NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
10 reportsClear category filter87,000 miles · Feb 16, 2005
Engine And Engine CoolingFuel System, Gasoline
PROBLEM WITH 1996 GMC SAFARI VAN NOT STARTING. *BF THE MECHANIC FOUND THE FUEL PUMP WAS NOT PUMPING FUEL. UPON RETRIEVING THE FUEL PUMP FROM THE GAS TANK, HE FOUND IT TO HAVE SUFFERED SEVERE ELECTRICAL DAMAGE. THE ACTUAL FAILURE WAS NOT THE FUEL PUMP, BUT BECAUSE IT GENERATED ENOUGH HEAT TO MELT THE HOSE COMING FROM THE P…
Read full complaint
PROBLEM WITH 1996 GMC SAFARI VAN NOT STARTING. *BF THE MECHANIC FOUND THE FUEL PUMP WAS NOT PUMPING FUEL. UPON RETRIEVING THE FUEL PUMP FROM THE GAS TANK, HE FOUND IT TO HAVE SUFFERED SEVERE ELECTRICAL DAMAGE. THE ACTUAL FAILURE WAS NOT THE FUEL PUMP, BUT BECAUSE IT GENERATED ENOUGH HEAT TO MELT THE HOSE COMING FROM THE PUMP ALONG THE CONNECTION. THE CONSUMER ALSO STATED HE HAD TO HAVE A REBUILT ENGINE INSTALLED AFTER THE FIRST ENGINE FAILED WITH ONLY 87,000 MILES. *JB
NHTSA ODI #10115064
87,000 miles · Feb 16, 2005
Electrical SystemEngine And Engine Cooling
THE CONSUMER 1996 GMC SAFARI VAN ELECTRICAL PROBLEM WITH FUEL PUMP. *BF THE FUEL PUMP DID NOT PUMP FUEL. THE FUEL PUMP SUFFERED ELECTRICAL DAMAGE. THE FUEL FILTER WAS CHANGED WHEN THE REBUILT ENGINE WAS PLACED IN THE VEHICLE. THE MAIN BEARING WAS SHOT. *SC
NHTSA ODI #10112837
93,230 miles · Jul 21, 2004
Engine And Engine Cooling
COOLANT LEAK CAUSE BY INTAKE MANIFOLD FAILURE. *LA
NHTSA ODI #10082380
66,000 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineSuspension
WINDSHIELD WIPERS DO NOT OPERATE - RECALLED - DEALER CLAIMS IT WAS REPAIRED, NOW WIPERS OPERATE WHENEVER IT FEELS LIKE IT. BOTH TORSION RODS FAILED WITHOUT WARNING WITHIN 1 DAY APART OF EACH OTHER. MECHANIC REVEALED THAT GM NOW HAS A SPECIAL TECHNIQUE TO BE DONE WHEN THIS HAPPENS AND IT COSTS AN EXTRA $90 TO REPAIR. WHICH MEANS …
Read full complaint
WINDSHIELD WIPERS DO NOT OPERATE - RECALLED - DEALER CLAIMS IT WAS REPAIRED, NOW WIPERS OPERATE WHENEVER IT FEELS LIKE IT. BOTH TORSION RODS FAILED WITHOUT WARNING WITHIN 1 DAY APART OF EACH OTHER. MECHANIC REVEALED THAT GM NOW HAS A SPECIAL TECHNIQUE TO BE DONE WHEN THIS HAPPENS AND IT COSTS AN EXTRA $90 TO REPAIR. WHICH MEANS THEY ARE AWARE OF THE PROBLEM AND WILL NOT RECALL THE VEHICLES AND REPLACE AT THEIR COST. BROKEN SPARK PLUG ALMOST KILLED MY FAMILY. FUEL PUMP WENT OUT. DRIVER'S SIDE WINDOW DOES NOT ROLL DOWN, DRIVER'S SIDE VIEW MIRROR DOES NOT OPERATE.
NHTSA ODI #10070505
93,000 miles · Oct 1, 2003
Electrical SystemEngine And Engine CoolingSeat Belts
INTERMITTENTLY REAR WINDSHIELD WIPERS BECOME INOPERABLE, OBSTRUCTING DRIVER'S VIEW. THE ACCELERATOR CABLE WAS REPLACED TWICE. THE ALTERNATOR WAS REPLACED THREE TIMES. THE WATER PUMP WAS REPLACED TWICE. THE DRIVER'S SIDE POWER WINDOW MOTOR WAS REPLACED AND THE PASSENGER SIDE NEEDS TO BE REPLACED. THE DRIVER'S SIDE SEAT MOTOR …
Read full complaint
INTERMITTENTLY REAR WINDSHIELD WIPERS BECOME INOPERABLE, OBSTRUCTING DRIVER'S VIEW. THE ACCELERATOR CABLE WAS REPLACED TWICE. THE ALTERNATOR WAS REPLACED THREE TIMES. THE WATER PUMP WAS REPLACED TWICE. THE DRIVER'S SIDE POWER WINDOW MOTOR WAS REPLACED AND THE PASSENGER SIDE NEEDS TO BE REPLACED. THE DRIVER'S SIDE SEAT MOTOR FAILED. THE HATCH FAILED. THE REAR CAPTAIN CHAIRS SEAT BELTS BROKE. *AK *NLM
NHTSA ODI #10038013
Mileage unknown · Aug 18, 2002
Engine And Engine CoolingEquipmentVisibility
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #765823
Mileage unknown · May 18, 2000
Engine And Engine CoolingService Brakes, HydraulicSteering
STARTED VEHICLE IN THE GARAGE AND HEARD A CLUNKING & GRINDING NOISE. KEPT VEHICLE RUNNING, BACKED OUT OF THE GARAGE, TURNED THE WHEEL, AND THERE WAS NO STEERING. WENT TO APPLY BRAKES , AND THERE WERE NO BRAKES. CONTACTED DEALER. *AK. VEHICLE LOST POWER AND BRAKES DUE TO TENSION PULLEY WAS BROKE. *YH
NHTSA ODI #862104
Mileage unknown · Oct 26, 1999
Engine And Engine CoolingSteering
BELT TENSIONER LOOSE. NLM
NHTSA ODI #549197
Mileage unknown · Jul 6, 1999
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
BRAKES FAILED CAUSING NOISE. MJS
NHTSA ODI #546548
Mileage unknown · Mar 17, 1998
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
BELT SLIPS WHEN WET, CAUSING ENGINE HESITATION.
NHTSA ODI #532768
Official recalls
4Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration