PASSENGER SEAT WOULD NOT LOCK INTO TRACK, ALLOWING IT TO SLIDE FORWARD INTERMITTENTLY, THEN REGULARLY UPON BRAKING. THIS CAUSED THE PASSENGER DISCOMFORT FROM THE FORCE OF THEIR WEIGHT AND THE SEAT PULLING AGAINST THE SEAT AND SHOULDER BELTS. SERVICE TECHNICIAN REPORTED A LAGE NUMBER OF SIMILAR FAILURES AND REPLACEMENTS. SAID…
Read full complaint
PASSENGER SEAT WOULD NOT LOCK INTO TRACK, ALLOWING IT TO SLIDE FORWARD INTERMITTENTLY, THEN REGULARLY UPON BRAKING. THIS CAUSED THE PASSENGER DISCOMFORT FROM THE FORCE OF THEIR WEIGHT AND THE SEAT PULLING AGAINST THE SEAT AND SHOULDER BELTS. SERVICE TECHNICIAN REPORTED A LAGE NUMBER OF SIMILAR FAILURES AND REPLACEMENTS. SAID SINCE IT WAS A SAFETY ISSUE THEY COULD NOT ATTEMPT TO DIAGNOSE AND REPAIR, THEY HAD TO REPLACE THE ENTIRE ASSEMBLY. COST: $238.78 . *AK
NHTSA ODI #720097
Mileage unknown · Jan 14, 2000
Seats
DRIVER'S SIDE POWER SEAT FRAME BROKE WHILE IN USE. THE SEAT WOULD ROCK BACKWARDS & FORWARDS WHEN THE BRAKES ARE APPLIED. THIS CAUSES PROBLEM FOR THE DRIVER. *AK
NHTSA ODI #855009
Mileage unknown · Jan 12, 2000
Seats
THE LEFT FRONT SEAT ANCHOR BROKE WHILE DRIVING. WHEN IT GAVE AWAY THE SEAT LEANED BACK MORE THATN USUAL. IF BOTH ANCHOR IN THE FRONT HAD BROKE AT THE SAME TIME THE SEAT MORE THAN LIKELY WOULD HAVE FELL BACKWARDS DUE TO MY WEIGHT IN THE SEAT. DURING A DISCUSSION WITH A LOCAL CHEVROLET SERVICE REP MY WIFE WAS TOLD THAT THEY H…
Read full complaint
THE LEFT FRONT SEAT ANCHOR BROKE WHILE DRIVING. WHEN IT GAVE AWAY THE SEAT LEANED BACK MORE THATN USUAL. IF BOTH ANCHOR IN THE FRONT HAD BROKE AT THE SAME TIME THE SEAT MORE THAN LIKELY WOULD HAVE FELL BACKWARDS DUE TO MY WEIGHT IN THE SEAT. DURING A DISCUSSION WITH A LOCAL CHEVROLET SERVICE REP MY WIFE WAS TOLD THAT THEY HAVE HAD SOME PROBLEMS WITH THE SEAT FRAMES IN THIS VEHICLE. IF THERE TRUELY IS A PROBLEM OF THIS NATURE SOMEONE OTHER THAN THE MANUFACTURER SHOULD PROBABLY BE LOOKING INTO IT. *AK
NHTSA ODI #717275
Mileage unknown · Jan 7, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
MASTER BRAKE CYLINDER LEAKING. NLM
NHTSA ODI #550277
Mileage unknown · Dec 22, 1999
Seats
SHEET METAL ON BOTTOM OF SEAT IS EXTREMELY THIN AND BROKEWHERE IT IS BOLTED TO THE TRACK.IF THIS HAPPENED WHILE DRIVING A SERIOUS ACCIDENT COULD HAVE OCCURRED REBOLTED SEAT TO TRACK. *AK
NHTSA ODI #716353
Mileage unknown · Sep 1, 1999
Seats
WHILE DRIVING THE DRIVERS SEAT MALFUNTIONED AND BROKE.DEALER WAS CONTACTED AND WILL FIX THE PROBLEM AT OWNER'S EXPENSE. *AK
NHTSA ODI #846327
Mileage unknown · Jun 21, 1999
Seats
DRIVER'S SIDE SEAT BROKE FROM THE TRACKS, CAUSING THE CONSUMER TO ROCK. THIS WAS THE FOURTH TIME THAT DRIVER'S SEAT BROKE FROM THE TRACKS. ALSO, PASSENGER'S SIDE SEAT BROKE ON JUNE 21, 1999. DEALER IS AWARE OF THE PROBLEM, AND CAN'T DETERMINE THE CAUSE. *AK
