On 07/10/2026 at approximately 1:10 a.m., the parked and unoccupied vehicle caught fire while turned off. The vehicle had not been driven for several hours. A neighbor was awakened by the horn/alarm and popping noises, observed fire near the passenger-side cab/engine area, and called 911. The fire rapidly spread throughout the c…
Read full complaint
On 07/10/2026 at approximately 1:10 a.m., the parked and unoccupied vehicle caught fire while turned off. The vehicle had not been driven for several hours. A neighbor was awakened by the horn/alarm and popping noises, observed fire near the passenger-side cab/engine area, and called 911. The fire rapidly spread throughout the cab, engine compartment, rocker-panel areas, wheel wells, and truck bed, creating an explosion hazard and threatening a nearby occupied residence and garage. The fire department extinguished the blaze, but the vehicle was completely destroyed. Before the fire, the vehicle had experienced recurring coolant warnings, a DEF-system warning, and delayed starting associated with the main battery. No smoke, fuel odor, intentional ignition source, charging device, or known external fire source was present before the incident. Weather was calm. The exact failed component and cause remain UNKNOWN. A firefighter stated that the apparent fire origin was near the passenger side of the vehicle. The remains are available for inspection, subject to coordination with the vehicle owner and insurer. The incident has been reported to the fire department, insurer, manufacturer, and NHTSA.
NHTSA ODI #11752275
Mileage unknown · Mar 13, 2026
Electrical System
UI Bulletin #161b is for years 2020 and beyond. But my 2019 is having the same exact issue and the GM dealer will not cover the work as stated in the UI Bulletin #161b
NHTSA ODI #11724160
Mileage unknown · Dec 1, 2025
Electrical SystemFire
My center console wires for the charging pad broke and shorted out causing wires to burn and short the whole system out
NHTSA ODI #11702171
Mileage unknown · Jun 13, 2025
Electrical SystemInjury
The manufacturer placed two 12v batteries to start the truck with one being located on the passenger side just in front of the cowl of the cab. The factory OEM batteries are known to overheat when charging which is exactly what mine did and as the battery boils over with sulfuric acid, the acid is vaporized and ingested into the…
Read full complaint
The manufacturer placed two 12v batteries to start the truck with one being located on the passenger side just in front of the cowl of the cab. The factory OEM batteries are known to overheat when charging which is exactly what mine did and as the battery boils over with sulfuric acid, the acid is vaporized and ingested into the cabin. It’s a diesel so it’s common for me to take my dog in the rear crew cab with me and leave the engine running so the cabin will stay cool in the summer while I work my contractor job. When I let the engine idle with windows up and AC on the overcharged battery introduced the vaporized sulfuric acid into the cabin and rendered the interior deadly toxic. Luckily I was only gone from the truck for about 10 minutes but in this amount of time the acid was very bad and caused burns in my dogs throat and mine while driving home. I can only imagine if this scenario were to take place with kids left in the truck for many reasons to stay cool but could easily turn into a deadly situation. PLEASE look into this before someone or some poor animal is fatally injured or killed.
NHTSA ODI #11666873
87,000 miles · Oct 3, 2024
Electrical SystemEngine And Engine Cooling
The contact owns a 2019 GMC Sierra 2500. The contact stated while driving at various speeds, the vehicle lost motive power. The coolant fan seized and failed to operate as needed. There were no warning lights illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the check engine wa…
Read full complaint
The contact owns a 2019 GMC Sierra 2500. The contact stated while driving at various speeds, the vehicle lost motive power. The coolant fan seized and failed to operate as needed. There were no warning lights illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the check engine warning light was illuminated, and the knock sensor, coolant fan clutch, injector #6, and unstated wiring harness needed to be replaced. The dealer informed the contact that the parts to repair the vehicle were on back order. The vehicle was not repaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 87,000.
NHTSA ODI #11617810
Mileage unknown · Aug 7, 2024
Electrical SystemUnknown Or Other
When it rains, there are puddles of water on the passenger side! Cannot figure out how the water is getting in..my concern is of a potential electrical short/ fire / failure of a system that doesn’t allow me to operate the vehicle safely! Possibly, affecting other functions of the vehicle during operation!
NHTSA ODI #11607154
Mileage unknown · Jun 29, 2024
Electrical SystemFire
Vehicle was last driven on June 23 2024 and parked in my driveway. On the evening of June 29 2024 my horn was blowing in my truck at around 10:30. While I was walking out to the vehicle it was in flames. The fire started from what I understand on the driver’s side behind the dash. Luckily no one was in the vehicle when it happen…
Read full complaint
Vehicle was last driven on June 23 2024 and parked in my driveway. On the evening of June 29 2024 my horn was blowing in my truck at around 10:30. While I was walking out to the vehicle it was in flames. The fire started from what I understand on the driver’s side behind the dash. Luckily no one was in the vehicle when it happened.
NHTSA ODI #11597612
Mileage unknown · Jul 21, 2023
Electrical SystemService Brakes
DEFECTIVE TRAILER BRAKE SWITCH ,WHICH POSES A RISK TO MOTOR VEHICLE SAFETY IF YOU ARE TOWING A TRAVEL TRAILER, WHERE BRAKES FAIL LOCK UP IS POSSIBLE DANGEROUS TO PULL
NHTSA ODI #11533680
Mileage unknown · Jul 14, 2023
Electrical SystemService BrakesUnknown Or Other
TRAILER BRAKE SYSTEM NEEDS SERVICE, WARNING LIGHT CAME ON AND BEEPING LOUD STARTER LAST MONTH 6-2023 , AND MAYBE THE BRAKE CONTROL MODULE IS BAD ? CODE C1117 CAME UP
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.
Remedy: Dealers will replace both RRAB modules, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262557310. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 21, 2026. This recall expands previous NHTSA recall number 26V166.
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 Crew Cab vehicles. The left or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.
Remedy: Dealers will replace the left and right-side RRAB modules, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262549710. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
General Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed July 23, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.
General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.
Consequence & remedy
Consequence: An electrical short-circuit can increase the risk of a fire.
Remedy: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
Consequence & remedy
Consequence: A short-circuit may damage the engine components and increase the risk of fire.
Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2019 GMC Sierra 2500 Problems, Complaints & Recalls | Skip That Year
Illustration