NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
236 reportsClear category filter86,636 miles · Apr 16, 2025
Electronic Stability Control (esc)EngineSteering
The contact owns a 2022 GMC Sierra 1500. The contact stated that while depressing the brake pedal, the transmission would downshift, and the vehicle was aggressively shaking while idling and while depressing the brake pedal. While driving approximately 35 - 40 MPH, the Electronic Stability Control (ESC) Service message was displ…
Read full complaint
The contact owns a 2022 GMC Sierra 1500. The contact stated that while depressing the brake pedal, the transmission would downshift, and the vehicle was aggressively shaking while idling and while depressing the brake pedal. While driving approximately 35 - 40 MPH, the Electronic Stability Control (ESC) Service message was displayed, and the check engine warning light was illuminated. The contact was able to pull over to the side of the road, the vehicle was turned off for a while and then restarted to continue driving. The vehicle was taken to the dealer, who diagnosed that the crankshaft, bearings, and tie rods needed to be replaced due to engine failure. The engine was rebuilt and the vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was 86,636.
NHTSA ODI #11655027
Mileage unknown · Apr 16, 2025
Engine
The engine went out while driving on the highway. Was driving around 60 mph. I almost gone to an accident. GM seemed like they knew of the problem but did not warn none of their customers of this problem. Car only had around 35,000 miles. GM however did swap out the engine. I want to sell and or trade it in, however the year and…
Read full complaint
The engine went out while driving on the highway. Was driving around 60 mph. I almost gone to an accident. GM seemed like they knew of the problem but did not warn none of their customers of this problem. Car only had around 35,000 miles. GM however did swap out the engine. I want to sell and or trade it in, however the year and model lost its value due to the fact of the faulty engines.
NHTSA ODI #11654907
Mileage unknown · Apr 15, 2025
EngineForward Collision Avoidance
repeated mechanical failures of my 2022 GMC Sierra AT4, which I purchased on October 26, 2024, with approximately 37,000 miles on the odometer. The adaptive cruse control is wonderful when it works but I have found even with the sensor clean the truck will slam on brakes on its own causing me to nearly be rear ended. It happens …
Read full complaint
repeated mechanical failures of my 2022 GMC Sierra AT4, which I purchased on October 26, 2024, with approximately 37,000 miles on the odometer. The adaptive cruse control is wonderful when it works but I have found even with the sensor clean the truck will slam on brakes on its own causing me to nearly be rear ended. It happens when driving into the sun and at night. I no longer trust adaptive cruse and use manual cruse. Within just 55 days of ownership, and after driving roughly 4,700 miles, the vehicle experienced a catastrophic engine failure without warning on December 20, 2024. This failure left the truck immobilized in a highly dangerous situation—stuck in the middle of a 65-mph highway at a red light, without the ability to shift into neutral and remove the vehicle from traffic. I was forced to activate the emergency flashers and exit the vehicle, standing helplessly on the side of the road while praying that oncoming drivers would see the truck in time to avoid a potentially deadly accident. The truck was towed to the dealership the following day, December 21, 2024, where it remained for an unacceptable 110 days awaiting a replacement engine. I finally took possession of the repaired vehicle on April 10, 2025. Shockingly, only two days later—after driving just 328 miles—the vehicle suffered a second catastrophic engine failure without warning. The truck is now inoperable once again, sitting in my driveway and in need of a third engine replacement. While the odometer currently reads 42,365 miles. This ongoing situation has been not only a major inconvenience, but also a significant safety concern and financial burden. I am extremely disappointed in the reliability and performance of this vehicle. This level of failure on a vehicle that is still under powertrain warranty is simply unacceptable.
NHTSA ODI #11654863
Mileage unknown · Apr 15, 2025
Engine
I heard a knocking noise in my engine on 4/13/25 and took it to a dealer to diagnose on 4/15/25. I had previously had to have the engine rebuilt due a collapsed lifter at 70,000 miles and I was concerned that the noise was a precursor to a repeat of that problem. Instead, the dealer informed me that problem was a failed connecto…
Read full complaint
I heard a knocking noise in my engine on 4/13/25 and took it to a dealer to diagnose on 4/15/25. I had previously had to have the engine rebuilt due a collapsed lifter at 70,000 miles and I was concerned that the noise was a precursor to a repeat of that problem. Instead, the dealer informed me that problem was a failed connector rod bearing and would require a replacement engine. The service manager said my truck was not safe to drive since it could experience a sudden catastrophic failure on the highway. The truck has 80,000 miles and has been serviced at every single required interval by the original selling dealer. There was no check engine light warning.
NHTSA ODI #11654861
Mileage unknown · Apr 15, 2025
Electrical SystemEngine
While driving my 2022 GMC Sierra Denali 6.2L truck, it somehow turned off. I placed it on neutral and tried to turn on, but it didn’t. I maneuvered to stop at the side of the road, but I was not close enough to the curb making it uncomfortable for others to drive around. I tried again to turn on the truck, but it didn’t. Before …
Read full complaint
While driving my 2022 GMC Sierra Denali 6.2L truck, it somehow turned off. I placed it on neutral and tried to turn on, but it didn’t. I maneuvered to stop at the side of the road, but I was not close enough to the curb making it uncomfortable for others to drive around. I tried again to turn on the truck, but it didn’t. Before and after everything looked good, there were no symptoms or warning lights on the truck. I gave it a break and tried to turn in the truck, but it didn’t. I called GM roadside asst., and I got towed to the closed GM Services. They found out that battery was damaged, and an open starter fuse damaged. They changed the battery, the fuse block, and did the multi-point vehicle inspection (MPVI), and everything seemed good. I picked up my truck, and on my way back home the engine stopped running. At this time I get into a left turn lane, and I was able to stop before the stop line. This time I was in the middle of the road. I turned on the Hazard Warning Lights, but too many cars turning left pass through making it dangerous to my safety and others. I called the service department where my truck was serviced and GM roadside asst., and it got towed to the same service place. All this process was again around 2 hours in the middle of the road. They checked the truck, and found out that the battery was damaged, and an open starter fuse again. They changed, but this time they kept it on test to the next day and the starter fuse was damaged again. They found that the engine was locked, which is why the starter heats up and the amperage consumption increases, opening the fuse, the engine does not turn easily, the oil is at the correct level, it does not indicate low pressure in the initial driving test. They removed the oil pan and found metal particles in the oil and in the pan. After that they removed the rod bearings and can see that they are scratched and overheated, crankshaft scratched as well. Need order a new engine, oil cooler, oil cooler lines.
NHTSA ODI #11654705
Mileage unknown · Apr 15, 2025
Engine
At 61k miles motor siezed. Took 3 months to get a replacement this was 10/24 got truck back Jan 25, drove 3k miles and motor is knocking. Been at dealer since 2/2/2025. Waiting for replacement motor.
NHTSA ODI #11654649
Mileage unknown · Apr 10, 2025
Engine
While driving on a busy highway, the vehicle lost all acceleration. Seconds later, the entire truck shutdown. Lucky, I was able to get into the right hand lane prior to losing complete power, which allowed me to steer the truck onto the shoulder. It appears that an investigation has been launched into vehicles equipped with the …
Read full complaint
While driving on a busy highway, the vehicle lost all acceleration. Seconds later, the entire truck shutdown. Lucky, I was able to get into the right hand lane prior to losing complete power, which allowed me to steer the truck onto the shoulder. It appears that an investigation has been launched into vehicles equipped with the GM 6.2L V8 L87 engine. This catastrophic engine failure not only put me in a fairly unsafe situation, it is costing me $13,800 to replace the engine on a 2022 GMC Sierra Denali.
NHTSA ODI #11653851
40,000 miles · Apr 4, 2025
Engine
The contact owns a 2022 GMC Sierra 1500. The contact stated while driving 50 MPH, the engine seized. The contact was able to cost the vehicle to the side of the road. There were no warning lights illuminated. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed and determined that the engine ne…
Read full complaint
The contact owns a 2022 GMC Sierra 1500. The contact stated while driving 50 MPH, the engine seized. The contact was able to cost the vehicle to the side of the road. There were no warning lights illuminated. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The dealer informed the contact that the parts were on backorder. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was 40,000.
NHTSA ODI #11652840
64,900 miles · Apr 4, 2025
Engine
The contact owns a 2022 GMC Sierra 1500. The contact stated that while driving at approximately 60 MPH, the RPM decreased while the accelerator pedal was depressed, and the vehicle lost motive power. No warning light was illuminated. The contact was able to pull over to the shoulder of the road. The vehicle was towed to the resi…
Read full complaint
The contact owns a 2022 GMC Sierra 1500. The contact stated that while driving at approximately 60 MPH, the RPM decreased while the accelerator pedal was depressed, and the vehicle lost motive power. No warning light was illuminated. The contact was able to pull over to the shoulder of the road. The vehicle was towed to the residence. The vehicle was then towed to a local independent mechanic, where it was diagnosed with a frozen crankshaft and engine seizure. The vehicle was towed to a local dealer, where it was diagnosed and determined that the engine had failed due to metal shavings inside the engine. The dealer determined that the engine needed to be replaced. No further information was available. The manufacturer was made aware of the failure. The failure mileage was approximately 64,900.
NHTSA ODI #11652824
Mileage unknown · Apr 4, 2025
Engine
Truck has 30,000 miles on it. Truck has been in dealer for a new torque converter which they did a fine job. Now it is in for engine problems. They said I need a ew engine and on backorder. This is the Sierra Denali Ultimate and did not expect this from such an expensive truck. I was given a loaner car.
NHTSA ODI #11652746
Official recalls
6Feb 12, 2026
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence & remedy
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:control Module:software
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Feb 6, 2025
General Motors, LLC (GM) is recalling certain 2022 GMC Sierra 1500 vehicles equipped with chrome front grille deflectors. The attachments that hold the front grille deflectors in place may fracture, resulting in grille detachment.
Consequence & remedy
Consequence: A detached front grille deflector may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will reinforce or repair all attachment points on the chrome front grille deflector, free of charge. Owner notification letters were mailed March 17, 2025. Owners may call GM customer service for GMC at 1-800-462-8782. GM's number for this recall is N242490120.
Oct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence & remedy
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Additional source detail variants (2)
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Jun 30, 2022
General Motors (GM) has decided that certain 2022 model year Chevrolet Silverado, and GMC Sierra vehicles equipped with an accessory sport bar. The accessory sport bar contains a high-mounted brake light that may not function. In addition, it may block the vehicle's existing high-mounted brake light. As such, these vehicles may fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: An inoperative high-mounted brake light can reduce visibility to other drivers and increase the risk of a crash.
Remedy: Dealers will inspect the installation of the accessory bar and provide the correct vehicle wiring, if necessary, free of charge. Interim owner notification letters advising owners of the safety risk were mailed on August 10, 2022. Owner notification letters were mailed on January 27, 2023. Owners may contact GM's customer service on 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020.. GM's recall number for this recall is N222368110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration