NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
57 reportsClear category filter101,250 miles · Jun 26, 2016
Electronic Stability Control (esc)SteeringSuspension
I NOTICED THAT WHEN DRIVING ON AN EXPRESSWAY AND WOULD ATTEMPT TO PASS A SLOWER MOVING VEHICLE, AS I WOULD MOVE INTO THE PASSING LANE AND ATTEMPT TO ACCELERATE, THE CAR WOULD HESITATE FOR A FEW SECONDS, LOSE SPEED, THEN SUDDENLY DOWNSHIFT AND ACCELERATE AT AN UNEXPECTED RATE. I ALSO NOTICED THAT THE CAR WOULD UNEXPECTEDLY A…
Read full complaint
I NOTICED THAT WHEN DRIVING ON AN EXPRESSWAY AND WOULD ATTEMPT TO PASS A SLOWER MOVING VEHICLE, AS I WOULD MOVE INTO THE PASSING LANE AND ATTEMPT TO ACCELERATE, THE CAR WOULD HESITATE FOR A FEW SECONDS, LOSE SPEED, THEN SUDDENLY DOWNSHIFT AND ACCELERATE AT AN UNEXPECTED RATE. I ALSO NOTICED THAT THE CAR WOULD UNEXPECTEDLY ACCELERATE OR DECELERATE UNDER NORMAL DRIVING CONDITIONS. I BOUGHT THE VEHICLE TO THE DEALER FOR REPAIR, THEY RESPONDED THAT THEY COULD FIND NOTHING WRONG, BUT THE WHAT I WAS EXPERIENCING WAS CHARACTERISTIC OF THE 6-SPEED TRANSMISSION ON THE VEHICLE. THE PROBLEM CONTINUED AND I FOUND IT DANGEROUS. I RETURNED THE VEHICLE AND THE DEALER'S REMEDY WAS TO "RESET THE TRANSMISSION COMPUTER." DURING THIS TIME, I ALSO NOTICED THAT THE "SERVICE STABILITRAC AND TRACTION CONTROL" WARNING WOULD COME ON. IT DOSEN'T MATTER IF YOUR DRIVING OR IDLE OR IN PARK THESE WARNINGS AND PROBLEMS STILL EXIST.THE DEALER FIXED ONE WHEEL SENSOR BUT THE PROBLEM STILL OCCURS. THE SERVICE AIRBAG WARNING LIGHTS STILL COMES ON THERE WAS A RECALL FOR THAT I HAD IT FIXED BUT WARNING STILL COMES ON. THIS VEHICLE HAS HAD SO MANY RECALLS AUTOMATIC LIFT GATE, AIR BAG WARNINGS, POWER STEERING PUMP AND HOSE. THE RACK & PINION WILL NEED TO BE REPLACED IN THE VEHICLES SHORT LIFE SPAN, ALL OF THE SUSPENSION PARTS BUSHINGS WILL HAVE TO BE REPLACED AT SOME POINT SO THIS MEANS CONTROL ARM, SWAY BAR SWAY, SWAY BAR LINKS TOE LINKS OF COURSE WITH THESE ISSUES YOU WILL HAVE TO REPLACE STRUTS AND SHOCKS, ETC...HOW CAN GOVERNMENT/GENERAL MOTORS SELL A VEHICLE THIS EXPENSIVE AND HAVE SO MANY PROBLEMS THESE VEHICLES ARE UNSAFE TO DRIVE SOMETHING NEEDS TO BE DONE ABOUT THIS BEFORE SOMEONE GETS SERIOUSLY HURT.MY 08 GMC ACADIA IS PURE GARBAGE SOMEONE NEEDS TO BE HELD ACCOUNTABLE BECAUSE THESE VEHICLES HAVE MAJOR MECHANICAL AND ELECTRICAL ISSUES, RECALLS AND ARE UNSAFE TO BE DRIVING
NHTSA ODI #10876670
86,000 miles · Jun 21, 2016
Electronic Stability Control (esc)EngineSteering
MY 2008 ACADIA IS NOW ON IT'S 4TH THERMOSTAT. I'M ABOUT TO SEND IT IN TO HAVE IT REPLACED. MY SUV KEEPS OVERHEATING. SO FAR I HAVE REPLACED THE RADIATOR, THERMOSTAT, AND STABILITY TRACK. IS THERE ANY ONE ELSE WHO HAS THIS PROBLEM?
