VEHICLE LEAKS ANTI-FREEZE FROM VICINITY OF UPPER INTAKE MANIFOLD. CHRONIC PROBLEM. OCCURS AFTER VEHICLE HAS SET FOR 3-5 HOURS AFTER RUNNING. DOES NOT APPEAR TO BE LEAKING INTO CRANKCASE. HAD SYSTEM PRESSURE TESTED. TOLD TO MONITOR TO SEE IF IT IS GETTING INTO OIL. LEAKS ABOUT 1-2 TABLESPOONS PER SHUT DOWN. ENOUGH TO BE NOTICEABL…
Read full complaint
VEHICLE LEAKS ANTI-FREEZE FROM VICINITY OF UPPER INTAKE MANIFOLD. CHRONIC PROBLEM. OCCURS AFTER VEHICLE HAS SET FOR 3-5 HOURS AFTER RUNNING. DOES NOT APPEAR TO BE LEAKING INTO CRANKCASE. HAD SYSTEM PRESSURE TESTED. TOLD TO MONITOR TO SEE IF IT IS GETTING INTO OIL. LEAKS ABOUT 1-2 TABLESPOONS PER SHUT DOWN. ENOUGH TO BE NOTICEABLE
NHTSA ODI #10108205
Mileage unknown · Sep 4, 2002
Engine And Engine CoolingEquipmentExterior Lighting
THE BACK UP LIGHTS WERE INOPERATIVE, THE DEALER REPLACED THE NEUTRAL SAFETY SWITCH. NLM
NHTSA ODI #567316
Mileage unknown · Oct 10, 2001
Engine And Engine CoolingPower Train
THE TRANMISSION WAS REPLACED AT 43429 MILES, CONSUMER BELIEVES THERE IS A DEFECT IN WORKMANSHIP OR MATERIAL WHICH MAY HAVE CAUSED THIS FAILURE AT SUCH LOW MILEAGE.*JB
NHTSA ODI #563677
Mileage unknown · Aug 14, 2001
Engine And Engine CoolingPower Train
AT 42,000 MILES TRUCK NEEDED A NEW TRANSMISSION AND AT 66,151 MILES TRUCK NEEDED A NEW MOTOR.
NHTSA ODI #9003701
Mileage unknown · Sep 8, 2000
Engine And Engine Cooling
CONSUMER WAS TRAVELING ON HIGHWAYAND AND WAS SMELLING OIL, THERE WAS OIL LEAKING FROM UNDERNEATH VEHICLE. SEALS WERE LEAKING. CONSUMER TOOK VEHICLE BACK TO THE DEALERSHIP, AND THE MECHANIC REPLACED SEALS. *AK
NHTSA ODI #870043
Mileage unknown · Feb 4, 2000
Engine And Engine Cooling
BLOWER MOTOR NOISE. *AK
NHTSA ODI #718314
Mileage unknown · Nov 23, 1998
Engine And Engine Cooling
AT VARIOUS SPEEDS THE ENGINE WILL CUT OFF WITHOUT WARNING. DEALER CAN'T FIND THE PROBLEM. *AK
NHTSA ODI #831194
Mileage unknown · Oct 27, 1997
Engine And Engine Cooling
MAIN SEAL IN THE EXHAUST SYSTEM FAILED.
NHTSA ODI #605218
Mileage unknown · Aug 29, 1997
Engine And Engine CoolingVehicle Speed Control
COOLER LINE CONNECTION FAILED.
NHTSA ODI #605370
Mileage unknown · Feb 28, 1997
Engine And Engine CoolingFuel System, GasolinePower TrainFire
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
1996 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration