IllustrationWINDSHIELD WIPERS WILL OPERATE INTERMITTENTLY AND WITHOUT PRIOR NOTICE WINDSHIELD WIPERS WOULD STOP AND GO. DEALERSHIP AWARE OF PROBLKEM.*AK CONSUMER STATES THE PULSE MODULE IS CAUSING WINDSHIELD WIPERS TO NOT WORK. *JB
1996 GMC Sierra
Owner reports · Recalls · Investigations
More warning signs than most Sierra years
Owner complaints for the 1996 GMC Sierra are substantially higher than the model-year median of 53.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 246 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports3 fire reports13 injury reports
What owners actually said
246 reportsINTERMITTENTLY WINDSHIELD WIPERS BECOME INOPERABLE, OBSTRUCTING DRIVER'S VIEW. A RECALL HAS BEEN ISSUED ON VEHICLE'S MAKE AND MODEL; HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK WINDSHIELD WIPERS WILL NOT WORK AT ALL AT VARIOUS TIMES. *YH
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE DRIVING WHEN WINDSHIELD WIPERS ARE NEEDED. WINDSHIELD WIPERS WORK INTERMITTENTLY OR FAIL TO WORK AT ALL WHICH CAUSES POOR DRIVER'S VISIBILITY. ALSO, RECALL NUMBER 98V150001/ MANUFACTURER'S RECALL 98043 DEALT WITH SAME PROBLEM. HOWEVER, THIS VEHICLE NOT INCLUDED DUE TO VIN. *AK
GMC SAID THAT MY VECHICLE IS NOT COVER, BUT I'M HAVING THE SAME PROBLEM AS THE VECHICLE THAT ARE COVERED. NO SAFETY DEFECT. *AK
THE WINDSHIELD WIPERS FAIL INTERMITTENTLY, GMC RECALL THE DEFECTIVE MODULE IN NEWER MODEL VEHICLES BUT REFUSES TO REPLACE THE SAME MODULE IN OLDER VEHICLES, CONSUMER REPLACED THE MODULE HIMSELF AFTER A NEAR ACCIDENT. NLM
RECALL 98V150001/WINDSHIELD WIPER WIRING: VEHICLEWINDSHIELD WIPERS WORK INTERMITTENTLY. PROBLEM CAN RESULT IN INOPERATIVE WINDSHIELD WIPERS REDUCING A DRIVER'S VISIBILITY, AND INCREASING RISK OF A VEHICLE CRASH. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER RECALL DUE TO VIN. PLEASE FEE…
Read full complaint
RECALL 98V150001/WINDSHIELD WIPER WIRING: VEHICLEWINDSHIELD WIPERS WORK INTERMITTENTLY. PROBLEM CAN RESULT IN INOPERATIVE WINDSHIELD WIPERS REDUCING A DRIVER'S VISIBILITY, AND INCREASING RISK OF A VEHICLE CRASH. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER RECALL DUE TO VIN. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
COOLANT LEAKING FROM BACK OF INTAKE MANIFOLD,AUTO MECH. TELL ME THAT THIS IS A COMMON PROBLEM WITH THE VORTEX MOTOR, WHEN I TELL THE MECHANIC THAT MY TRUCK IS LEAKING ANTI-FREEZE ,EVERY MECHANIC HAS SAID THAT HE KNOWS JUST WHERE IT IS LEAKING AND THEY ARE RIGHT EVERY TIME; IS THIS A DEFECT IN THIS MOTOR AND WHAT CAN I DO ABOUT I…
Read full complaint
COOLANT LEAKING FROM BACK OF INTAKE MANIFOLD,AUTO MECH. TELL ME THAT THIS IS A COMMON PROBLEM WITH THE VORTEX MOTOR, WHEN I TELL THE MECHANIC THAT MY TRUCK IS LEAKING ANTI-FREEZE ,EVERY MECHANIC HAS SAID THAT HE KNOWS JUST WHERE IT IS LEAKING AND THEY ARE RIGHT EVERY TIME; IS THIS A DEFECT IN THIS MOTOR AND WHAT CAN I DO ABOUT IT? THANKS R. MCLAUGHLIN. MC LAUGHLIN E
VEHICLE EXPERIENCING PROBLEM WITH ENGINE STALLING. VEHICLE TAKEN TO DEALER SHOP AND INFORMED CONSUMER THAT PROBLEM WAS DUE TO A DIESEL INJECTOR PUMP FAILURE. *AK
WHILE DRIVING ABOUT 20-25MPH VEHICLE SLID ON ICE AND HIT A POLE HEAD-ON. UPON IMPACT, DRIVER'S SIDE AIRBAG DID NOT DEPLOY. NO ONE HAS SEEN VEHICLE. *AK
Official recalls
298V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V057000 · Vehicle Speed Control
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.