My motor seized and shut off while driving 63 mph on a busy highway going up hill. Truck made it to the top of the hill before it shut off and had to coast to a stop on the side of the road. No warning lights or anything. Rpms locked at 3000 and wouldn’t go up or down until the motor shut off. Switched itself to neutral while it…
Read full complaint
My motor seized and shut off while driving 63 mph on a busy highway going up hill. Truck made it to the top of the hill before it shut off and had to coast to a stop on the side of the road. No warning lights or anything. Rpms locked at 3000 and wouldn’t go up or down until the motor shut off. Switched itself to neutral while it was rolling still and wouldn’t allow my to put the truck in park when stopped. Finally locked itself in park and wouldn’t allow to be shifted to neutral. Dealership said the motor seized and ordered a new one but is on back order
NHTSA ODI #11649726
Mileage unknown · Mar 17, 2025
Electrical SystemEnginePower Train
Truck just made a year old and killed on me in the middle of road. They are saying I need a new engine and maybe transmission. Could not shift truck into neutral, which left me stranded on busy road. For unsafe and had me nervous. Trying to get GMC to buy me out of this vehicle. Had same problem with 6.2 liter prior to this truc…
Read full complaint
Truck just made a year old and killed on me in the middle of road. They are saying I need a new engine and maybe transmission. Could not shift truck into neutral, which left me stranded on busy road. For unsafe and had me nervous. Trying to get GMC to buy me out of this vehicle. Had same problem with 6.2 liter prior to this truck. Engine and transmission was replaced. They promised if I bought new truck, I wouldn’t have the issues and here I am again. This is terrible.
NHTSA ODI #11648892
Mileage unknown · Mar 17, 2025
Power Train
While driving I experienced a loss of forward momentum, and watched the RPMs go up to 3000, wording came on the dash, but I was in traffic and wasn't able to read. I was able to reach next light about 1/4 mile, and stopped. Mad a left turn and within 200 feet, same issue. I pulled over and called OnStar. Towed to dealer. Dealer …
Read full complaint
While driving I experienced a loss of forward momentum, and watched the RPMs go up to 3000, wording came on the dash, but I was in traffic and wasn't able to read. I was able to reach next light about 1/4 mile, and stopped. Mad a left turn and within 200 feet, same issue. I pulled over and called OnStar. Towed to dealer. Dealer put on lift right away, as it was just in for 1st service on Saturday, with 4775 miles. Dealer informed me of a bulletin out for removing transmission pan, and splitting plates to check a ball size for 6th gear, which they found during the computer diagnostic checks. They claim to have a part tomorrow, and will install soon after.
NHTSA ODI #11648853
Mileage unknown · Mar 13, 2025
Power Train
DEF tank heater, diesel exhaust fluid heater has failed which causes the truck to go into a reduced speed until fixed. GM has no parts to fix the issue! at my dealer. Currently there is three or four trucks waiting on the exact same part, it puts the truck into reduced power and speed until part is replaced
NHTSA ODI #11648066
Mileage unknown · Mar 6, 2025
EnginePower Train
Driving on the highway vehicle installed out in the middle of the road lucky I had enough speed to rush to the median. I heard noise coming from the engine while I was coasting off the median on the median. Try to turn on the vehicle no luck.
NHTSA ODI #11646877
Mileage unknown · Mar 6, 2025
Power TrainVehicle Speed Control
The vehicle was traveling over a hill, and it failed to shift gears downwards when traveling over the hill. The vehicle’s RPM’s shot up to 4000+ and jolted the truck forward without pressing the gas pedal. The vehicle made a loud noise and would not accelerate in the middle of the road. The vehicle would only accelerate after gi…
Read full complaint
The vehicle was traveling over a hill, and it failed to shift gears downwards when traveling over the hill. The vehicle’s RPM’s shot up to 4000+ and jolted the truck forward without pressing the gas pedal. The vehicle made a loud noise and would not accelerate in the middle of the road. The vehicle would only accelerate after giving it minimal gas from the pedal. The truck then failed to accelerate on the entire drive to the destination and failed to enter reverse upon arriving to my destination.
NHTSA ODI #11646830
Mileage unknown · Feb 24, 2025
Power Train
First time it happened was on November 28th 2024 around 8pm, turned de engine on, selected the reverse gear and stepped on the gas, the reverse gear was selected but the gear didn't worked at all. I almost hit a car that was passing on the street. I out the gear on drive and got the message "reduced acceleration". I believe that…
Read full complaint
First time it happened was on November 28th 2024 around 8pm, turned de engine on, selected the reverse gear and stepped on the gas, the reverse gear was selected but the gear didn't worked at all. I almost hit a car that was passing on the street. I out the gear on drive and got the message "reduced acceleration". I believe that is a known issue by GM's 10 speed gearbox. The car is at the dealership and they informed me by e-mail that the part transmission valve body is in a "do not sell list". I have concerns about safety because losing power on a 70miles per hour road can be dangerous and not being able to reverse is also very dangerous. There are tons of posts about it in Facebook.
NHTSA ODI #11644523
Mileage unknown · Feb 14, 2025
Power TrainVehicle Speed Control
I have experienced several occurrences of unintended acceleration while operating the vehicle at low speed. Two recent examples; 1) the truck accelerated rapidly while I was driving into my garage, and 2) the truck accelerated suddenly when pulling forward out of a parking spot in the morning shortly after starting the vehicle.…
Read full complaint
I have experienced several occurrences of unintended acceleration while operating the vehicle at low speed. Two recent examples; 1) the truck accelerated rapidly while I was driving into my garage, and 2) the truck accelerated suddenly when pulling forward out of a parking spot in the morning shortly after starting the vehicle. In all cases, a hard application of the brake pedal slowed the vehicle. I considered whether this was operator error, possibly engaging cruise control inadvertently while turning the steering wheel, but the incident this morning does not support that potential cause. I have not spoken to the dealer about this issue.
NHTSA ODI #11642698
24,000 miles · Feb 12, 2025
Power Train
The contact owns a 2024 GMC Sierra 1500. The contact stated while driving 74 MPH, the vehicle inadvertently lost motive power, after which the vehicle was unable to accelerate above 25 MPH. The contact was able to pull over to the shoulder of the roadway and turned off the vehicle. After restarting the vehicle, the vehicle retur…
Read full complaint
The contact owns a 2024 GMC Sierra 1500. The contact stated while driving 74 MPH, the vehicle inadvertently lost motive power, after which the vehicle was unable to accelerate above 25 MPH. The contact was able to pull over to the shoulder of the roadway and turned off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the shift solenoid valve and that the serial data gateway module needed to be reprogrammed. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 24,000.
NHTSA ODI #11642303
Mileage unknown · Feb 11, 2025
Power Train
7500 miles and transmission valve body failed. Parts are on back order with no eta.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2024 GMC Sierra 1500 Problems, Complaints & Recalls | Skip That Year
Illustration