2005 GMC Sierra 1500

WAS ON MAIN ROAD GOING 50MPH AND APPROACHING STREET THAT I LIVE AT, APPLIED BRAKES TO SLOW DOWN, AND PEDAL WHEN TO FLOOR. I THEN STARTED TO DOWNSHIFT INTO LOWER GEARS AND APPLIED EMERGENCY BRAKE TO STOP. I HAD VEHICLE TOWED TO REPAIR SHOP AND CAUSE WAS METAL BRAKE LINE TO RIGHT FRONT WHEEL WAS RUSTED OUT. ALSO ALL THE OTHER LINES WERE VERY RUSTY AND SHOULD BE REPLACED.....OTHERWISE OTHERS WILL GO SOON AND IT WILL HAPPEN AGAIN. IT WAS MENTIONED THAT GMC AND CHEVY TRUCKS IN A CERTAIN YEAR RANGE (SUCH AS THIS) HAVE THIS PROBLEM BECAUSE THE ANTI-LOCK SYSTEM IS LOCATED NEAR THE FRAME AND THUS ALL LINES ARE EXPOSED TO SALT ETC.......WHERE AS IN A CONVENTIONAL DESIGN THE ANTI-LOCK SYSTEM IS LOCATED ON THE FIRE WALL AND ONLY ONE LINE (THE LINE THAT GOES TO BACK) IS EXPOSED TO SALT ETC AND IS USUALLY MADE OF RUST PROOF MATERIAL. THE BRAKE LINE THAT IS USED ON THIS TRUCK IS MADE OF CHEAP STEEL WHICH WILL RUST.....NOT RUST PROOF LINES SUCH AS "ARMOR COAT TYPE BRAKE LINES". THIS REPAIR COST ME $700 2ND ITEM: WHILE ON THE SUBJECT OF BRAKE SYSTEM ON THIS TRUCK.....I HAVE FOUND THAT IN CERTAIN CONDITIONS THAT THE ANTI-LOCK BRAKE SYSTEM IS TOO SENSITIVE AND CAN ACTUALLY MAKE THING WORSE UNDER CERTAIN CONDITIONS. *TR

I DID NOT HAVE AN ACCIDENT WITH THIS VEHICLE. I AM FILING THE COMPLAINT BECAUSE I HAVE PREVIOUSLY TAKEN MY VEHICLE TO BOB JEANNOTTE PONTIAC-GMC TRUCK, INC., PLYMOUTH, MI 48170 (734) 453-2500 TO HAVE AN INSPECTION FOR RUSTED BRAKE LINES AS WELL AS RUSTED FRAME ON THE ABOVE LISTED INCIDENT DATE. MY INVOICE # IS GCCS189900 AND MY CUSTOMER ASSISTANCE PROVIDED CASE # IS 71-784-24265. I WAS TOLD IT WAS NORMAL FOR THE CONDITIONS BY THE DEALER REP. THIS VEHICLE IS HAVING CONTINUAL RUST PROBLEMS TO BOTH THE BRAKE LINES AND FRAME. I AM FILING THIS COMPLAINT AS I UNDERSTAND THERE IS AN ONGOING INVESTIGATION INTO THIS PROBLEM UP TO YEAR 2003 AND WOULD LIKE MY VEHICLE YEAR TO BE INCLUDED IN THESE INVESTIGATION ISSUES.

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED THAT THE ABS LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. AN HOUR LATER, THE CONTACT NOTICED THAT THE VEHICLE DISPLAYED DIFFICULTY STOPPING. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE DRIVER SIDE TIRE WAS TILTED AND SMOKE AND FLAMES HAD BEGAN RISING FROM BEHIND THE WHEEL. THE CONTACT CALLED THE FIRE DEPARTMENT BUT NO REPORT WAS FILED. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 49,000. UPDATED 07/26/10. *LJ UPDATED 08/06/10*JB

I WOULD LIKE TO FILE A COMPLAINT AGAINST GM FOR BRAKE LINE CORROSION ISSUES & EXCESSIVE FRONT ROTOR/PAD WEAR. I HAVE A 2005 GMC SIERRA 1500 2WD CREW CAB WITH THE VORTEC 5300 MOTOR. I HAVE REPLACED SEVERAL SETS OF FRONT PADS AND ROTORS AND HAVE BEEN WATCHING THE CORROSION OF THE BRAKE LINES THAT LEAD TO THE REAR WHEELS. I WAS NOT AWARE THERE WAS AN INVESTIGATION UNTIL I DID SEARCH ONLINE. MOTORTREND REPORTED IN MARCH OR APRIL OF 2010, AN INVESTIGATION WAS OPENED FOR GM VEHICLES UP TO AND INCLUDING MODEL YEAR 2003. I THINK YOU NEED TO ADD 2005 TO IT ALSO. *TR