NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
82 reportsClear category filterMileage unknown · Sep 15, 2026
Electrical System
The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle intermittently failed to start and was jumpstarted on each occurrence. The contact purchased and installed a new battery; however, the failure persisted. The vehicle was taken to an authorized dealer, where it was diagnosed that a corroded ground strap …
Read full complaint
The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle intermittently failed to start and was jumpstarted on each occurrence. The contact purchased and installed a new battery; however, the failure persisted. The vehicle was taken to an authorized dealer, where it was diagnosed that a corroded ground strap had caused an electrical short to the battery. The dealer replaced the ground strap, and the vehicle was repaired. The contact associated the failure with Customer Satisfaction Program: N252515590; however, the VIN was not included. The failure mileage was unknown.
NHTSA ODI #11764474
Mileage unknown · Sep 7, 2026
Electrical SystemEngineVehicle Speed Control
P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to…
Read full complaint
P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to diagnose
NHTSA ODI #11762547
Mileage unknown · Aug 25, 2026
Electrical SystemForward Collision Avoidance
I am filing a formal safety complaint regarding my 2022 GMC Sierra 1500 Denali (5.3L engine). This vehicle has exhibited a pattern of severe electrical, fuel system, and active safety sensor failures that pose a direct threat to occupant and public safety.At approximately 4,000 miles, the high-pressure fuel injectors suffered an…
Read full complaint
I am filing a formal safety complaint regarding my 2022 GMC Sierra 1500 Denali (5.3L engine). This vehicle has exhibited a pattern of severe electrical, fuel system, and active safety sensor failures that pose a direct threat to occupant and public safety.At approximately 4,000 miles, the high-pressure fuel injectors suffered an early-stage mechanical failure requiring dealer repair.At approximately 24,000 miles, the vehicle suffered a catastrophic, un-warned total power shutdown while driving in the middle of active, fast-moving 5:00 PM rush-hour traffic on a 100-degree day in [XXX]. The vehicle completely stalled, causing a loss of standard driving capabilities and leaving the occupants stranded without air conditioning or cabin ventilation in an incredibly high-risk, live-traffic environment. The dealership attributed the failure to the fuel pump switch/control module.The vehicle's active safety framework is deeply compromised. The forward-facing front collision camera and its integrated crash-avoidance sensors have completely failed and required a minimum of three (3) separate repair interventions, yet the safety system remains broken and unreliable.The vehicle exhibits phantom electrical bugs. The MultiPro tailgate audio system consistently turns itself on while the vehicle is parked, locked, and closed, hijacking the driver's phone Bluetooth from inside the home. While driving down the road, the internal cabin radio will abruptly cut out and begin blasting audio through the exterior tailgate speakers, creating a severe driver distraction. The dealership has repeatedly dismissed these electrical safety anomalies as untraceable.3. Activating Your Texas Consumer Rights INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11759334
Mileage unknown · Jul 31, 2026
Back Over PreventionElectrical System
My truck is intermittently having the camera display a warning code. While in reverse or while towing and trying to use the surrounding cameras. It happens randomly and almost caused accidents in parking lots. While towing I use it for lane changes and with non towing mirrors it’s a very dangerous issue that could cause an accid…
Read full complaint
My truck is intermittently having the camera display a warning code. While in reverse or while towing and trying to use the surrounding cameras. It happens randomly and almost caused accidents in parking lots. While towing I use it for lane changes and with non towing mirrors it’s a very dangerous issue that could cause an accident especially on the highway
NHTSA ODI #11754012
Mileage unknown · Jun 16, 2026
Electrical SystemEngine
I was driving at 45 mph and all of a sudden the screens went black as if the truck was turned off and the first thing I did was turn on the hazards because I didn’t know if the engine shut off either there was on coming traffic from both my front and back so I was scared my truck shut off 5-7 seconds later the screens turned bac…
Read full complaint
I was driving at 45 mph and all of a sudden the screens went black as if the truck was turned off and the first thing I did was turn on the hazards because I didn’t know if the engine shut off either there was on coming traffic from both my front and back so I was scared my truck shut off 5-7 seconds later the screens turned back on and everything went back to normal but I was scared that my truck just turned off I made the dealership aware of this issue as soon as I pulled over and they said they had a busy schedule and that they would try to have a manager reach out to me to “squeeze me in” Mind you I just got my truck back from the dealership due to electrical issues and service yesterday and not even 24 hours later this happened so I am upset.
NHTSA ODI #11744447
Mileage unknown · Jun 10, 2026
Electrical SystemPower Train
Was driving down the road at 35 mph and the truck started to shake and the the transmission shifted really hard check engine light came on. Pulled over truck wouldn’t go into reverse and wouldn’t shift correctly. Had my truck towed home called the dealership they said I will need to have it towed in. Several days later the chec…
Read full complaint
Was driving down the road at 35 mph and the truck started to shake and the the transmission shifted really hard check engine light came on. Pulled over truck wouldn’t go into reverse and wouldn’t shift correctly. Had my truck towed home called the dealership they said I will need to have it towed in. Several days later the check engine light was off I took the truck around the block it was running okay. Drove it the next day it did the same thing shook really bad shifted hard and wouldn’t shift correctly my go I took reverse. Had it towed to the dealership. The dealership said it was the same problem they are having on other trucks with this same transmission truck is out of warranty and GM will not cover the cost to fix it.
NHTSA ODI #11743157
Mileage unknown · Jun 8, 2026
Electrical System
The Telematics Control Module failed - it no longer functions. This affects the ability to use OnStar services, such as navigation assistance, but especially OnStar emergency services which would be needed in case of a vehicle crash or other emergency. OnStar no longer works due to the module failure. There is a backlog of at…
Read full complaint
The Telematics Control Module failed - it no longer functions. This affects the ability to use OnStar services, such as navigation assistance, but especially OnStar emergency services which would be needed in case of a vehicle crash or other emergency. OnStar no longer works due to the module failure. There is a backlog of at least several months, or longer, before a new module is available. Many people complain that the replacement module often fails within a few months,
NHTSA ODI #11742834
Mileage unknown · May 19, 2026
Electrical SystemEnginePower Train
Multiple times now my vehicle has had its engine locked up while driving at highway and regular uphill driving. Along with towing aswell. I have had it repaired multiple times and last time dealer wouldn’t tell me what happened because GM wouldn’t let them figure out what happened. Along with multiple attempts at fixing the tra…
Read full complaint
Multiple times now my vehicle has had its engine locked up while driving at highway and regular uphill driving. Along with towing aswell. I have had it repaired multiple times and last time dealer wouldn’t tell me what happened because GM wouldn’t let them figure out what happened. Along with multiple attempts at fixing the transmission and brakes that are still on going issue. Same with the engine.
NHTSA ODI #11738860
73,000 miles · Apr 7, 2026
Electrical System
The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle had experienced a failure with the front cameras and various control modules and sensors, requiring that all the parts be replaced. The contact stated that the parts had been replaced several times, but the vehicle was not repaired. The vehicle was take…
Read full complaint
The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle had experienced a failure with the front cameras and various control modules and sensors, requiring that all the parts be replaced. The contact stated that the parts had been replaced several times, but the vehicle was not repaired. The vehicle was taken to a dealer for repairs, but the failures persisted. The manufacturer was not notified of the failure. The failure mileage was 73,000.
NHTSA ODI #11729731
Mileage unknown · Apr 7, 2026
Electrical SystemPower TrainSteeringCrash
This is in addition to the first report regarding my 2022 GMC Sierra SLT with 10-Speed Transmission. I had previously filed a complaint (NHSTA Tracking# 11728418.) regarding the OnStar and Internet quitting on me. Which was the Serial Gateway Module. I had reported that I was put off many times regarding a loner vehicle so i co…
Read full complaint
This is in addition to the first report regarding my 2022 GMC Sierra SLT with 10-Speed Transmission. I had previously filed a complaint (NHSTA Tracking# 11728418.) regarding the OnStar and Internet quitting on me. Which was the Serial Gateway Module. I had reported that I was put off many times regarding a loner vehicle so i could get back and forth to my Oncologist for treatment of Head and Neck Cancer. And years of follow-up appt. with specialists Gastrointerologists and Cardiologist for serious issues incurred from 168 intense radiation treatments and Chemo. I had also taken my truck in for all scheduled maintenace intervals specified by the dealer and the manufacturer. "REPAIR ORDER GCCS504610" I had to leave it in the shop for 30 days for a defective Exhaust System, Radio, Charging Port, Remote Key Fob not able to unlock the truck so i could get in. And some other warranty/recall issues regarding my A/C blower and Seat cushion blower motor and Trailer Brake Switch, Fog Lamps running while daytime running lights were on - All Safety issues, My truck was @ Beck & Masten GMC for 30 days during these repairs, recalls and warranty. Will attach INVOICE 123532 to show consistant sheduled maintenance per GMC guidelines. Waited while this service was performed. "REPAIR ORDER / INVOICE 140542" Again my truck was back at Beck & Masten GMC (19 days) for the Serial Gateway Module and Radio not working AGAIN! Again, no OnStar, No Internet, No GPS. And, I reported the oil consumption and Add OIL light coming on; which was dismissed as idling too often (. I had to add 2 qts of oil between scheduled oil changes(The truck had only 13754 miles at this time) The LAST time I had anything to do with Beck & Masten GMC South was when I spent over months waiting on a loaner vehicle because I needed them to please look into still having an oil light coming on. And slipping and front end wobble just before the slipping/clucking and high RPM's that were dangerous- accident!!
NHTSA ODI #11729716
Official recalls
6Feb 12, 2026
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence & remedy
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:control Module:software
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Consequence: Rear wheel lock up increases the risk of a crash.
Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Feb 6, 2025
General Motors, LLC (GM) is recalling certain 2022 GMC Sierra 1500 vehicles equipped with chrome front grille deflectors. The attachments that hold the front grille deflectors in place may fracture, resulting in grille detachment.
Consequence & remedy
Consequence: A detached front grille deflector may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will reinforce or repair all attachment points on the chrome front grille deflector, free of charge. Owner notification letters were mailed March 17, 2025. Owners may call GM customer service for GMC at 1-800-462-8782. GM's number for this recall is N242490120.
Oct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence & remedy
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Additional source detail variants (2)
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Consequence: Rear wheel lock-up can increase the risk of a crash.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Jun 30, 2022
General Motors (GM) has decided that certain 2022 model year Chevrolet Silverado, and GMC Sierra vehicles equipped with an accessory sport bar. The accessory sport bar contains a high-mounted brake light that may not function. In addition, it may block the vehicle's existing high-mounted brake light. As such, these vehicles may fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: An inoperative high-mounted brake light can reduce visibility to other drivers and increase the risk of a crash.
Remedy: Dealers will inspect the installation of the accessory bar and provide the correct vehicle wiring, if necessary, free of charge. Interim owner notification letters advising owners of the safety risk were mailed on August 10, 2022. Owner notification letters were mailed on January 27, 2023. Owners may contact GM's customer service on 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020.. GM's recall number for this recall is N222368110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration