NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
83 reportsClear category filterMileage unknown · Jul 24, 2019
Power TrainService Brakes
TL* THE CONTACT OWNS A 2016 A GMC SIERRA 1500. WHILE DRIVING 65 MPH, THE VEHICLE STARTED WOBBLING. THE VEHICLE WAS TAKEN TO WALLINGFORD BUICK GMC (1122 OLD NORTH COLONY RD, WALLINGFORD, CT 06492, (203) 269-8741) WHERE THE BRAKE PADS ON THE FRONT DRIVER'S SIDE WHEEL WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TA…
Read full complaint
TL* THE CONTACT OWNS A 2016 A GMC SIERRA 1500. WHILE DRIVING 65 MPH, THE VEHICLE STARTED WOBBLING. THE VEHICLE WAS TAKEN TO WALLINGFORD BUICK GMC (1122 OLD NORTH COLONY RD, WALLINGFORD, CT 06492, (203) 269-8741) WHERE THE BRAKE PADS ON THE FRONT DRIVER'S SIDE WHEEL WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND TEST DRIVEN. THE TECHNICIAN DIAGNOSED THAT THE ROTORS NEEDED TO BE RESURFACED, THE FRONT BRAKE PADS NEEDED TO BE CHANGED, THE TRANSMISSION FLUID NEEDED TO BE DRAINED, AND THE COMPUTER NEEDED TO BE RESET. THE CONTACT RETRIEVED THE VEHICLE AND THE FAILURES RECURRED THE FOLLOWING DAY. THE DEALER ADVISED THE CONTACT TO GIVE THE VEHICLE A FEW THOUSAND MILES TO WORK OUT THE FAILURES AND STATED THAT THE TRANSMISSION WAS ADJUSTING TO THE CONTACT'S DRIVING HABITS. THE VEHICLE WAS NOT REPAIRED AGAIN AND THE FAILURES WERE STILL PRESENT. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
NHTSA ODI #11234499
49,800 miles · Jul 19, 2019
Power Train
TRUCK LURCHES FORWARD UNEXPECTEDLY DURING SLOW STOPS SUCH AS WHEN APPROACHING A BARRIER TO PARK, A GATE, OR PEDESTRIAN CROSSING. AS THE TRANSMISSION DOWNSHIFTS, THE TORQUE INCREASE CAUSES THE BRAKE PRESSURE BEING APPLIED TO BECOME INSUFFICIENT TO STOP THE VEHICLE CAUSING IT TO LURCH FORWARD UP TO SIX FEET. DURING ACCELLERATION…
Read full complaint
TRUCK LURCHES FORWARD UNEXPECTEDLY DURING SLOW STOPS SUCH AS WHEN APPROACHING A BARRIER TO PARK, A GATE, OR PEDESTRIAN CROSSING. AS THE TRANSMISSION DOWNSHIFTS, THE TORQUE INCREASE CAUSES THE BRAKE PRESSURE BEING APPLIED TO BECOME INSUFFICIENT TO STOP THE VEHICLE CAUSING IT TO LURCH FORWARD UP TO SIX FEET. DURING ACCELLERATION WHILE HIGHWAY DRIVING THE TRANSMISSION MAY UNEXPECTEDLY DOWNSHIFT TO AN INAPPROPRIATE GEAR CAUSING THE ENGINE REV LIMITER TO ENGAGE AND REDUCING POWER UNEXPECTEDLY WHEN IT SHOULD BE INCREASING.
NHTSA ODI #11233437
47,000 miles · Jul 15, 2019
Power Train
WHEN TRAVELING LOW SPEEDS LIKE IN A PARKING LOT FIRST GEAR JERKS SO BAD IT FEELS LIKE SOMEONE REAR ENDED YOU. GOING HIGHWAY SPEEDS BETWEEN 45 TO 75 YOU FEEL VIBRATIONS COMING FROM THE TRANSMISSION IT FEELS LIKE YOU'RE GOING OVER RUMBLE STRIPS. I HAD MY TRANSMISSION FLUSHED AND CHANGED IT FIX THE VIBRATIONS BUT 3000 MILES LATER T…
Read full complaint
WHEN TRAVELING LOW SPEEDS LIKE IN A PARKING LOT FIRST GEAR JERKS SO BAD IT FEELS LIKE SOMEONE REAR ENDED YOU. GOING HIGHWAY SPEEDS BETWEEN 45 TO 75 YOU FEEL VIBRATIONS COMING FROM THE TRANSMISSION IT FEELS LIKE YOU'RE GOING OVER RUMBLE STRIPS. I HAD MY TRANSMISSION FLUSHED AND CHANGED IT FIX THE VIBRATIONS BUT 3000 MILES LATER THE VIBRATIONS STARTED AGAIN.
NHTSA ODI #11232144
85,400 miles · Jul 7, 2019
Power Train
I HAVE HAD ISSUES WITH MY GMC SIERRA SINCE IT WAS NEW. IT HAS JERKED AND CLUNKED WHEN I START TO GO AND THEN LEFT OFF THE GAS. THERE HAS ALSO BEEN A HESITATION WHEN STEPPING ON THE GUESS. I HAVE TAKEN IT TO THE DEALER SEVERAL TIMES AND WAS TOLD THINGS SUCH AS: "I JUST NEEDED TO GET USE TO THE 8 SPEED TRANSMISSION"," THE HESIT…
Read full complaint
I HAVE HAD ISSUES WITH MY GMC SIERRA SINCE IT WAS NEW. IT HAS JERKED AND CLUNKED WHEN I START TO GO AND THEN LEFT OFF THE GAS. THERE HAS ALSO BEEN A HESITATION WHEN STEPPING ON THE GUESS. I HAVE TAKEN IT TO THE DEALER SEVERAL TIMES AND WAS TOLD THINGS SUCH AS: "I JUST NEEDED TO GET USE TO THE 8 SPEED TRANSMISSION"," THE HESITATION IS WHEN THE TRUCK SWITCHES FROM V4 TO V8". AND "THERE IS NOTHING WRONG". NOW THE WARRANTY HAS EXPIRED AND IT IS GETTING WORSE. IT NOW FEELS LIKE "RUNNING OVER A RUMBLE STRIP" OR LIKE IT IS "MISSING" AND "HESITATING". ALL OF THESE THINGS OCCUR WHEN THE VEHICLE IS IN MOTION.
NHTSA ODI #11229893
29,000 miles · Jul 2, 2019
Power Train
MY 8 SPEED TRANSMISSION SEEM TO WAIT TOO LONG TO UP SHIFT. WILL DOWN SHIFT AT ODD TIMES. WHEN IS STOP AND GO TRAFFIC AROUND 5-15 MPH THE TRUCK WILL LURCH FORWARD WHEN COASTING OR COMING TO A STOP. WHEN TRUING ON THE TRUCK AND GOING FROM PARK TO REVERSE THERE WILL BE A LOUD "CLUNK" THAT CAN ALSO BE FELT CAUSING THE TRUCK TO ROC…
Read full complaint
MY 8 SPEED TRANSMISSION SEEM TO WAIT TOO LONG TO UP SHIFT. WILL DOWN SHIFT AT ODD TIMES. WHEN IS STOP AND GO TRAFFIC AROUND 5-15 MPH THE TRUCK WILL LURCH FORWARD WHEN COASTING OR COMING TO A STOP. WHEN TRUING ON THE TRUCK AND GOING FROM PARK TO REVERSE THERE WILL BE A LOUD "CLUNK" THAT CAN ALSO BE FELT CAUSING THE TRUCK TO ROCK.
