2016 GMC Canyon

On [XXX] at approximately 5:30p, I was driving normal highway speed when I saw what I thought was exhaust trailing behind. There were NO dash warning lights, engine temperature showing normal range, car was performing normally. I pulled over to shoulder, turned off car, released the hood latch. My husband tried to open hood but it was too hot. We then realized it was smoke coming from under hood, not exhaust. Smoke began to come inside car through vents. I quickly exited the car, and within a minute the entire front end engine area was engulfed in flames. 911 was called, fire, police, highway patrol responded. Fortunately there was no injury to myself or husband. There was also concern of starting a brushfire risk here in SoCal, but it was all extinguished thoroughly. Truck was towed to Al’s Towing, 475 W Vermont Ave, Escondido CA 92025, ph 760-745-5933. A report has been filed with our insurance USAA, inspection by adjuster is pending. I also notified Temecula GMC, where I purchased vehicle from, of the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Stability track Cameondoing 50mph transmission geared down motor shut down on and off yes it's available problem not found by dealer took to 2 different ones stability track comes on side lights stay on and off press brakes it shut down turn left it shut down motor running in park put in reverse shut down Will drive and run sometimes but gets worse

Purchased this vehicle brand new and paid extra for Nav and a backup camera as I am a disabled Veteran! Currently have 32000 miles or so as i don't drive that much. No other lights or warnings came up before the following happened. Recently the radio stopped playing and the infotainment system went blank. It occasionally pops up a screen that says waiting on update, other than that it stays blank most of the time. The backup camera comes on intermittently but not always when backing up, maybe 1 out of every 5 times. Also the bluetooth went dead since this all started. As a disabled Vet I depend on the backup camera and built in Navigation so this is an issue! Called the dealer and 3 other radio and entertainment car stores and they stated this is a know issue and would cost around $1000 to $1200 to replace the HMI 2.5 module behind the dash which is the known issue. Looking online this is a well known and common issue and GMC has bulletins to diagnose but no free or discounted replacement or repair, even though it's all over the internet that GMC and Chevy Infotainment centers have issues. There is a class action lawsuit going on due to this issue as well. I'm sure there are others that just haven't complained and should be fixed by the dealer.

The key does not always release from the ignition after parking the truck. I have to shift into Drive and back into Park multiple times or wait up to a minute to remove the key. Took it to the dealership, but at that time, it was only happening once a week or so, and they could not reproduce the problem. 3 years later and it still happens and it's getting much worse. Happens at least once a day. I have seen this problem pop-up on many forums, and while it is not a safety issue, it is a quality issue that should be addressed by GMC.

The malfunction is: no power, no crank, no electricity at all, can not use key fob to lock/unlock, radio does not work, dash does not work, literally 0 lights 0 power when key is in ignition to and turning to start or when key is not in ignition. The positive battery terminal also overheats to extreme temps which caused my dad a 3rd degree burn since positive terminals should never be hot. Dates of malfunction that have left me stranded 7/16, 8/3, 8/5, 8/11, 8/12, 8/28. I have video evidence of the malfunction on each of those dates. The way we got it to fix is by banging on the battery. on 8/12 I brought the truck to the dealership because I banged on the battery I got error codes- Engine Power Reduced, and Stabilitrak Offline. The engine was shaking very badly, I have video. hey have the truck for a week, get it to trigger the same incident and determine its a bad battery cell that could only be detected when the malfunction was happening. They replaced the battery. On 8/28 the same malfunction happens except nothing is fixing it, not banging on the battery, not waiting 24+ hours. Prior to me buying the truck on June 28th the previous owner has an invoice in the glove box dated May 25th to try to fix the same issues. I bought this from the dealership not the previous owner. The vehicle still sits at the dealership trying to diagnose the issue.

When I put my GMC Canyon into park, the key will not release from the ignition. This does not happen every time, but it is a recurring problem. I first had the issue back on April 6, 2018 and the dealer "fixed" the issue. Three weeks later, April 27, 2018, I had the same issue. This time the dealer replaced the "shift control assembly". The truck was still under warranty so there was no financial burden on me. Then on September 2, 2020 the same issue happened and the shift control assembly had to be replaced again. This time the truck was not under warranty and it cost me $688.72. Now August 2022 the key is not releasing from the ignition once again. This is the 4th time for the same issue. I believe GMC needs to recall this part and come up with a fix that will work.

The contact owns a 2016 GMC Canyon. The contact stated that while the gear shifter was in park(P), the contact was unable to be removed from the ignition. The contact was able to remove the key after several attempts. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the ignition switch needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 55,223.