ABOUT 4 YEARS AGO I HAD PROBLEMS WITH MY BRAKE BOOSTER SYSTEM ON MY TRUCK WHEN THE BRAKES FAILED AND IT WAS HARD TO STOP THE TRUCK. I HAD THE BRAKE BOOSTER REPLACED TWO TIMES THEN HAD TO HAVE THE POWER STEERING PUMP REPLACED AS THIS IS CONNECTED TO MY BRAKE SYSTEM. ABOUT A YEAR AFTER I HAD THIS WORK DONE GMC RECALLED THE POWER S…
Read full complaint
ABOUT 4 YEARS AGO I HAD PROBLEMS WITH MY BRAKE BOOSTER SYSTEM ON MY TRUCK WHEN THE BRAKES FAILED AND IT WAS HARD TO STOP THE TRUCK. I HAD THE BRAKE BOOSTER REPLACED TWO TIMES THEN HAD TO HAVE THE POWER STEERING PUMP REPLACED AS THIS IS CONNECTED TO MY BRAKE SYSTEM. ABOUT A YEAR AFTER I HAD THIS WORK DONE GMC RECALLED THE POWER STEERING PUMP ON MY TRUCK. NOW I AM HAVE PROBLEMS WITH THIS SYSTEM AGAIN. IF I TURN MY TRUCK RIGHT OR LEFT THE BRAKE ACTIVATE JUST LIKE YOU ARE PUSHING ON THE BRAKE TO STOP. THIS HAS ALMOST CAUSED ME TO HAVE AN ACCIDENT MORE THEM ONCE. I UNDERSTAND FROM OTHER OWNERS THAT THIS SYSTEM HAS A LOT OF PROBLEMS WITH IT AND THE ONLY WAY TO FIX IT IS TO REMOVE THIS SYSTEM AND REPLACE WITH A DIFFERENT TYPE OF SYSTEM. I HOPE YOU CAN HELP ME AND OTHER OWNERS TO GET GMC TO REPAIR OUR BRAKES. *TR
NHTSA ODI #10254211
Mileage unknown · Nov 20, 2002
Service Brakes, Hydraulic
CONSUMER STATED THAT WHEN TRYING TO APPLY THE BRAKES THE BRAKE PEDAL WOULD GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED TS
NHTSA ODI #8023036
Mileage unknown · Jul 2, 2002
Service Brakes, Hydraulic
I HAVE THE MISFORTUNE OF OWNING A 1998 GMC 1 TON DUALLY, THE REAR BRAKE DRUMS HAVE SEALS LOACATED ON THE INBOARD SIDE THAT SEAL AGAINST A SURFACE OF THE AXLE. AS IT IS A FULL FLOAT AXLE, MEANING THERE ARE TAPERED BEARINGS IN THE BRAKE DRUMS THE BEARINGS ARE LUBRICATED WITH AXLE FLUID AND THE SEALS ARE THERE TO PREVENT LEAKAGE OF…
Read full complaint
I HAVE THE MISFORTUNE OF OWNING A 1998 GMC 1 TON DUALLY, THE REAR BRAKE DRUMS HAVE SEALS LOACATED ON THE INBOARD SIDE THAT SEAL AGAINST A SURFACE OF THE AXLE. AS IT IS A FULL FLOAT AXLE, MEANING THERE ARE TAPERED BEARINGS IN THE BRAKE DRUMS THE BEARINGS ARE LUBRICATED WITH AXLE FLUID AND THE SEALS ARE THERE TO PREVENT LEAKAGE OF THE FLUID. THE FAILURE OF A SEAL PROVIDES A FLUID LEAKAGE PATH THAT IS DOWN THE INSIDE SURFACE OF THE DRUM, ACROSS THE SURFACE OF THE DRUM WHICH THE BRAKE LININGS CONTACT AND OUT BETWEEN THE BACKING PLATE AND DRUM. I HAVE HAD 3 SEAL FAILURES ON ONE SIDE AND 2 ON THE OTHER. A FAILURE OF THE SEAL ALLOWS 80W90 AXLE FLUID TO SOAK THE BREAK LININGS, AS THIS IS NOT OBVIOUS, THE FAILURE IS NOTICED BY INCREASED STOPPING DISTANCE AS THE REAR BRAKES ARE RENDERED USELESS BY THE CONTAMINATION WITH AXLE FLUID. SINCE 1-TON TRUCKS ARE UASUALLY SOLD TO PULL OR HAUL THIS IS AN ESPECIALLY DANGEROUS CONDITION, WITH A FULL RATED LOAD THE REAR BRAKES ARE MUCH MORE CRITICAL THAN THAT OF A PASS CAR. I TALKED TO MECHANICS AT GM DEALERSHIPS AND THEY SAY THE SEALS HAVE BEEN A PROBLEM SINCE AS LONG AS THEY CAN REMBER. I'VE SINCE LOOKED AT THE BACKSIDE OF THE REAR TIRES OF DUALLY AND NOTICED THE TELL TALE SIGN OF A FAILED SEAL OF AXLE FLUID STAINS. THERES AN AWFULL LOT OF 1 TON DUALLYS ON THE ROAD WITH NO REAR BRAKES.*AK
ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence & remedy
Consequence: IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Remedy: DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1998 GMC Sierra 3500 Problems, Complaints & Recalls | Skip That Year
Illustration