLAMP TO THE BATTERY CABLE TO ALLOW BAD MOVES FROM THE CHASSITY.*AK
POSITIVE TERMINAL OF BATTERY LEAKED BATTERY ACID. *AK
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05007 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed Apr 11, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS IS CONDUCTING A SAFETY RECALL TO REMOVE AND REPLACE THE TAILGATE SUPPORT CABLES INSTALLED IN 805,368 MODEL YEAR 1999 AND 2000 GMT 800 MODEL VEHICLES.THE MODEL YEAR 1999 AND 2000 GMT-800 SERIES VEHICLES THAT WILL BE CAMPAIGNED HAD CONTRIBUTED A SIGNIFICANT MAJORITY OF THE TOTAL COMPLAINTS (87%) AND INJURIES (79%) ASSOCIATED WITH THE TAILGATE SUPPORT CABLE BREAKAGE IN THE MODEL YEAR 1998 - 2000 C/K SERIES VEHICLES ADDRESSED BY THIS INVESTIGATION.
Additional source detail variants (3)
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SAFETY RECALL TO REMOVE AND REPLACE THE TAILGATE SUPPORT CABLES INSTALLED IN 805,368 MODEL YEAR 1999 AND 2000 GMT 800 MODEL VEHICLES.THE MODEL YEAR 1999 AND 2000 GMT-800 SERIES VEHICLES THAT WILL BE CAMPAIGNED HAD CONTRIBUTED A SIGNIFICANT MAJORITY OF THE TOTAL COMPLAINTS (87%) AND INJURIES (79%) ASSOCIATED WITH THE TAILGATE SUPPORT CABLE BREAKAGE IN THE MODEL YEAR 1998 - 2000 C/K SERIES VEHICLES ADDRESSED BY THIS INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS IS CONDUCTING A SAFETY RECALL TO REMOVE AND REPLACE THE TAILGATE SUPPORT CABLES INSTALLED IN 805,368 MODEL YEAR 1999 AND 2000 GMT 800 MODEL VEHICLES.THE MODEL YEAR 1999 AND 2000 GMT-800 SERIES VEHICLES THAT WILL BE CAMPAIGNED HAD CONTRIBUTED A SIGNIFICANT MAJORITY OF THE TOTAL COMPLAINTS (87%) AND INJURIES (79%) ASSOCIATED WITH THE TAILGATE SUPPORT CABLE BREAKAGE IN THE MODEL YEAR 1998 - 2000 C/K SERIES VEHICLES ADDRESSED BY THIS INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS IS CONDUCTING A SAFETY RECALL TO REMOVE AND REPLACE THE TAILGATE SUPPORT CABLES INSTALLED IN 805,368 MODEL YEAR 1999 AND 2000 GMT 800 MODEL VEHICLES.THE MODEL YEAR 1999 AND 2000 GMT-800 SERIES VEHICLES THAT WILL BE CAMPAIGNED HAD CONTRIBUTED A SIGNIFICANT MAJORITY OF THE TOTAL COMPLAINTS (87%) AND INJURIES (79%) ASSOCIATED WITH THE TAILGATE SUPPORT CABLE BREAKAGE IN THE MODEL YEAR 1998 - 2000 C/K SERIES VEHICLES ADDRESSED BY THIS INVESTIGATION.
RQ04010 · Tailgate Support Cable Breakage
Opened Sep 28, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
ODI IS UPGRADING RQ04-010 AND OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998, 1999, AND PARTIAL YEAR 2000 SILVERADOS AND SIERRAS (C/K MODELS).GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000 - 2004 SIERRAS AND SILVERADOS.GENERAL MOTORS HAS ADVISED ODI THAT THE MATERIALS USED FOR THE TAILGATE CABLE SHEATHING INSTALLED IN C/K MODELS HAD INADVERTENTLY CHANGED IN OCTOBER 1999, INCREASING THE PROPENSITY FOR VOIDS IN AND AROUND THE GALVANIZED STEEL CABLE STRANDS WHICH CAN ALLOW MOISTURE TO WICK AMONG THE STRANDS, LEADING TO OXIDATION AND WEAKENING OF THE STRANDS.SINCE ODI INITIATED RQ04-010 IN SEPTEMBER 2004, ODI HAS RECEIVED 10 ADDITONAL NON-INJURY COMPLAINTS ON MY 1998-99 C/K VEHICLES, BUT NO ADDITIONAL INJURY COMPLAINTS.DURING THIS SAME PERIOD, GM HAS RECEIVED 564 NON-INJURY AND 35 INJURY COMPLAINTS. ODI HAS RECEIVED 6 INJURY COMPLAINTS AND 38 NON-INJURY COMPLAINTS FROM OWNERS OF MODEL YEAR 2000 C/K VEHICLES AND REQUIRES FURTHER INVESTIGATION TO DETERMINE WHETHER THESE INCIDENTS OCCURRED IN VEHICLES WITHIN THE SCOPE OF CAMPAIGN 04V-129 OR SHOULD BE ADDED TO THE INJURY SUMMARY FOR RQ04-010.
Additional source detail variants (3)
Latches/locks/linkages:tailgate:latch
ODI IS UPGRADING RQ04-010 AND OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998, 1999, AND PARTIAL YEAR 2000 SILVERADOS AND SIERRAS (C/K MODELS).GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000 - 2004 SIERRAS AND SILVERADOS.GENERAL MOTORS HAS ADVISED ODI THAT THE MATERIALS USED FOR THE TAILGATE CABLE SHEATHING INSTALLED IN C/K MODELS HAD INADVERTENTLY CHANGED IN OCTOBER 1999, INCREASING THE PROPENSITY FOR VOIDS IN AND AROUND THE GALVANIZED STEEL CABLE STRANDS WHICH CAN ALLOW MOISTURE TO WICK AMONG THE STRANDS, LEADING TO OXIDATION AND WEAKENING OF THE STRANDS.SINCE ODI INITIATED RQ04-010 IN SEPTEMBER 2004, ODI HAS RECEIVED 10 ADDITONAL NON-INJURY COMPLAINTS ON MY 1998-99 C/K VEHICLES, BUT NO ADDITIONAL INJURY COMPLAINTS.DURING THIS SAME PERIOD, GM HAS RECEIVED 564 NON-INJURY AND 35 INJURY COMPLAINTS. ODI HAS RECEIVED 6 INJURY COMPLAINTS AND 38 NON-INJURY COMPLAINTS FROM OWNERS OF MODEL YEAR 2000 C/K VEHICLES AND REQUIRES FURTHER INVESTIGATION TO DETERMINE WHETHER THESE INCIDENTS OCCURRED IN VEHICLES WITHIN THE SCOPE OF CAMPAIGN 04V-129 OR SHOULD BE ADDED TO THE INJURY SUMMARY FOR RQ04-010.
Structure:body:tailgate
ODI IS UPGRADING RQ04-010 AND OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998, 1999, AND PARTIAL YEAR 2000 SILVERADOS AND SIERRAS (C/K MODELS).GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000 - 2004 SIERRAS AND SILVERADOS.GENERAL MOTORS HAS ADVISED ODI THAT THE MATERIALS USED FOR THE TAILGATE CABLE SHEATHING INSTALLED IN C/K MODELS HAD INADVERTENTLY CHANGED IN OCTOBER 1999, INCREASING THE PROPENSITY FOR VOIDS IN AND AROUND THE GALVANIZED STEEL CABLE STRANDS WHICH CAN ALLOW MOISTURE TO WICK AMONG THE STRANDS, LEADING TO OXIDATION AND WEAKENING OF THE STRANDS.SINCE ODI INITIATED RQ04-010 IN SEPTEMBER 2004, ODI HAS RECEIVED 10 ADDITONAL NON-INJURY COMPLAINTS ON MY 1998-99 C/K VEHICLES, BUT NO ADDITIONAL INJURY COMPLAINTS.DURING THIS SAME PERIOD, GM HAS RECEIVED 564 NON-INJURY AND 35 INJURY COMPLAINTS. ODI HAS RECEIVED 6 INJURY COMPLAINTS AND 38 NON-INJURY COMPLAINTS FROM OWNERS OF MODEL YEAR 2000 C/K VEHICLES AND REQUIRES FURTHER INVESTIGATION TO DETERMINE WHETHER THESE INCIDENTS OCCURRED IN VEHICLES WITHIN THE SCOPE OF CAMPAIGN 04V-129 OR SHOULD BE ADDED TO THE INJURY SUMMARY FOR RQ04-010.
Structure:body:tailgate:hinge And Attachments
ODI IS UPGRADING RQ04-010 AND OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998, 1999, AND PARTIAL YEAR 2000 SILVERADOS AND SIERRAS (C/K MODELS).GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000 - 2004 SIERRAS AND SILVERADOS.GENERAL MOTORS HAS ADVISED ODI THAT THE MATERIALS USED FOR THE TAILGATE CABLE SHEATHING INSTALLED IN C/K MODELS HAD INADVERTENTLY CHANGED IN OCTOBER 1999, INCREASING THE PROPENSITY FOR VOIDS IN AND AROUND THE GALVANIZED STEEL CABLE STRANDS WHICH CAN ALLOW MOISTURE TO WICK AMONG THE STRANDS, LEADING TO OXIDATION AND WEAKENING OF THE STRANDS.SINCE ODI INITIATED RQ04-010 IN SEPTEMBER 2004, ODI HAS RECEIVED 10 ADDITONAL NON-INJURY COMPLAINTS ON MY 1998-99 C/K VEHICLES, BUT NO ADDITIONAL INJURY COMPLAINTS.DURING THIS SAME PERIOD, GM HAS RECEIVED 564 NON-INJURY AND 35 INJURY COMPLAINTS. ODI HAS RECEIVED 6 INJURY COMPLAINTS AND 38 NON-INJURY COMPLAINTS FROM OWNERS OF MODEL YEAR 2000 C/K VEHICLES AND REQUIRES FURTHER INVESTIGATION TO DETERMINE WHETHER THESE INCIDENTS OCCURRED IN VEHICLES WITHIN THE SCOPE OF CAMPAIGN 04V-129 OR SHOULD BE ADDED TO THE INJURY SUMMARY FOR RQ04-010.