IllustrationTHE BRAKE LINES IN FRONT ARE RUSTED OUT AND LEAKING CREATING A SERIOUS PROBLEM, AS THE BRAKES ARE NOT WORKING. I SEE THIS IS A RE-OCCURRING PROBLEM WITH GMC VEHICLES. THE COST TO REPAIR IS ASTRONOMICAL. WHY ISN'T GMC RECALLING THESE VEHICLES?
2003 GMC Safari
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Safari years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
Service Brakes complaints
2 reports. I WOULD LIKE TO REPORT THE INCIDENT I HAD WITH MY AUTOMOBILE: GMC SAFARI WAGON 2003. ONE DAY IN JULY THIS YEAR (2014) I APPLIED THE BRAKES OF THE ABOVE VEHICLE WHEN I WAS APPROACHING THE RED TRAFFIC LIGHT. THE VEHICLE DID NOT STOP EVEN THROUGH THE BRAKE SYSTEM WAS RECENTLY WORKED ON. I INVESTIGATED THE REASON WHY IT FAIL…
Read full complaint
. I WOULD LIKE TO REPORT THE INCIDENT I HAD WITH MY AUTOMOBILE: GMC SAFARI WAGON 2003. ONE DAY IN JULY THIS YEAR (2014) I APPLIED THE BRAKES OF THE ABOVE VEHICLE WHEN I WAS APPROACHING THE RED TRAFFIC LIGHT. THE VEHICLE DID NOT STOP EVEN THROUGH THE BRAKE SYSTEM WAS RECENTLY WORKED ON. I INVESTIGATED THE REASON WHY IT FAILED TO STOP AND FOUND OUT THAT THE BRAKE LINE WAS HEAVILY CORRODED. *TR
Official recalls
103V328000 · Suspension:front:control Arm:lower Ball Joint
Sep 12, 2003
CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
Consequence & remedy
Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.