NHTSA ODI #10875489
Mileage unknown · Jun 6, 2016
Electronic Stability Control (esc)
EITHER WHEN I FIRST START THE CAR OR WHEN THE CAR IS IN MOTION THE STABILITRAK AND THE TRACTION CONTROL WARNING COMES ON- SOMETIMES IT COMES WITH AN ENGINE POWER REDUCED WARNING AND THE CAR DOES NOT DRIVE WELL UNTIL I CAN PULL OVER AND TURN IT OFF- WAIT A COUPLE OF MINUTES AND SOMETIMES IT CLEARS WHEN I TURN IT BACK ON AND OTHER…
Read full complaint
EITHER WHEN I FIRST START THE CAR OR WHEN THE CAR IS IN MOTION THE STABILITRAK AND THE TRACTION CONTROL WARNING COMES ON- SOMETIMES IT COMES WITH AN ENGINE POWER REDUCED WARNING AND THE CAR DOES NOT DRIVE WELL UNTIL I CAN PULL OVER AND TURN IT OFF- WAIT A COUPLE OF MINUTES AND SOMETIMES IT CLEARS WHEN I TURN IT BACK ON AND OTHER TIMES THE WARNING IS STILL THERE. MORE RECENTLY IT IS ALSO HAVING THE BRAKE WARNING LIGHT COME ON AND I REPLACED THE FRONT BRAKE PADS ONLY 2 MONTHS AGO SO I KNOW ITS NOT MY BRAKES. NEED THIS FIXED ASAP!
NHTSA ODI #10872779
87,000 miles · Feb 26, 2016
Electronic Stability Control (esc)EngineVehicle Speed Control
WHILE DRIVING THE VEHICLE AT A NORMAL SPEED (55) ON A HIGHWAY, A DINGING SOUND COMES ON AND THE CAR GOES INTO REDUCED POWER MODE, LOSING SPEED. THE STABILITRAK AND THE TRACTION CONTROL WARNING COMES ON. THIS MAKES IT DIFFICULT TO CROSS TRAFFIC AT INTERSECTIONS AS THE CAR WILL BARELY ACCELERATE. THERE IS NO WARNING THAT THIS IS …
Read full complaint
WHILE DRIVING THE VEHICLE AT A NORMAL SPEED (55) ON A HIGHWAY, A DINGING SOUND COMES ON AND THE CAR GOES INTO REDUCED POWER MODE, LOSING SPEED. THE STABILITRAK AND THE TRACTION CONTROL WARNING COMES ON. THIS MAKES IT DIFFICULT TO CROSS TRAFFIC AT INTERSECTIONS AS THE CAR WILL BARELY ACCELERATE. THERE IS NO WARNING THAT THIS IS GOING TO HAPPEN. ALSO, THE CARS BEHIND YOU DO NOT KNOW WHY YOU ARE SLOWING DOWN. THEN WHEN YOU TURN THE CAR OFF AND RESTART IT, THE LIGHTS GO OFF AND THE CAR DRIVES FINE. AFTER THREE TRIPS TO THE GMC DEALER, THE THROTTLE BODY WAS DETERMINED TO BE THE PROBLEM. GMC HAS ISSUED SPECIAL CIRCUMSTANCES WARRANTY ON THE 2007 & THE 2009 BUT NOT THE 2008. I DO NOT FEEL THAT THE WARRANTY IS SUFFICIENT. I DO NOT UNDERSTAND WHY THERE IS NOT A RECALL BECAUSE AFTER SEARCHING THE FORUMS, I HAVE FOUND THAT THERE ARE NUMEROUS COMPLAINTS WITH THIS HAPPENING. I HAD MY GRANDKIDS IN THE CAR WITH ME AND WE COULD HAVE BEEN HURT WHEN WE HAD THE SUDDEN LOSS OF POWER WE EXPERIENCED.
NHTSA ODI #10838625
Mileage unknown · Jan 27, 2016
Air BagsElectrical SystemElectronic Stability Control (esc)
I HAVE HAD SERVICE AIR BAG LIGHTS COME ON ALL THE TIME ALONG WITH SERVICE STABLETRACK AND AND I THINK SOMETHING WITH THE FUEL WHEN I GET GAS IT MAKES WEIRD SOUNDS AND WON'T START WITHOUT PUMPING THE GAS TO GET IT STARTED.
NHTSA ODI #10822705
197,600 miles · Jan 25, 2016
Electronic Stability Control (esc)Service Brakes
GOING DOWN THE HIGH WAY THE STABILITRACK LIGHT COMES ON AFTER TURNING OFF THE CAR TURNING IT BACK ON IT GOES OUT THE LIGHT HASN'T CAME BACK ON ITS BEEN A COUPLE MONTHS IT ONLY COMES ON WHEN DRIVING FAR. ALSO HAVE A PROBLEM WITH THE BRAKES THEY GO ALL THE WAY TO THE FLOOR HARD TO STOP THE CAR. MY GIRLFRIEND TOLD ME ABOUT THE PROB…
Read full complaint
GOING DOWN THE HIGH WAY THE STABILITRACK LIGHT COMES ON AFTER TURNING OFF THE CAR TURNING IT BACK ON IT GOES OUT THE LIGHT HASN'T CAME BACK ON ITS BEEN A COUPLE MONTHS IT ONLY COMES ON WHEN DRIVING FAR. ALSO HAVE A PROBLEM WITH THE BRAKES THEY GO ALL THE WAY TO THE FLOOR HARD TO STOP THE CAR. MY GIRLFRIEND TOLD ME ABOUT THE PROBLEM I DROVE IT MYSELF TO SEE IF IT WOULD DO IT TO ME NEVER DID TILL TODAY I ALMOST HIT 2 CARS
NHTSA ODI #10821952
80,000 miles · Dec 8, 2015
Electronic Stability Control (esc)SteeringSuspension
RECEIVED NOTICE FROM GM RE POWER STEERING, DO NOT TAKE TO VEHICLE FOR SERVICE UNLESS PROBLEM IS KNOWN. I TOOK VEHICLE FOR TIRE ROTATION AND MECHANIC NOTICED POWER STEERING FLUID LEAKING, CAUSED DAMAGE TO RACK, PINION, ETC. (ESTIMATE ATTACHED). CALLED GM DEALER AND GM CUST SERVICE, WILL ONLY COVER DEFECTIVE POWER STEERING PUMP NO…
Read full complaint
RECEIVED NOTICE FROM GM RE POWER STEERING, DO NOT TAKE TO VEHICLE FOR SERVICE UNLESS PROBLEM IS KNOWN. I TOOK VEHICLE FOR TIRE ROTATION AND MECHANIC NOTICED POWER STEERING FLUID LEAKING, CAUSED DAMAGE TO RACK, PINION, ETC. (ESTIMATE ATTACHED). CALLED GM DEALER AND GM CUST SERVICE, WILL ONLY COVER DEFECTIVE POWER STEERING PUMP NOT THE DAMAGE CAUSED BY DEFECTIVE PUMP. SINCE GM ADVISED NOT TO GET FIXED UNTIL ISSUE OCCURS (I STILL HAVE POWER STEERING, WAS NOT AWARE OF THE ISSUE UNTIL TIRES WERE ROTATED) WHY SHOULD I BE LIABLE FOR THE ADDITIONAL DAMAGE CAUSED? ALSO, THIS MORNING 12/08/15, WHILE TAKING MY DAUGHTER TO SCHOOL, THE CAR BUCKLED AND STABILTRAK, CHECK ENGINE LIGHT CAME ON WITH A MESSAGE "POWER REDUCED", ONLY ABLE TO DRIVE 20-25 MILES. THE SAME ISSUE OCCURRED APPX. A YEAR AGO AND I FILED A COMPLAINT. THE LIGHT GOES AND OFF JUST LIKE A YEAR AGO. AFTER READING SEVERAL BULLETINS FOR THE 2008 GMC ACADIA, ALL THE ABOVE ISSUES ARE A KNOWN ISSUE. I SHOULD NOT HAVE TO PAY FOR VEHICLE DEFECTS THAT ARE COMMON IN ALL OF THE VEHICLES.
NHTSA ODI #10808993
Mileage unknown · Nov 27, 2015
Electronic Stability Control (esc)Power TrainUnknown Or Other
TRANSMISSION STARTED GETTING SLUGGISH AROUND 88, 000 MILES. VEHICLE WOULDN'T CRANK DUE TO ELECTRICAL STABILIZER, NOW MY SUNROOF IS LEAKING. DEALERSHIP IS GOING TO CHARGE ME $275 DOLLAR TO UNBLOCK THE SUNROOF DRAINS WHAT A RIP OFF WHEN THIS IS THE THREE TIME I HAVE HAD THE DRAINS CLEANED AND THE SUNROOF STILL LEAK. THIS HAS TO …
Read full complaint
TRANSMISSION STARTED GETTING SLUGGISH AROUND 88, 000 MILES. VEHICLE WOULDN'T CRANK DUE TO ELECTRICAL STABILIZER, NOW MY SUNROOF IS LEAKING. DEALERSHIP IS GOING TO CHARGE ME $275 DOLLAR TO UNBLOCK THE SUNROOF DRAINS WHAT A RIP OFF WHEN THIS IS THE THREE TIME I HAVE HAD THE DRAINS CLEANED AND THE SUNROOF STILL LEAK. THIS HAS TO BE A GMC PROBLEM THAT THEY REFUSE TO ACKNOWLEDGE. THE TRANSMISSION IS STILL UNDER THE GMC WARRANTY SO THANK GOD I DON'T HAVE TO PAY OUT OF POCKET FOR THAT. THE ELECTRICAL MODULES SEEM TO BE OKAY FOR NOW BUT AT ANY GIVING TIME THE VEHICLE MAY STOP WORKING. GMC SHOULD OWN UP TO THESE PROBLEMS AND LOOK OUT FOR THEIR CUSTOMERS.
NHTSA ODI #10807250
111,900 miles · Sep 17, 2015
Electronic Stability Control (esc)
DRIVING HOME FROM WORK, GOT ON THE HIGHWAY AND WAS GOING ABOUT 70MPH AND THE TRACTION CONTROL LIGHT CAME ON. THEN THE MESSAGE DISPLAYED TO SERVICE STABILIZER TRAK. THEN THE MESSAGE SERVICE TRACTION CONTROL. N THE CAR STARTED ROCKING SIDE TO SIDE. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS SUV SINCE I BOUGHT IT. IT IS THE MOST…
Read full complaint
DRIVING HOME FROM WORK, GOT ON THE HIGHWAY AND WAS GOING ABOUT 70MPH AND THE TRACTION CONTROL LIGHT CAME ON. THEN THE MESSAGE DISPLAYED TO SERVICE STABILIZER TRAK. THEN THE MESSAGE SERVICE TRACTION CONTROL. N THE CAR STARTED ROCKING SIDE TO SIDE. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS SUV SINCE I BOUGHT IT. IT IS THE MOST SCARIEST CAR TO DRIVE. I WOULD LOVE TO TRADE IT IN, BUT CAN'T BECAUSE OF THE NEGATIVE EQUITY.
NHTSA ODI #10764490
90,000 miles · Jul 17, 2015
Electronic Stability Control (esc)Equipment Adaptive/mobilityService Brakes
THE SERVICE BRAKE LIGHT AND STABILATRAC COMES ON EVERY TIME YOU START THE VEHICLE AND SOMETIMES WHILE DRIVING. HAVE NOT RECEIVED A QUOTE FROM THE DEALERSHIP YET. WILL THERE BE A RECALL THAT EFFECTS THIS OR IS IT OUR PROBLEM TO DROP 1500 DOLLARS TO REPAIR A MANUFACTURER DEFECT
NHTSA ODI #10734872
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration