IllustrationTHERE WAS NO EVENT THAT WAS NOTED THAT WOULD CAUSE THE SEPARATION OF THE TIRE TREAD FROM THE SIDEWALL. A MAJOR LEAK WAS NOTED. THE SPLIT WAS LOCATED AT THE POINT OF SIDEWALL TO TREAD JOINT. THE TIRE HAS >9/32 OF TREAD LEFT ON THE TIRE. I AM AT A LOSS TO REPLACE THE TIRE. NO TRAUMA WAS INFLICTED ON THE TIRE. *NM
2002 GMC Sierra 3500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 20 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Parking Brake. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports1 injury reports
What owners actually said
20 reportsTHIS COMPLAINT IS REGARDING NHTSA ID # 05V161000 AND GM RECALL # 05042. THE ABOVE IS FOR A DEFECT IN THE PARKING BRAKE WHICH CAUSES PREMATURE WEAR. THE RECALL ONLY APPLIES TO MANUAL SHIFT TRANSMISSIONS. I HAVE THIS SAME PROBLEM BUT HAVE AN AUTOMATIC TRANSMISSION. I BELIEVE THIS RECALL SHOULD ALSO APPLY TO MY VEHICLE SINCE A PARK…
Read full complaint
THIS COMPLAINT IS REGARDING NHTSA ID # 05V161000 AND GM RECALL # 05042. THE ABOVE IS FOR A DEFECT IN THE PARKING BRAKE WHICH CAUSES PREMATURE WEAR. THE RECALL ONLY APPLIES TO MANUAL SHIFT TRANSMISSIONS. I HAVE THIS SAME PROBLEM BUT HAVE AN AUTOMATIC TRANSMISSION. I BELIEVE THIS RECALL SHOULD ALSO APPLY TO MY VEHICLE SINCE A PARKING BRAKE IS ALSO INSTALLED ON MY VEHICLE AND IT IS ALSO DEFECTIVE. IF A PARKING BRAKE IS NOT NEEDED ON MY VEHICLE FOR SAFETY THAN WHY IS ONE INSTALLED? *JB
THE PARKING BRAKE WAS ON AND THE VEHICLE WAS PARKED ON A SLIGHT INCLINE AND WITHOUT WARNING THE VEHICLE ROLLED DOWN THE STREET AND CRASHED INTO A TREE. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE BRAKE PADS NEEDED TO BE REPLACED ON THE PARKING BRAKES DUE TO WEAR AND TEAR. *AK
DEALERSHIP INFORMED THE CONSUMER THAT THE EMERGENCY PARKING BRAKE WORE OUT. THIS COULD POTENTIALLY CAUSE THE VEHICLE TO ROLL BACK/FORWARD ON A INCLINE WITHOUT WARNING. DEALERSHIP WAS NOT ABLE TO RESOLVE THE PROBLEM. *AK RETAINER ON EMERGENCY BRAKE FAILED. *LA
AIRBAGS DID NOT DEPLOY WHEN VEHICLE WENT OFF ROAD AND RASHED; ON-STAR DID NOT FUNCTION EITHER MANUALLY OR UPON IMPACT.*AK
WHILE DRIVING APPROXIMATELY 55 MPH REAR RIGHT TIRE BLEW OUT. CONSUMER MANAGED TO PULL VEHICLE OVER, AND STOPPED TO CHECK THE TIRE. NOTICED THAT TREAD HAD SEPARATED FROM THE RIGHT REAR TIRE. BRIDGESTONE TIRE, SIZE 285/75R16. *AK
WHILE DRIVING THE CONSUMER SMELLED FUMES INSIDE THE VEHICLE. THE DEALER WAS NOTIFIED. *NLM
CONSUMER STATES WHILE DRIVING AT HIGHWAY SPEED THE VEHICLE PULLS VIOLENTLY TO THE RIGHT. *NLM *DT
A FUEL LEAK UNDERNEATH VEHICLE. VEHICLE HAS NOT BEEN INSPECTED BY DEALERSHIP. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
VEHICLE BOUNCES ALL OVER THE ROAD, BOTH OUTSIDE MIRRORS VIBRATE DUE TO THIS. DEALER HAS BALANCED TIRES, DID NOT REMEDY THE PROBLEM. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
Official recalls
204V562000 · Equipment Adaptive/mobility
Nov 26, 2004
ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
01V220000 · Interior Lighting
Jun 26, 2001
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.
Consequence & remedy
Consequence: THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.