NHTSA ODI #11228963
85,000 miles · May 30, 2019
Power Train
2016 GM SIERRA - 85,000 MILES NEVER HAD MANY ISSUES WITH JERKING/JUMPING/BRAKING AS MANY HAVE DESCRIBED. WENT TO ACCELERATE FROM A STOP LIGHT AND THE TRUCK WOULD NOT SHIFT OUT OF SECOND GEAR. COULD NOT GET TRUCK TO SHIFT AND WOULD THEN SHIFT HARD UPON DECELERATION. TOOK TO THE DEALER SERVICE DEPARTMENT. THEY SAID THE TORQUE…
Read full complaint
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
NHTSA ODI #11210855
40,000 miles · May 19, 2019
Power TrainService Brakes
TRUCK HESITATES, JUMPS, AND BUMPS WHEN APPLYING BRAKES. WHEN STEPPING ON BRAKES TO STOP, IT BUMPS AND JUMPS BEFORE IT ACTUALLY COMES TO A FULL STOP. IT SEEMS YOU REALLY HAVE TO STEP ON THE BRAKE HARD TO MAKE IT COME TO A FULL STOP. THIS IS WORSE ON LOW SPEED, BELOW 30 MPH, STOP AND GO TRAFFIC. THERE WERE A NUMBER OF INSTANCE…
Read full complaint
TRUCK HESITATES, JUMPS, AND BUMPS WHEN APPLYING BRAKES. WHEN STEPPING ON BRAKES TO STOP, IT BUMPS AND JUMPS BEFORE IT ACTUALLY COMES TO A FULL STOP. IT SEEMS YOU REALLY HAVE TO STEP ON THE BRAKE HARD TO MAKE IT COME TO A FULL STOP. THIS IS WORSE ON LOW SPEED, BELOW 30 MPH, STOP AND GO TRAFFIC. THERE WERE A NUMBER OF INSTANCES I ALMOST REAR ENDED VEHICLES IN FRONT OF ME DUE TO THIS PROBLEM. THE TRUCK ALSO BUMPS AND JUMPS WHEN TAKING OFF. I THINK THIS STARTED A FEW MONTHS AFTER I GOT THE TRUCK BRAND NEW. IT IS GETTING PROGRESSIVELY WORSE. I TOOK IT A NUMBER OF TIMES TO GM SERVICE CENTER; THEY DID A TRANSMISSION RELEARN, SOFTWARE UPDATES, AND TRANSMISSION FLUSH--TRUCK GOT BETTER FOR ONLY A FEW HUNDRED MILES, THEN SAME PROBLEMS RECURRED. THE LATEST COUPLE OF TIMES I WENT BACK TO GM SERVICE, THEY TOLD ME NOTHING IS WRONG WITH MY TRUCK. IT HAS BEEN VERY FRUSTRATING DEALING WITH THIS PROBLEM AND GM SERVICE FOR THE PAST 3 YEARS.
NHTSA ODI #11208481
26,000 miles · Apr 28, 2019
Power Train
WHEN DRIVING IN SLOW MOVING TRAFFIC TRANS MISSION FEELS VERY JERKY AND SHIFTS HARD. ALSO WHEN GOING FROM PARK TO REVERSE TRANSMISSION WILL CLUNK VERY HARD CAUSING THE TRUCK TO MOVE. TRUCK ALSO SEEMS TO HESITATE WHEN TRYING TO SHIFT IN LOWER GEARS WHILE ACCELERATING. THIS HAS BEEN AN ONGOING ISSUE SINCE PURCHASING THE TRUCK BRAN…
Read full complaint
WHEN DRIVING IN SLOW MOVING TRAFFIC TRANS MISSION FEELS VERY JERKY AND SHIFTS HARD. ALSO WHEN GOING FROM PARK TO REVERSE TRANSMISSION WILL CLUNK VERY HARD CAUSING THE TRUCK TO MOVE. TRUCK ALSO SEEMS TO HESITATE WHEN TRYING TO SHIFT IN LOWER GEARS WHILE ACCELERATING. THIS HAS BEEN AN ONGOING ISSUE SINCE PURCHASING THE TRUCK BRAND NEW FROM THE DEALERSHIP. PRIOR ATTEMPTS FOR SERVICE HAVE BEEN EXPLAINED BY THEIR TECHNICIANS AS BEING AN ADAPTIVE TRANSMISSION NEEDING TO LEARN
NHTSA ODI #11204295
43,234 miles · Apr 25, 2019
Power Train
TRANSMISSION SHIFTS HARD GOING FROM 1ST TO 2ND GEAR WITH NO FIX FROM GM. COMPLAINED TO DEALER THEY SAID IT'S NORMAL AND THERE'S NO FIX FOR THE ISSUE. ISSUE ALSO PERSIST WHEN GOING FROM DRIVE TO REVERSE, A HARD SHIFT THAT I'VE NEVER EXPERIENCED BEFORE IN SEVERAL PREVIOUS GM PRODUCTS I OWNED OR CURRENTLY OWN. HAPPENS EVERY TIME I …
Read full complaint
TRANSMISSION SHIFTS HARD GOING FROM 1ST TO 2ND GEAR WITH NO FIX FROM GM. COMPLAINED TO DEALER THEY SAID IT'S NORMAL AND THERE'S NO FIX FOR THE ISSUE. ISSUE ALSO PERSIST WHEN GOING FROM DRIVE TO REVERSE, A HARD SHIFT THAT I'VE NEVER EXPERIENCED BEFORE IN SEVERAL PREVIOUS GM PRODUCTS I OWNED OR CURRENTLY OWN. HAPPENS EVERY TIME I DRIVE THE VEHICLE
NHTSA ODI #11203727
57,000 miles · Dec 22, 2018
Power TrainService Brakes
2016 GMC SIERRA- BOUGHT USED HARD SHIFTING NOTED IMMEDIATELY AND SHUTTERING ON INCLINES, TOOK TO DEALERSHIP HAD PART REPLACED- FIXED SHUTTERING BUT NOT HARD SHIFTS- NOW IT NOT ONLY SHIFTS HARD BUT WHILE I WAS TRYING TO STOP AT A DRIVE THROUGH THE BRAKES FAILED- LUNGES FORWARD ALMOST HITTING THE CAR IN FRONT OF US- NEXT DAY I PUL…
Read full complaint
2016 GMC SIERRA- BOUGHT USED HARD SHIFTING NOTED IMMEDIATELY AND SHUTTERING ON INCLINES, TOOK TO DEALERSHIP HAD PART REPLACED- FIXED SHUTTERING BUT NOT HARD SHIFTS- NOW IT NOT ONLY SHIFTS HARD BUT WHILE I WAS TRYING TO STOP AT A DRIVE THROUGH THE BRAKES FAILED- LUNGES FORWARD ALMOST HITTING THE CAR IN FRONT OF US- NEXT DAY I PULLED INTO A PARKING SPOT SAME THING HAPPENED- BRAKES WOULD NOT COMPRESS- STOOD ON THE BRAKE BEFORE IT FINALLY STOPPED- BACKED UP A BIT TO STRAIGHTEN UP AND THE [XXX] THING DID IT AGAIN IN REVERSE. I'M TRAVELING BACK HOME TO ARKANSAS FROM FLORIDA IN A FEW DAYS WITH MY CHILDREN AND I'M SCARED TO DEATH TO DRIVE THIS THING. I CAN'T GET IT LOOKED AT BEFORE WE LEAVE BECAUSE OF THE WEEKEND/ CHRISTMAS BREAK.SERIOUSLY UNSAFE VEHICLE! THERE SHOULD BE RECALLS ON THESE VEHICLES! I'VE READ SO MANY SIMILAR STORIES, WHY HAS THIS NOT BEEN ADDRESSED YET? GMC SHOULD BE ASHAMED. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11163153
Official recalls
7Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Apr 28, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Consequence & remedy
Consequence: Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration