Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
5125–50K
5150–75K
3075–100K
25100–150K
9150K+
186 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports4 injury reports
What owners actually said
212 reports
3,000 miles · Oct 13, 2004
Tires
I PURCHASED A NEW 2004 GMC IN FEBUARY 04 AND IT KEEPS WEARING THE FRONT TIRES TO EXCESS AND THE DEALER KEEPS TELLING ME THAT'S NORMAL FOR A FOUR WHEEL DRIVE,,BULL THE TIRES ARE BRIDGESTONE DUELER 265/R70/17 ANDTHE TRUCK. *AK IS A 1500 GMC SERRIA , I MAINTAIN MY EQUIPMENT AND KEEP A CLOSE EYE …
Read full complaint
I PURCHASED A NEW 2004 GMC IN FEBUARY 04 AND IT KEEPS WEARING THE FRONT TIRES TO EXCESS AND THE DEALER KEEPS TELLING ME THAT'S NORMAL FOR A FOUR WHEEL DRIVE,,BULL THE TIRES ARE BRIDGESTONE DUELER 265/R70/17 ANDTHE TRUCK. *AK IS A 1500 GMC SERRIA , I MAINTAIN MY EQUIPMENT AND KEEP A CLOSE EYE FOR PROBLEMS AND I CAN SEE SOMEONE WHO DOES NOT WITH TIRE FAILURE AND ACCIDENTS, I HAVE LOOK AT THE SAME MOLDEL AND THEY TOO HAVE THE SAME PROBLEM WITH FRONT TIRE WEAR.
NHTSA ODI #10095668
1,000 miles · Sep 29, 2004
Electrical System
UPON ENTERING THE VEHICLE THERE WAS NO POWER. AAA WAS CALLED, AND IT WOULD NOT TAKE A JUMP. THE DEALER REPAIRED THE BATTERY CABLE BOLT THAT BECAME DEFECTIVE FROM ACID. THE BATTERY CABLE PRONG AND WIRES WERE REPLACED AT CONSUMER'S EXPENSE. *AK *SC *JB
ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
THE SPARE TIRE AND WHEEL ASSEMBLY THAT WAS PROVIDED ON CERTAIN CONVERSION VEHICLES WILL NOT FIT ON THE FRONT WHEEL HUB DUE TO OFFSET OF THE WHEEL. HOWEVER, IT WILL FIT ON THE REAR WHEELS.
Consequence & remedy
Consequence: IF SOMEONE HAS A FLAT TIRE ON THE FRONT WHEEL, THEY WILL NOT BE ABLE TO INSTALL THE PROVIDED SPARE TIRE.
Remedy: DEALERS WILL INSTALL A SPARE WHEEL WITH THE CORRECT OFFSET. OWNER NOTIFICATION BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT REGENCY AT 1-800-989-4727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 GMC Sierra 1500 Problems, Complaints & Recalls | Skip That Year
Illustration