2024 GMC Sierra 2500

[XXX] has a trailer brake control module issue that causes the trailer brake to periodically disengage and reengage. Unfortunately, I had to drive across the country on a military PCS move with this intermittent failure. GMC has provided numerous surveys to ask about my experience with my new GMC. Overall, the vehicle adequate, and in each survey I have annotated this issue. However, it does not appear the issue is being taken seriously as I have not seen a recall. A trailer brake that intermittently fails is extremely dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 GMC Sierra 2500. The contact stated while driving at an undisclosed speed, another vehicle drove by on the driver's side of the vehicle, and the blind spot alert light illuminated on the passenger's side of the vehicle, even though the vehicle was present on the driver's side. The contact also stated that the failure only occurred when the Adaptive Cruise Control was activated. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was able to duplicate the failure but was unable to provide a fix. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 3.

Towing an RV with solar panels. When the trailer battery becomes fully charged and has a higher charge than the vehicle battery, the trailer brake control module becomes disabled. When this occurs, you have no trailer brakes. Combined weight of truck and RV exceeds 20,000 pounds. Trying to stop with only truck brakes is dangerous, especially if you are on a decent. I not only believe this to be a safety issues, but somebody is going to get killed.

The contact owns a 2024 GMC Sierra 2500. The contact stated while towing a trailer and driving down a hill at approximately 40 MPH, the integrated trailer braking system error message was displayed, and the trailer braking system failed to activate. The vehicle was later taken to the local dealer who was unable to replicate the failure and failure was found. The dealer later informed the contact that the solar panel system on the trailer might have caused the integrated trailer braking system to malfunction. The contact stated that after turning off the solar panel system the failure persisted. The cause of the failure was not yet determined. The manufacturer was not contacted. The failure mileage was 800.

When I connect my 2024 GMC Sierra 2500HD to my camping trailer that has a solar panel and solar charge controller, it causes the factory-installed brake controller inside the truck to malfunction. The trailer brakes connect and disconnect 4 times a minute sending alerts to my dashboard. This is dangerous. My trailer weighs up to 14,000 pounds and would have to rely solely on the truck brakes to slow to a stop. GM put out a Document ID: 6379278 / #23-NA-113 "Information on Trailer Brake Disabled or DTC Stored". However, there is no fix. The GMC dealer said they can't find the service bulletin?! Please make this issue a RECALL. I bought this truck to exclusively tow a trailer and now I can't.

Upon starting our 2024 GMC Sierra 2500HD after towing a camping trailer for approximately 200 miles, the following error notifications would cycle every 20 seconds to 5 minutes: "Check Trailer Wiring" "Service Trailer Brake System" The trailer brake would become disabled after these errors, and sometimes would connect with a "trailer brake connected" message, only to repeat every 20 seconds to a few minutes later. During the 60 minutes in which I drove to an RV dealership to have the problem looked at, on multiple occasions, I had no trailer brakes when braking, or had no trailer brakes until the trailer brakes suddenly connected at below the speed of 35 - 25 MPH. GM has acknowledged document ID: 6420021 and bulletin #23-NA-149 that this could happen when pulling a trailer with a battery, generator, or solar charger that has a higher state of charge than the vehicle battery. This is an extremely unsafe condition that could easily cause a rear-end accident or a jackknife condition of the vehicle/trailer combination. GM has known about this issue since at least June of 2023, and as of September, they have an updated trailer brake controller that is supposed to correct this issue. There should be an immediate recall of the vehicles involved to have the trailer brake module replaced with the updated part.

The contact owns a 2024 GMC Sierra 2500. The contact stated that while driving 30 MPH, the check engine malfunction and Electronic Stability Control system malfunction warning lights illuminated. The contact was inadvertently locked out of the vehicle and was unable to open the tailgate. The contact disconnected the battery to cancel the warning lights; however, the tailgate still failed to open. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 1,000.

When the car is on and in park, there is a button on the front console that drops the tail gate. The truck gives you no indication that the button has been pressed or that the tailgate is open. You can then drive the truck with the tailgate open and have no indication or idea. As a result, it is easy to lose gear out of the truck bed while you are driving. This button is located just above a storage compartment and is easy to press while placing items in this compartment. This is a major safety hazard on the road. There is no option to disable this button or be alerted when you tailgate is open.