NHTSA ODI #840588
Mileage unknown · Apr 11, 1999
Seats
THE SEAT METAL CRACKED ON BOTH SIDES ON FRONT OF SEAT, SOMETIMES THE EDGES CATCH ON EACH OTHER AND THEN SUDDENLY RELEASES WHEN MOTION IS STARTED. THIS HAPPENED AT A TRAFFIC LIGHT AND FOUND MYSELF LOOKING AT THE HEADLINER OF THE TRUCK (THE SHOULDER BELT KEEPS YOU FROM GOING FORWARD, NOT BACKWARDS) THE SEAT BACK KEEPS YOU FROM GO…
Read full complaint
THE SEAT METAL CRACKED ON BOTH SIDES ON FRONT OF SEAT, SOMETIMES THE EDGES CATCH ON EACH OTHER AND THEN SUDDENLY RELEASES WHEN MOTION IS STARTED. THIS HAPPENED AT A TRAFFIC LIGHT AND FOUND MYSELF LOOKING AT THE HEADLINER OF THE TRUCK (THE SHOULDER BELT KEEPS YOU FROM GOING FORWARD, NOT BACKWARDS) THE SEAT BACK KEEPS YOU FROM GOING BACKWARDS. WHAT HAPPENS IS THE LOWER SEAT CUSHION TILTS UP TOWARDS THE STEERING WHEEL WHICH IN TURN CAN PULL THE FEET OFF THE CONTROLS AND AT THE SAME TIME THE CHEST AND HEAD GOES BACKWARDS, THIS COULD CAUSE A LOSS OF CONTROL ESPECIALLY IF THE HANDS SLIP OFF THE STEERING. I SAW THAT THERE WAS AN INVESTIGATION INTO THIS, BUT NO RECALL. I WILL CONTACT THE DEALER AGAIN TO SEE IF THEY HAVE A SOLUTION FOR THIS.
NHTSA ODI #705512
Mileage unknown · Feb 18, 1998
Seats
SEAT BOLT FAILED CAUSING SEAT TO BECOME LOOSE FROM THE TRACK.
NHTSA ODI #530664
Mileage unknown · Dec 16, 1997
Seats
WHILE DRIVING THE TRUCK THE SEAT ON THE DRIVER'S STARTED TO TILT BACKWARDS DUE TO THE CRACKING OF THE SEAT FRAME. THE DEALER WILL BE REPAIRING THE SEAT. *AK
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
IF BOTH THE LAP-BELT AND SHOULDER-BELT ENERGY MANAGEMENT LOOPS ON THE FRONT SEAT BELT ASSEMBLIES RELEASE AT OR NEAR THE SAME TIME, ACCELERATION FORCES CAN CAUSE THE BUCKLE RELEASE MECHANISM TO ACTIVATE AND ALLOW THE BUCKLE TO SEPARATE FROM THE LATCH.
Consequence & remedy
Consequence: IF THE BUCKLE RELEASED, THE SYSTEM WOULD FAIL TO PROVIDE ADEQUATE OCCUPANT RESTRAINT PROTECTION.
Remedy: DEALERS WILL REMOVE THE STITCHING THAT CREATES THE ENERGY MANAGEMENT LOOP IN THE SHOULDER BELT(S).
THESE VEHICLES WERE BUILT WITH FRONT SEAT BELT SYSTEMS WITH NO ENERGY MANAGEMENT LOOPS AND MAY NOT MEET THE HEAD INJURY CRITERIA REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANTS OF THESE SEATS MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE RETRACTOR PORTION OF THE SEAT BELT ASSEMBLY(S) WITH ONE HAVING THE NEWLY DESIGNED ENERGY-MANAGEMENT TWIN-LOOP SYSTEM.
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence & remedy
Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
1995 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration