OUR 2005 GMC ENVOY HAS ALWAYS HAD A FAULTY FUEL GAUGE AND HAS CAUSED OUR FAMILY TO BE STRANDED A FEW TIMES WITHOUT GAS WHILE TRAVELLING FAR FROM HOME. WE TOOK IT INTO A GMC DEALER WHO WANTED $ 950 FOR PARTS AND REPAIRS. WE JUST DONT HAVE THAT KIND OF MONEY. GMC HAS ALWAYS BEEN AWARE OF THIS PROBLEM AND HAS NOT OFFERED TO …
Read full complaint
OUR 2005 GMC ENVOY HAS ALWAYS HAD A FAULTY FUEL GAUGE AND HAS CAUSED OUR FAMILY TO BE STRANDED A FEW TIMES WITHOUT GAS WHILE TRAVELLING FAR FROM HOME. WE TOOK IT INTO A GMC DEALER WHO WANTED $ 950 FOR PARTS AND REPAIRS. WE JUST DONT HAVE THAT KIND OF MONEY. GMC HAS ALWAYS BEEN AWARE OF THIS PROBLEM AND HAS NOT OFFERED TO FIX IT NOR HAVE A RECALL ON THIS FAULTY GAS GAUGE. 856,000 GM SUVS UNDER INVESTIGATION FOR FAULTY FUEL GAUGES FEDERAL REGULATORS ARE INVESTIGATING 865,000 GENERAL MOTORS SUVS, INCLUDING THE 2005-?07 CHEVROLET TRAILBLAZER AND BUICK RAINIER,FOR FAULTY FUEL GAUGES THAT ARE INACCURATE. THE 2005-?06 CHEVROLET TRAILBLAZER EXT, THE 2005-?07 GMC ENVOY, THE 2005-?06 GMC ENVOY XL AND THE 2005-?07 SAAB 9-7X ARE ALSO AFFECTED VEHICLES BEING INVESTIGATED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
PURCHASED THE 2005 GMC ENVOY XUV USED IN 2009 WITH 41000 MILES. WITHIN 3 MONTHS THE ENVOY STARTED HAVING REAR DOOR LATCH FAILURES. THE REAR DOOR AND GLASS CAN BE OPENED IN A TRADITIONAL SIDE DOOR MODE OR A TRUCK BED MODE. FREQUENTLY THE ELECTRONIC LATCHES THAT OPERATE TO LET THE DOOR FUNCTION IN EITHER WAY WOULD FAIL. THE ENVOY …
Read full complaint
PURCHASED THE 2005 GMC ENVOY XUV USED IN 2009 WITH 41000 MILES. WITHIN 3 MONTHS THE ENVOY STARTED HAVING REAR DOOR LATCH FAILURES. THE REAR DOOR AND GLASS CAN BE OPENED IN A TRADITIONAL SIDE DOOR MODE OR A TRUCK BED MODE. FREQUENTLY THE ELECTRONIC LATCHES THAT OPERATE TO LET THE DOOR FUNCTION IN EITHER WAY WOULD FAIL. THE ENVOY HAS BEEN IN SEVERAL TIMES OVER THREE YEARS TO HAVE ALL THE LATCHES REPAIRED AND OR REPLACED. EACH LATCH HAS BEEN REPLACED SEVERAL TIMES. WHEN THE LATCHES FAIL, AND THEY HAVE FAILED IN A CONFIGURATION THAT WHEN I TRIED TO OPEN THE DOOR IN A SIDE DOOR WAY, THREE LATCHES LET LOSE AND THE DOOR FELL OPEN WITH ONLY ONE LATCH HOLING THE REAR DOOR ON. I WAS FORCED TO HAVE TO LIFT THE DOOR BACK INTO THE SLOTS WHERE THE DOOR PEGS LOCK INTO THE LATCHES. ONE TIME THREE LATCHES FAILED AND I HAD TO USE BUNGEE CORDS TO KEEP THE DOOR CLOSED SO THAT I COULD DRIVE IT TO THE DEALER TO HAVE THE LATCHES REPLACED. THE DEALER CHARGES ME 50 DOLLARS PER VISIT PER THE WARRANTY, HOWEVER THE VEHICLE HAS TO GO IN AT LEAST 3 TIMES A YEAR TO HAVE THE LATCHED LOOKED AT AND REPAIRED OR REPLACED. THEY REPLACE THE FIXED LATCHES AT NO COST BUT I STILL GET CHARGED 50 DOLLARS FOR THE VISIT. THE WARRANTY IS SOON TO BE OFF THIS VEHICLE. ALSO THE GAS GAUGE FAILED TO OPERATE CORRECTLY WITHIN MONTHS OF OWNING THE ENVOY. THE GAS GAUGE WOULD SHOW MORE FUEL THEN WHAT I HAD, OR SHOW NO FUEL WHATSOEVER EVEN THOUGH I HAD JUST FILLED THE GAS TANK UP. THE GAUGE NEEDLE WOULD BOUNCE BACK AND FORTH ALL THE TIME OR GET STUCK FULL OR EMPTY AS WELL. IT WAS FOUND THAT THERE WAS A BAD FUEL LEVEL SENSOR IN THE TANK. IT WAS REPLACED. I HAVE ALSO HAD TO REPLACE THE FRONT PINIONS OF THE ENVOY TWICE DURING THE THREE YEARS I HAVE OWNED IT BECAUSE THEY WERE LEAKING. I HAVE ALSO HAD TO HAVE THE DIFFERENTIAL CARRIER OVERHAULED BECAUSE THE FRONT DIFFERENTIALS WERE BOTH LEAKING. THESE PINIONS AND DIFFERENTIAL REPAIRS WERE THREE DIFFERENT VISITS TO THE DEALER, NOT AT ONCE. *TR
NHTSA ODI #10398607
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
2005 GMC Envoy Xuv Problems, Complaints & Recalls | Skip That Year
Illustration