IllustrationGAS GAUGE READS EMPTY ALL THE TIME. LOW FUEL ALARM WILL GO OFF RANDOMLY EVEN THOUGH THEIR IS FUEL IN THE CAR. BECAUSE OF THIS I NEVER KNOW HOW MUCH GASOLINE I REALLY HAVE. I HAVE RAN OUT OF GAS AND BEEN STRANDED ON THE SIDE OF THE ROAD B/C OF THIS. *TR
2005 GMC Envoy Xl 370
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy Xl 370 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
2225–50K
3050–75K
1975–100K
16100–150K
2150K+
91 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports3 injury reports
What owners actually said
104 reportsAT APPROXIMATELY 50,000 MILES, THE FUEL SENDING UNIT ON MY 05 GMC ENVOY XL QUIT WORKING. THE FUEL GAUGE INDICATOR WILL FLUCTUATE BUT MOSTLY READS EMPTY AND EMITS LOW FUEL WARNING BUZZER EVEN AFTER I HAVE FILLED THE GAS TANK. I SPOKE TO A SERVICE WRITER AT A LOCAL DEALERSHIP ABOUT THE PROBLEM. HIS RESPONSE WAS THE DEALERSHIP …
Read full complaint
AT APPROXIMATELY 50,000 MILES, THE FUEL SENDING UNIT ON MY 05 GMC ENVOY XL QUIT WORKING. THE FUEL GAUGE INDICATOR WILL FLUCTUATE BUT MOSTLY READS EMPTY AND EMITS LOW FUEL WARNING BUZZER EVEN AFTER I HAVE FILLED THE GAS TANK. I SPOKE TO A SERVICE WRITER AT A LOCAL DEALERSHIP ABOUT THE PROBLEM. HIS RESPONSE WAS THE DEALERSHIP SERVICE DEPARTMENT WOULD LOOK AT MY VEHICLE FOR ABOUT $300.00-NOT REPAIR THE PROBLEM-JUST DIAGNOSE IT. HE ALSO SAID THAT I WAS DRIVING THE VEHICLE TOO MUCH.*TR
2005 GMC ENVOY XL WITH 49000 MILES FUEL GAUGE NOT WORKING PROPERLY, WILL SHOW EMPTY AFTER FILLING UP THEN SHOW FULL. GAUGE WILL THEN SHOW 3/4 FULL THEN 1/2 FULL AFTER ONLY 10 TO 20 MILES. BEFORE 100 MILES GAUGE WILL DROP DOWN TO EMPTY FUEL LIGHT WILL COME ON AND BEEP. THIS WILL HAPPEN TILL TANK EMPTY, I NEVER KNOW HOW MUCH FUE…
Read full complaint
2005 GMC ENVOY XL WITH 49000 MILES FUEL GAUGE NOT WORKING PROPERLY, WILL SHOW EMPTY AFTER FILLING UP THEN SHOW FULL. GAUGE WILL THEN SHOW 3/4 FULL THEN 1/2 FULL AFTER ONLY 10 TO 20 MILES. BEFORE 100 MILES GAUGE WILL DROP DOWN TO EMPTY FUEL LIGHT WILL COME ON AND BEEP. THIS WILL HAPPEN TILL TANK EMPTY, I NEVER KNOW HOW MUCH FUEL IS IN TRUCK. I HAVE READ THAT IT COULD BE FUEL CAP, SO I REPLACED IT BUT NO FIX. I HAVE RUN OUT OF GAS ON HIGHWAY A COUPLE OF TIMES ALREADY. THIS PROBLEM HAS BEEN THE SAME THROUGH 20 FILL UPS.CAN YOU HELP,FROM WHAT I HAVE HEARD RUNS FROM 600 TO 1000 DOLLARS. *TR
PROB #1 DRIVING DOWN STREET REAR DOOR CAME OPEN AND WOULDN'T CLOSE. ALREADY REPLACED THE DOOR LATCH ON PASS REAR DOOR. IF I HAD CHILDREN IN THE CAR THIS WOULD'VE BEEN EXTREMELY DANGEROUS. TALKING TO OTHERS THIS IS NOT AN ISOLATED INCIDENT. PROBLEM #2 FUEL GAUGE JUST STOP WORKING, LOW FUEL LIGHT BEEPS CONSTANTLY. NEVER KNOW …
Read full complaint
PROB #1 DRIVING DOWN STREET REAR DOOR CAME OPEN AND WOULDN'T CLOSE. ALREADY REPLACED THE DOOR LATCH ON PASS REAR DOOR. IF I HAD CHILDREN IN THE CAR THIS WOULD'VE BEEN EXTREMELY DANGEROUS. TALKING TO OTHERS THIS IS NOT AN ISOLATED INCIDENT. PROBLEM #2 FUEL GAUGE JUST STOP WORKING, LOW FUEL LIGHT BEEPS CONSTANTLY. NEVER KNOW HOW MUCH FUEL IS IN CAR. COST TO REPLACE OVER $500! *TR
I HAVE A 2005 GMC ENVOY I6 THAT I PURCHASED IN MARCH 2005. NOVEMBER OF 2006 WE REPLACED THE FUEL SENSOR THAT IS UNDER WARRANTY DUE TO WHEN I WOULD FILL UP THE GAS TANK THE GAUGE WOULD GO TO EMPTY AND WOULD EVENTUALLY MAKE IT TO FULL AFTER ABOUT 100 MILES DRIVEN. NOW A YEAR AND A HALF LATER THE SAME THING IS HAPPENING AND THE…
Read full complaint
I HAVE A 2005 GMC ENVOY I6 THAT I PURCHASED IN MARCH 2005. NOVEMBER OF 2006 WE REPLACED THE FUEL SENSOR THAT IS UNDER WARRANTY DUE TO WHEN I WOULD FILL UP THE GAS TANK THE GAUGE WOULD GO TO EMPTY AND WOULD EVENTUALLY MAKE IT TO FULL AFTER ABOUT 100 MILES DRIVEN. NOW A YEAR AND A HALF LATER THE SAME THING IS HAPPENING AND THE LOCAL DEALERSHIP HAS CONFIRMED IT IS A KNOWN ISSUE AND WOULD COST AROUND $1100 TO FIX THE ISSUE THAT SHOULD HAVE ALREADY OF BEEN FIXED THE FIRST TIME I TOOK IT IN. *TR
REAR GLASS DOOR CAME UNGLUED AT HINGES DAMAGING THE STRUTS AND ALMOST FALLING ON MY HEAD. DEALER WAS CONTACTED AND REPLACING THE GLASS DOOR WAS SUGGESTED AT $1500.00. REPAIRING ATTEMPTED USING GLUE AND GLASS DOOR CAME LOOSE AGAIN. IT WAS A NEAR MISS, COULD BECOME A FATALITY. MAIN REAR DOOR STRUTS WERE DAMAGE AND THE DOOR ALM…
Read full complaint
REAR GLASS DOOR CAME UNGLUED AT HINGES DAMAGING THE STRUTS AND ALMOST FALLING ON MY HEAD. DEALER WAS CONTACTED AND REPLACING THE GLASS DOOR WAS SUGGESTED AT $1500.00. REPAIRING ATTEMPTED USING GLUE AND GLASS DOOR CAME LOOSE AGAIN. IT WAS A NEAR MISS, COULD BECOME A FATALITY. MAIN REAR DOOR STRUTS WERE DAMAGE AND THE DOOR ALMOST HIT ME AGAIN. *TR
THE FUEL GAUGE WENT OUT ON MY 2005 GMC ENVOY. IT JUST QUIT WORKING. I TOOK IT TO THE DEALERSHIP WE PURCHASED THE VEHICLE FROM AND IT HAD TO BE REPLACED TO THE TUNE OF $481. *TR
OPENING THE HATCH ON MY 2005 ENVOY XLS APPROX 1 TIME PER DAY CAUSED THE PISTONS AND THE BALLASTS TO GO BAD. THE VEHICLE HAS HAD CONTINUAL PROBLEMS WITH THE BACK DOOR HANDLES AND INTERIOR MECHANISMS FOR THE PAST 3 YEARS, WITH REPEATED TRIPS TO THE DEALER TO FIX THE PROBLEM. STILL NOT FIXED. *TR
POWER STEERING HOSE RUPTURED ON MY WIFE'S 2005 GMC ENVOY THANKFULLY JUST AS SHE WAS ENTERING OUR DRIVEWAY. I FEEL THIS IS A DEFECT IN THE HOSE ASSEMBLY AS THE VEHICLE ONLY HAS 48,000 MI ON IT AND IN 40+ YEARS OF DRIVING HAVE NEVER HAD THIS HAPPEN. IF THIS HAD HAPPENED ON THE ROADWAY I BELIEVE IT MAY HAVE CAUSED A SERIOUS ACCI…
Read full complaint
POWER STEERING HOSE RUPTURED ON MY WIFE'S 2005 GMC ENVOY THANKFULLY JUST AS SHE WAS ENTERING OUR DRIVEWAY. I FEEL THIS IS A DEFECT IN THE HOSE ASSEMBLY AS THE VEHICLE ONLY HAS 48,000 MI ON IT AND IN 40+ YEARS OF DRIVING HAVE NEVER HAD THIS HAPPEN. IF THIS HAD HAPPENED ON THE ROADWAY I BELIEVE IT MAY HAVE CAUSED A SERIOUS ACCIDENT AS IT RESULTED IN ALMOST TOTAL LOSS OF STEERING CONTROL. THE DEALER WAS EXCELLENT WITH THE REPAIR, BUT GM WAS UNWILLING TO ACKNOWLEDGE THE DEFECT. I FIND IT STRANGE THAT THE 06 MDL YEAR HAD POWER STEERING HOSE PROBLEMS AND A RECALL BUT THIS MDL YEAR WAS NOT INCLUDED,AS IT BURST IN THE EXACT WAY DESCRIBED IN THE RECALL. I FEEL THIS NEEDS INVESTIGATING AS THE VEHICLE WAS PURCHASED JUNE 2005 AND THE RECALL WAS DATED OCT 2005. *TR
#1 PROBLEM-- I ONLY HAVE 40,000 MILES ON MY CAR AND BOUGHT IT LESS THAN A YEAR AGO. MY FUEL TANK DOES NOT WORK-- IT FLOATS AND I NEVER KNOW HOW MUCH GAS I HAVE IN MY TANK #2 PROBLEM- DRIVING HOME LAST NIGHT-- I LOOKED DOWN AT MY SPEEDOMETER AND IT WAS STUCK OVER 120 MPH. I AM VERY UNHAPPY WITH GMC AND TELL EVERYONE I KNOW NEV…
Read full complaint
#1 PROBLEM-- I ONLY HAVE 40,000 MILES ON MY CAR AND BOUGHT IT LESS THAN A YEAR AGO. MY FUEL TANK DOES NOT WORK-- IT FLOATS AND I NEVER KNOW HOW MUCH GAS I HAVE IN MY TANK #2 PROBLEM- DRIVING HOME LAST NIGHT-- I LOOKED DOWN AT MY SPEEDOMETER AND IT WAS STUCK OVER 120 MPH. I AM VERY UNHAPPY WITH GMC AND TELL EVERYONE I KNOW NEVER TO BUY ANY CHEVY VEHICLES-- THESE PROBLEMS SHOULD NOT BE HAPPENING SO SOON ON A NEWER VEHICLE. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11014 · Fuel Level Gauge System Failure
Opened Apr 25, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Additional source detail variants (2)
Fuel System, Other
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.