← New search

2006 GMC Envoy

Owner reports · Recalls · Investigations

More warning signs than most Envoy years

Owner complaints for the 2006 GMC Envoy are substantially higher than the model-year median of 22.

About this comparison →

When problems were reported

Mileage at the reported incident

294 reports with mileage · 58 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Gasoline. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports24 fire reports5 injury reports

What owners actually said

352 reports
88,000 miles · May 23, 2014
Exterior Lighting

WHILE DRIVING ON THE EXPRESSWAY AT ABOUT 11PM, GOING 70 MILES PER HOUR, MY HEADLIGHT JUST WENT OUT. I TURNED THE CONTROL SWITCH ON AND OFF TO SEE IF THEY WOULD COME BACK ON BUT THEY DIDN'T. I PULLED ONTO THE SIDE OF THE ROAD AND CHECK TO SEE IF MY OTHER LIGHTS WERE WORKING (BLINKERS, FLOOD LIGHTS, BRIGHTS) AND THEY WERE. MY H…

Read full complaint

WHILE DRIVING ON THE EXPRESSWAY AT ABOUT 11PM, GOING 70 MILES PER HOUR, MY HEADLIGHT JUST WENT OUT. I TURNED THE CONTROL SWITCH ON AND OFF TO SEE IF THEY WOULD COME BACK ON BUT THEY DIDN'T. I PULLED ONTO THE SIDE OF THE ROAD AND CHECK TO SEE IF MY OTHER LIGHTS WERE WORKING (BLINKERS, FLOOD LIGHTS, BRIGHTS) AND THEY WERE. MY HEADLIGHTS HOWEVER WEREN'T. I TRIED TURNING THE TRUCK ON AND OFF TO SEE IF THEY WOULD COME BACK ON BUT THEY DIDN'T. AFTER SITTING THERE WITH THE CAR OFF FOR ABOUT 10 MINUTES, I STARTED IT BACK UP AND THEY CAME ON. I HAD TO TURN AROUND AND GO BACK HOME IN FEAR THAT I COULDN'T FINISH MY TRIP BECAUSE I DIDN'T KNOW IF MY LIGHTS WOULD GO OUT AGAIN. SINCE THIS FIRST INCIDENT, MY LIGHT GO OUT ON A DAILY BASIS AND AT RANDOM. THEY HAVE GONE OUT WHILE MY TRUCK HAS BEEN IN PARK AS WELL AS WHILE I'VE BEEN DRIVING. I HAVE TAKEN IT INTO THE SHOP AND AFTER THEM HAVING MY TRUCK FOR 9 HOURS, THEY TOLD ME THEY WORKED THE WHOLE TIME WHILE THEY HAD IT (GO FIGURE). I TOOK MY TRUCK BACK IN THIS MORNING BECAUSE IT WAS HAPPENING AGAIN AND I WAS ABLE TO SHOW TO THEM THAT MY SWITCH WAS REGISTERING MY HEADLIGHTS AS BEING ON WHEN THEY WEREN'T. I HAVE CONTACTED GMC TO FILE A COMPLAINT AND WAS TOLD AT THIS TIME THERE WASN'T MUCH THEY CAN DO AND THAT I JUST NEED TO GET IT REPAIRED. HARD TO DO WHEN NO ONE WILL ACKNOWLEDGE THE PROBLEM. I AM BEYOND FRUSTRATED BECAUSE I AM LIMITED WHEN I CAN DRIVE MY VEHICLE DUE TO THIS MAJOR ISSUE THAT CAN HAPPEN AT ANYTIME WITHOUT ANY WARNINGS. *TR

NHTSA ODI #10593601

86,236 miles · May 17, 2014
Electrical SystemUnknown Or Other

I HAVE HAD THIS ISSUE 3 TIMES -8/2012, 2/2013, 3/2014 - SO I AM ON THE 4TH IGNITION SWITCH IN THIS CAR, MILEAGE NOW APPROX 108,000. THE 4X4, STABILITRAK, ABS AND EMERGENCY BRAKE LIGHTS COME ON THEN IT BEEPS REPEATEDLY. SOMETIMES CONCURRENTLY, SOMETIMES NOT THE AIR BLOWER STOPS WORKING AS WELL. THIS 3RD TIME, AFTER THE LIGHTS HAD…

