← New search

2003 GMC Sierra 3500

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Sierra 3500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 6 of 7 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports1 injury reports

Power Train complaints

1 reports
Clear category filter
21,503 miles · Jan 25, 2012
Power TrainService Brakes, Hydraulic

I RECENTLY HAD A BRAKE FAILURE ON MY 2003 GMC SIERRA 3500 SERIES TRUCK. I WAS DRIVING WHEN MY BRAKES GAVE OUT. THE PEDAL WENT TO THE FLOOR AND I WAS BARELY ABLE TO STOP BEFORE STRIKING A PARKED CAR. I TOOK IT TO THE DEALER AND WAS TOLD THAT MY BRAKE LINES AND CALIPERS ARE CORRODED AND IN NEED OF REPLACEMENT FOR A $4200. I HA…

Read full complaint

I RECENTLY HAD A BRAKE FAILURE ON MY 2003 GMC SIERRA 3500 SERIES TRUCK. I WAS DRIVING WHEN MY BRAKES GAVE OUT. THE PEDAL WENT TO THE FLOOR AND I WAS BARELY ABLE TO STOP BEFORE STRIKING A PARKED CAR. I TOOK IT TO THE DEALER AND WAS TOLD THAT MY BRAKE LINES AND CALIPERS ARE CORRODED AND IN NEED OF REPLACEMENT FOR A $4200. I HAD THE BRAKES REPLACED LAST FEBRUARY AND PUT LESS THAN 1000 MILES BEFORE THIS INCIDENT. THE REAR BRAKE PADS WHICH WERE REPLACED THEN NEEDED TO BE REPLACED BECAUSE OF CORROSION ISSUES. I HAVE HAD TO REPLACE THE BRAKES ON THIS TRUCK 4 TIMES SINCE I PURCHASED IT EACH TIME BECAUSE OF CORROSION ISSUES. I HAVE BEEN TOLD BY GM THAT I DO NOT DRIVE THE TRUCK ENOUGH. I AM AFRAID TO DRIVE IT FOR TWO REASONS 1. IT MIGHT NOT STOP WHEN I NEED IT TO AND 2. EVERYTIME I DRIVE IT ENDS UP COSTING ME MORE MONEY. THE TRANSMISSION LINES WERE REPLACED LAST SUMMER FOR THE SAME ISSUE. THIS TRUCK HAS COST ME OVER $20,000 IN REPAIRS SINCE 2005 NOT INCLUDING MAINTENANCE ISSUES. WHEN I CONTACTED GM CUSTOMER SERVICE THEY WERE ABSOLUTELY NO HELP. I WAS TOLD I DO NOT DRIVE IT ENOUGH AND THE FACT THAT THE TRUCK IS OLDER IT IS A PART OF LIFE. THEY WOULD NOT EVEN ACKNOWLEDGE THAT THEY HAVE A PROBLEM. I WAS TOLD THAT THE NHTSA IS CONDUCTING AN INVESTIGATION INTO THIS MATTER WITH GM. IF YOU NEED ANY HELP PLEASE CALL ME I WOULD GLADLY HELP IN THIS MATTER. *TR

NHTSA ODI #10445199

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.