NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
41 reportsClear category filter84,068 miles · Aug 1, 2005
Service Brakes, Hydraulic
DT: THE CONSUMER STATES THERE IS MASSIVE RUST ON THE REAR BRAKE LINE. THIS CAUSED THE BRAKE LINE TO RUPTURE. BRAKE FLUID WAS LEAKING OUT, CAUSING A PROBLEM WHILE TRYING TO BRAKE. THE SERVICE DEALER STATED THE BRAKE LINE NEEDED TO BE REPLACED. *AK THE DEALER DID NOT REMOVE THE OLD BRAKE LINE WHEN THEY INSTALLED A NEW ONE. …
Read full complaint
DT: THE CONSUMER STATES THERE IS MASSIVE RUST ON THE REAR BRAKE LINE. THIS CAUSED THE BRAKE LINE TO RUPTURE. BRAKE FLUID WAS LEAKING OUT, CAUSING A PROBLEM WHILE TRYING TO BRAKE. THE SERVICE DEALER STATED THE BRAKE LINE NEEDED TO BE REPLACED. *AK THE DEALER DID NOT REMOVE THE OLD BRAKE LINE WHEN THEY INSTALLED A NEW ONE. *JB
NHTSA ODI #10127443
42,000 miles · May 11, 2004
Service Brakes, Hydraulic
METAL BRAKE LINE RUSTED OUT AND RUPTURED CAUSING PARTIAL BRAKE FAILURE. DEALER REPLACED FAILED BRAKE LINE.
NHTSA ODI #10072432
Mileage unknown · Feb 25, 2004
Exterior LightingParking BrakeService Brakes, Hydraulic
#1, I SPENT 1,164.73 TO HAVE MY ANTI-LOCK BRAKES REPAIRED AT A DEALER. I FOUND A SAFETY RECALL OF 1.4 MILLION REPORTS OF BRAKE FAILURE,WITH KELSY-HAVE PARTS ("KCB4"AND "EBC4"UNITS).WHY IF I HAD TO SPEND OVER $ 1,100.00 TO HAVE MY TRUCK REPAIRED WAS I NOT NOTIFIED????? #2 MY EMERGENCY FLASHERS BUTTON IS JAMMED AND THE DEALER WAN…
Read full complaint
#1, I SPENT 1,164.73 TO HAVE MY ANTI-LOCK BRAKES REPAIRED AT A DEALER. I FOUND A SAFETY RECALL OF 1.4 MILLION REPORTS OF BRAKE FAILURE,WITH KELSY-HAVE PARTS ("KCB4"AND "EBC4"UNITS).WHY IF I HAD TO SPEND OVER $ 1,100.00 TO HAVE MY TRUCK REPAIRED WAS I NOT NOTIFIED????? #2 MY EMERGENCY FLASHERS BUTTON IS JAMMED AND THE DEALER WANTS 485.00 TO REPAIR. I HAD THE WINDSHIELD WIPER REPAIRED. WHY IS MY EMERGENCY EQUIPMENT FAILING? AND THERE IS NO RECALL NOTICE!!!! #3 MY EMERGENCY BRAKE CABLE AND HANDLE-BOTH BROKE. HOW MUCH IS A DEALER GOING TO RIP ME OFF TO REPAIR. #4 I HAD TO REPAIR THE COLD SOLDER JOINTS ON MY HOT/COLD SWITCH SO MY A/C WOULD RUN COLD. ONCE AGAIN THE DEALER WANTED TO REPLACE THE WHOLE UNIT-"RIP ME OFF!!" #5 WHY AFTER ALMOST 100 YEARS CANT A CAR MAKER BUILD THEIR CARS BETTER RATHER THAN CAUSING THE CONSUMER TO KEEP THE PARTS/SERVICE INDUSTRY BOOMING. IF MY OLD MAN WASN'T SHOT BY A ?!@#$% FIGHTER PLANE I WOULD BUY FROM THE ?!@#$%, BUT I HAVE NO CHOICE BUT TO BUY AMERICAN (BECAUSE I AM ONE)!!!!!!!!!!!!!!!!! #6 ONE LAST THING WHEN I HAD MY FUEL INJECTORS "CLEANED" THE F/N DEALER JUST PUMPED ALMOST 60 LBS OF AIR IN MY TIRES.(SOME CLEANING)??????*AK
NHTSA ODI #10058938
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicUnknown Or Other
AC FAILURE AT 20,000 MILES - ABS FAILURE AT 90,000 MILES- INTAKE MANIFOLD GASKET AT 95,000 MILES- WINSHIELD WIPER FAILURE AT 95,000 MILES- POWER WINDOW FAILURE AT 100,000 MILES.
NHTSA ODI #10069061
Mileage unknown · Dec 24, 2003
Service Brakes, Hydraulic
WHEN BRAKING THE BRAKE PEDAL WENT TO THE FLOOR. THE DRIVER HAD TO PUMP THE BRAKE PEDAL TO STOP THE VEHICLE. *AK THE VEHICLE DID NOT KEEP BRAKE FLUID IN THE RESERVOIR TANK AND THE FLUID HAD RUN OUT ON THE TIRES, THERE WAS PULLING AND THE INSIDE OF THE RIGHT FRONT TIRES WERE RUINED FROM THE BRAKE FLUID. WHEN THE PULLING WAS F…
Read full complaint
WHEN BRAKING THE BRAKE PEDAL WENT TO THE FLOOR. THE DRIVER HAD TO PUMP THE BRAKE PEDAL TO STOP THE VEHICLE. *AK THE VEHICLE DID NOT KEEP BRAKE FLUID IN THE RESERVOIR TANK AND THE FLUID HAD RUN OUT ON THE TIRES, THERE WAS PULLING AND THE INSIDE OF THE RIGHT FRONT TIRES WERE RUINED FROM THE BRAKE FLUID. WHEN THE PULLING WAS FELT A NOISE WOULD BE PRESENT. *SC *JB
NHTSA ODI #10048299
Mileage unknown · Feb 4, 2002
Service Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #757753
Mileage unknown · Mar 28, 2001
Service Brakes, Hydraulic
ABS LIGHT WENT ON PERMANTLY AND ABS DIDNOT WORK HAD TO HAVE MOTOR REPLACED BECAUSE OF MOTOR AND VALVE FAILURE FEB 2000, SAME PROBLEM HAPPENED IN JULY 2000 WITH THE SAME RESULTS AND THE MOTOR HAD TO BE REPLACED AGAIN, NOW HAS HAPPEN A THIRD TIME WITH THE SAME PROBLEM AND SAME SOLUTION MARCH 2001, THERE IS NO REASON THIS UNIT SHOU…
Read full complaint
ABS LIGHT WENT ON PERMANTLY AND ABS DIDNOT WORK HAD TO HAVE MOTOR REPLACED BECAUSE OF MOTOR AND VALVE FAILURE FEB 2000, SAME PROBLEM HAPPENED IN JULY 2000 WITH THE SAME RESULTS AND THE MOTOR HAD TO BE REPLACED AGAIN, NOW HAS HAPPEN A THIRD TIME WITH THE SAME PROBLEM AND SAME SOLUTION MARCH 2001, THERE IS NO REASON THIS UNIT SHOULD HAVE TO BE REPLACED THREE TIMES IN 13 MONTHS. *AK
NHTSA ODI #743187
Mileage unknown · Oct 6, 2000
Service Brakes, HydraulicCrash
CONSUMER WAS INVOLVED IN REAR END ACCIDENT DUE TO FAILURE OF BRAKES THAT DID NOT ACTUATE.THERE WAS A HARD APPLICATION OF BRAKES .*AK *SLC
NHTSA ODI #872455
Mileage unknown · May 24, 2000
Service Brakes, Hydraulic
INTERMITTENTLY WHEN BRAKES ARE APPLIED ABS LIGHT ILLUMINATES. VEHICLE BEGINS TO JUMP, AND BRAKES LOCK UP, RESULTING IN EXTENDED STOPPING DISTANCE. *AK
NHTSA ODI #862451
Mileage unknown · Apr 5, 2000
Service Brakes, HydraulicVisibility
ABS BRAKE SYSTEM FAILS IN SLIPPERY CONDITIONS. BRAKE PEDAL GOES ALMOST TO FLOOR AND TRUCK FEELS LIKE IT WONT STOP . HAVE ALMOST HAD ACCIDENTS A FEW TIMES WHEN THERE SHOULD HAVE BEEN PLENTY OF TIME TO STOP. WHEN THIS HAPPENS THERE IS A GROWLING NOIS FROM UNDER THE CAR. FRONT BRAKES WEAR OUT REAR BRAKES HARDLY WORN AFTER 85000 …
Read full complaint
ABS BRAKE SYSTEM FAILS IN SLIPPERY CONDITIONS. BRAKE PEDAL GOES ALMOST TO FLOOR AND TRUCK FEELS LIKE IT WONT STOP . HAVE ALMOST HAD ACCIDENTS A FEW TIMES WHEN THERE SHOULD HAVE BEEN PLENTY OF TIME TO STOP. WHEN THIS HAPPENS THERE IS A GROWLING NOIS FROM UNDER THE CAR. FRONT BRAKES WEAR OUT REAR BRAKES HARDLY WORN AFTER 85000 MILES AS THOUGH THEY ARE NOT BEING USED. WIPER MOTER STOPES INTERMITTANTLY IN RAIN . HIGH SPEED DOES NOT WORK. WHEN NOT WORKING CANNOT DRIVE CAR IN RAIN . HAVE HAD STOP WHILE DRIVING WHICH IS DANGEROUS. FOUND THAT YOU HAVE LISTED A RECALL . HOWEVER THE GMC WEB SITE DID NOT OFFER THIS INFORMATION. AS SECOND OWNER OF RECORD I SHOULD HAVE BEEN NOTIFIED . MY DAUGHTER WAS FIRST OWNER AND TO MY KNOWLEDGE SHE WAS NEVER NOTIFIED OF ANY RECALLS.
NHTSA ODI #721081
Official recalls
6Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Dec 13, 1995
IF BOTH THE LAP-BELT AND SHOULDER-BELT ENERGY MANAGEMENT LOOPS ON THE FRONT SEAT BELT ASSEMBLIES RELEASE AT OR NEAR THE SAME TIME, ACCELERATION FORCES CAN CAUSE THE BUCKLE RELEASE MECHANISM TO ACTIVATE AND ALLOW THE BUCKLE TO SEPARATE FROM THE LATCH.
Consequence & remedy
Consequence: IF THE BUCKLE RELEASED, THE SYSTEM WOULD FAIL TO PROVIDE ADEQUATE OCCUPANT RESTRAINT PROTECTION.
Remedy: DEALERS WILL REMOVE THE STITCHING THAT CREATES THE ENERGY MANAGEMENT LOOP IN THE SHOULDER BELT(S).
Dec 13, 1995
THESE VEHICLES WERE BUILT WITH FRONT SEAT BELT SYSTEMS WITH NO ENERGY MANAGEMENT LOOPS AND MAY NOT MEET THE HEAD INJURY CRITERIA REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANTS OF THESE SEATS MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE RETRACTOR PORTION OF THE SEAT BELT ASSEMBLY(S) WITH ONE HAVING THE NEWLY DESIGNED ENERGY-MANAGEMENT TWIN-LOOP SYSTEM.
Jul 26, 1995
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence & remedy
Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
Feb 16, 1995
DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
Illustration