Read full complaint

I HAVE HAD THIS ISSUE 3 TIMES -8/2012, 2/2013, 3/2014 - SO I AM ON THE 4TH IGNITION SWITCH IN THIS CAR, MILEAGE NOW APPROX 108,000. THE 4X4, STABILITRAK, ABS AND EMERGENCY BRAKE LIGHTS COME ON THEN IT BEEPS REPEATEDLY. SOMETIMES CONCURRENTLY, SOMETIMES NOT THE AIR BLOWER STOPS WORKING AS WELL. THIS 3RD TIME, AFTER THE LIGHTS HAD BEEN COMING OFF/ON FOR A FEW DAYS, TURNING THE BLOWER ON WOULD TRIGGER THE LIGHTS TO COME ON. FOR EACH OF THE 3 TIMES, THE GMC DEALER HAS RECOMMENDED REPLACEMENT OF THE IGNITION SWITCH (2X AT MY COST) ON THE MOST RECENT REPAIR A VOLTAGE SPIKE WAS ACKNOWLEDGED BUT THE OPTION TO TRACK THIS BY INSTALLING INLINE FUSES WAS NOT EVEN OFFERED UNTIL I HAD TAKEN MY ISSUE TO A HIGHER AUTHORITY. I DECLINED AS I DON'T CARE TO PUT MORE MONEY IN A CAR THAT EVEN ONE OF THE DEALERSHIPS EMPLOYEES RECOMMENDED I JUST SELL AND BUY NEW. MY CONCERN IS WHETHER THIS CAR IS A HAZARD TO ME AND OTHERS? THE SERVICE MANAGER SAID WHEN THIS OCCURS THE IGNITION IS ESSENTIALLY OFF AND THE CAR COULD STOP BUT ANOTHER PERSON TOLD ME THAT NO, IT'S ANOTHER LEG OF THE IGNITION AND ITS OKAY. I DON'T KNOW WHO TO BELIEVE. ....UPDATED 08/12/14 *BF UPDATED 11/12/2014 *JS UPDATED 8/28/2017*CN

NHTSA ODI #10592124

208,000 miles · May 15, 2014
Electrical SystemEngineFire

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, SMOKE EMITTED INSIDE OF THE VEHICLE. THERE WERE NO FLAMES VISIBLE. A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT DRIVER'S SIDE WINDOW AND DOOR HOUSING CONTROL BOX HAD BEEN BURNED. THE VEHICLE WAS NOT REP…

Read full complaint

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, SMOKE EMITTED INSIDE OF THE VEHICLE. THERE WERE NO FLAMES VISIBLE. A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT DRIVER'S SIDE WINDOW AND DOOR HOUSING CONTROL BOX HAD BEEN BURNED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE VEHICLE EXHIBITED A CONSTANT STALLING AND WOULD RESTART MOMENTS AFTER THE FAILURE OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 208,000.

NHTSA ODI #10588519

111,860 miles · May 14, 2014
Fuel System, Gasoline

FUEL SENSOR/GAUGE READS EMPTY EVEN THOUGH FUEL TANK IS FULL. NEEDLE CONTINUES TO FLUCTUATES WHILE DRIVING PROVIDING AN INACCURATE READ OF DUEL STATE. *TR

NHTSA ODI #10588410

157,000 miles · May 9, 2014
Power TrainSteeringCrash

ACCIDENT ON 4/25/14 AFTER MY 2006 GMC ENVOY SHUT OFF COMPLETELY WHILE I WAS MAKING AN LEFT HAND TURN. I INFORMED GMC OF IT BUT GOT NO RESPONSE. THE VEHICLE HAS BEEN DOING THIS FOR THE PAST 6 MONTHS. I HAVE CONTACTED GMC SINCE THE ACCIDENT AND STILL HAVE GOTTEN NO RESPONSE. *TR

NHTSA ODI #10587514

138,775 miles · May 8, 2014
Fuel/propulsion System

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE FUEL GAUGE INDICATED THAT A QUARTER TANK OF FUEL REMAINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,775 AND THE CURREN…

Read full complaint

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE FUEL GAUGE INDICATED THAT A QUARTER TANK OF FUEL REMAINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,775 AND THE CURRENT MILEAGE WAS 138,963.

NHTSA ODI #10587277

135,000 miles · Apr 22, 2014
Fuel/propulsion System

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE INTERMITTENTLY FAILED. THE CONTACT ALSO MENTIONED THAT STRONG FUEL FUMES EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THE FUEL LEVER SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTUR…

Read full complaint

TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE INTERMITTENTLY FAILED. THE CONTACT ALSO MENTIONED THAT STRONG FUEL FUMES EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THAT THE FUEL LEVER SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

NHTSA ODI #10584202

100,000 miles · Apr 20, 2014
EngineFuel/propulsion System

DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY READ EMPTY ON THE FUEL GAUGE, THEN THE PANEL SAID LOW OIL PRESSURE SHUT OFF ENGINE. I RAN OUT OF GAS ON A BUSY HIGHWAY PASSING LANE ALMOST CAUSING A BAD ACCIDENT WITH MY 5 YEAR OLD IN THE BACK SEAT AS I COULD NOT TELL MY FUEL LEVEL. THE FUEL GAUGE WOULD WORK SPORADICALLY OVER THE NEXT …

Read full complaint

DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY READ EMPTY ON THE FUEL GAUGE, THEN THE PANEL SAID LOW OIL PRESSURE SHUT OFF ENGINE. I RAN OUT OF GAS ON A BUSY HIGHWAY PASSING LANE ALMOST CAUSING A BAD ACCIDENT WITH MY 5 YEAR OLD IN THE BACK SEAT AS I COULD NOT TELL MY FUEL LEVEL. THE FUEL GAUGE WOULD WORK SPORADICALLY OVER THE NEXT FEW DAYS AND THE LOW OIL PRESSURE WOULD GO AWAY AND COME BACK. WHEN I HAD THIS CHECKED OUT IT WAS THOUGHT TO BE THE OIL SENDING UNIT SO IT WAS CHANGED ALONG WITH THE FUEL SENDING UNIT. THE FUEL SENSOR WAS RESOLVED AT A COST OF $300 BUT THE LOW OIL PRESSURE CAME BACK ON EVEN THOUGH OIL WAS WELL MAINTAINED. SUDDENLY ON 3/1/2012 THE ENGINE RAN LOAD WHEN STARTED UP. I HAD TOWED TO THE SHOP WHERE (GM WHERE THEY DETERMINED THE ENGINE WAS NO GOOD. I HAD IT TOWED TO ANOTHER SHOP THAT DETERMINED THE ENGINE WAS NO GOOD AS WELL. I HAD TO PAY TO REPLACE THE ENGINE ALMOST $5000. I THEN LOOKED ONLINE FOR THIS ISSUE AND FOUND A WEBSITE TRAILVOY.COM (REPRESENT CHEVY TRAILBLAZER AND GMC ENVOY). HERE I FOUND 1000'S OF POST OF PEOPLE HAVING THE SAME ISSUES LOOKING TO FILE LAW SUITS AND WONDERING WHY WE CAN HAVE NO RECALL ON THIS DANGEROUS VEHICLE. THERE ORE 1000'S OF PEOPLE HAVING LOW OIL PRESSURE, DEAD ENGINES WITH LOW MILEAGE VEHICLES, RUN OUT OF GAS ON BUSY ROADS SUCH AS MYSELF AND MUCH MUCH MORE. THE GM ISSUES WE'VE EXPERIENCED AND ARE EXPERIENCING HAS BEEN HERE LONG BEFORE THE CURRENT ISSUES OF GM VEHICLES. HOW CAN WE GET SOMEONE WILLING TO HAVE THIS VEHICLE AND ISSUES ON THE RECALL LIST AND GET REIMBURSED FOR THE 1000'S OF DOLLARS SPENT TO REPAIR THIS VERY DEFECTIVE VEHICLE. IF A PETITION WILL DO IT PLEASE SHINE SOME LIGHT ON THIS. I HAD RECEIVED POST ON THE FORUM FROM NUMEROUS PEOPLE WILLING TO JOIN A CLASS ACTION SUIT AND MANY WERE CONSULTING ATTORNEYS ON HOW TO MOVE FORWARD WITH THIS. THIS IS A MAJOR ISSUE THAT WE DESPERATELY NEED THE NHTSA TO LOOK INTO. *TR

NHTSA ODI #10583758

Mileage unknown · Apr 14, 2014
Air BagsElectrical SystemEngine

SUBMISSION FROM CONSTITUENT RE RECALLS-2006 GMC ENVOY. *SMD THE CONSUMER STATED, HER HUSBAND WAS DRIVING, WHEN SUDDENLY THE VEHICLE STALLED. HE WAS ABLE TO COAST SAFELY TO A STOP. HOWEVER, THE VEHICLE WOULD NOT RE-START, AND THE VEHICLE HAD TO BE TOWED. ACCORDING TO THE INVOICE, THE IGNITION CYLINDER WAS REPLACED. ALSO, ON NU…

Read full complaint

SUBMISSION FROM CONSTITUENT RE RECALLS-2006 GMC ENVOY. *SMD THE CONSUMER STATED, HER HUSBAND WAS DRIVING, WHEN SUDDENLY THE VEHICLE STALLED. HE WAS ABLE TO COAST SAFELY TO A STOP. HOWEVER, THE VEHICLE WOULD NOT RE-START, AND THE VEHICLE HAD TO BE TOWED. ACCORDING TO THE INVOICE, THE IGNITION CYLINDER WAS REPLACED. ALSO, ON NUMEROUS OCCASIONS, THE AIR BAG LIGHT ILLUMINATED, AND REMAINED ON FOR DAYS. THE CONSUMER REFERENCED RECALL # 06V417000. *JB UPDATED 06/10/14 *JB UPDATED 10/14/14 *JB

NHTSA ODI #10582781

100,000 miles · Feb 26, 2014
Visibility/wiper

VEHICLE WIPERS STARTING TURNING ON WHEN WIPERS WERE SET TO OFF. THIS PROBLEM HAS PROGRESSIVELY GOTTEN WORSE . IT STARTED AS ONLY INTERMITTENTLY AND OCCASIONALLY HAVING THE WIPERS TURN ON FOR A COUPLE SWIPES AND THEN SHUTTING OFF. NOW THEY (THE WINDSHIELD WIPERS) START SWIPING WHEN THE VEHICLE IS STARTED AND YOU CAN HEAR THE W…

Read full complaint

VEHICLE WIPERS STARTING TURNING ON WHEN WIPERS WERE SET TO OFF. THIS PROBLEM HAS PROGRESSIVELY GOTTEN WORSE . IT STARTED AS ONLY INTERMITTENTLY AND OCCASIONALLY HAVING THE WIPERS TURN ON FOR A COUPLE SWIPES AND THEN SHUTTING OFF. NOW THEY (THE WINDSHIELD WIPERS) START SWIPING WHEN THE VEHICLE IS STARTED AND YOU CAN HEAR THE WINDSHIELD WASHER PUMP RUNNING, THE WIPERS WILL RUN UNTIL I TURN THE VEHICLE OFF. AT TIMES THIS IS FOR 30 MINUTES OR LONGER. *TR

NHTSA ODI #10565960

Official recalls

8

15V599000 · Visibility:power Window Devices And Controls

Sep 24, 2015

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

Consequence & remedy

Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.

15V519000 · Exterior Lighting:headlights

Aug 14, 2015

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

Consequence & remedy

Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

14V404000 · Visibility:power Window Devices And Controls

Jul 2, 2014

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

13V248000 · Electrical System; Visibility:power Window Devices And Controls

Jun 13, 2013

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Electrical System

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

12V406000 · Electrical System; Visibility:power Window Devices And Controls

Aug 16, 2012

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Electrical System

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

06V417000 · Air Bags:frontal

Oct 31, 2006

CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.

Consequence & remedy

Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.

Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.

05V552000 · Equipment:other:labels

Dec 7, 2005

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Consequence & remedy

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

05V455000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Oct 5, 2005

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17002 · Loss Of Headlights

Opened Apr 24, 2017 · Closed Mar 29, 2021

Status: closed (inferred from source dates) · Exterior Lighting:headlights

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

EA12004 · Driver's Master Power Window Switch

Opened Jun 11, 2012 · Closed Jun 21, 2013

Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Additional source detail variants (4)

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

DP10001 · Fuel Level Gauge System Failure

Opened Jan 7, 2010 · Closed May 23, 2011

Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Additional source detail variants (2)

Fuel System, Other

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.