Power Train. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports7 fire reports11 injury reports

What owners actually said

428 reports

63,500 miles · Jul 16, 2013

EnginePower Train

CAR SHUT DOWN WHILE I WAS DRIVING. AFTER AWHILE IT STARTED BACK UP BUT IT WOULD ONLY GO ON FIRST GEAR SO I COULD GO MORE THAN 20MPH. THEN WHEN I WENT HOME, THE CHECK ENGINE LIGHT CAME ON AND THE REVERSE DID NOT WORK. I HAVE READ ALOT OF COMPLAINTS ABOUT THE SAME PROBLEM WITH 2007 ACADIAS. I HOPE THESE CARS GET RECALLED BECAUSE S…

Read full complaint

NHTSA ODI #10525232

92,000 miles · Jul 15, 2013

Engine

Read full complaint

OUR CAR WAS SERVICED BY JIM SALERNO GMC IN RANDOLPH,NJ ON 5/4/13. THE CAR WAS BROUGHT IN TO CHECK THE TRANSMISSION THAT WAS INSTALLED BY SALERNO IN 2011 BUT WE WERE TOLD TRANS IS OK, THE TIMING CHAINS NEED TO BE REPLACED. WE GET THE JOB DONE WHICH REQUIRES THEM TO TAKE THE ENGINE OUT OF THE CAR. WE GET THE CAR BACK FROM THEM AND IT IS IDLING VERY LOW TO THE POINT IT STALLED ONCE WHEN MY WIFE STOPPED TO GET OUT OF THE CAR TO GET OUR MAIL. AND WE NOTICED IT DIDN'T START UP THE SAME AS BEFORE (SLOWER) BUT WE DIDN'T MENTION THIS TO SALERNO BECAUSE WE TRUSTED THEM IN DOING THE JOB RIGHT (BIG MISTAKE!) FOR THE NEXT FEW WEEKS, MY WIFE DOES SOME LOCAL DRIVING WITH THE CAR UNTIL 6/22/13 WHEN WE (MY WIFE AND I AND OUR TWO SMALL CHILDREN AND OUR DOG) LEFT FOR A LONG DRIVE UP TO MAINE. WE MADE IT INTO MASSACHUSETTS AND THEN AN ENGINE LIGHT CAME ON FOLLOWED BY A LOT OF RATTLING FROM THE ENGINE. THIS WAS QUITE SCARY SINCE THE CAR STARTED DRIVING ERRATICALLY AND WE WERE TRAVELING AT HIGH SPEEDS ON RT 84. WE LUCKILY PULL OVER INTO A SMALL REST STOP AND 5 HOURS LATER, A INGERSOLL GMC COMES WITH A FLATBED TRUCK AND A LOANER CAR. *TR

NHTSA ODI #10524795

83,680 miles · Jul 13, 2013

EnginePower Train

Read full complaint

VEHICLE IS HARD SHIFTING FROM 1ST TO 2ND GEAR. HAD SERVICED WITH NEW TRANSMISSION FLUID ON 7/2/13. ON 7/5/13 VEHICLE WOULD NO LONGER SHIFT AT ALL WHILE TRAVELING ON THE FREEWAY ON OUR WAY TO FAMILY VACATION TO HILTON HEAD SC. IT WAS TOWED TO PARKS CHEVROLET IN CHARLOTTE, NC WHERE TRANSMISSION WAS DISASSEMBLED WITH PARTS REPLACED AND REBUILT. UPON DEPARTURE OF PICKUP VEHICLE IS STILL SHIFTING HARD FROM 1ST TO 2ND GEAR (AROUND 20-25MPH) AND WE HOPE TO MAKE BACK HOME TO OHIO SAFELY. I'VE RESEARCHED THIS ISSUE IS COMMON IN GMC ACADIAS. ISSUES NEEDS ADDRESSED AND RESOLVED FOR SAFETY! I WILL BE RETURNING THE VEHICLE TO CHEVY DEALER WHEN WE RETURN HOME FOR FURTHER SERVICE. WE HAVE ALREADY PAID THE WARRANTY DEDUCTIBLE AND HOPE TO NOT INCUR MORE EXPENSES! *TR

NHTSA ODI #10524673

77,000 miles · Jul 11, 2013

Electronic Stability Control (esc)Vehicle Speed Control

Read full complaint

MY CAR WOULD NOT GO OVER 40 MPH ON A HIGHWAY AND THE RPMS WERE SHOOTING UP TO 9,000. I SAFELY MADE IT TO A PARKING LOT AND WHEN I WENT TO LEAVE THE CAR WOULD NOT MOVE IN REVERSE! I HAD TO PUSH THE CAR, WITH MY 5 CHILDREN IN IT, OUT OF THE SPOT!! (I'M A TOUGH CHICK BUT THIS WAS CRAZY!). I GOT THE CAR OUT OF THE LOT AND WAS ABLE TO SLOWLY MAKE IT HOME. MY CAR IS ONLY 10 MONTHS PAST WARRANTY AND WE WILL BE STUCK WITH A BIG BILL. I THINK IT SHOULD BE COVERED OR GMC SHOULD REIMBURSE THE REPAIR FEE. *TR

NHTSA ODI #10524331

75,000 miles · Jul 8, 2013

Air Bags

Read full complaint

SERVICE AIRBAG LIGHT ILLUMINATED IN THE DASH; TECHNICAL SERVICE BULLETIN AVAILABLE TO DEALER FOR SIMILAR ISSUE ONLY COVERS THE AIRBAG CONNECTOR NOT THE AIRBAG MODULE, WHICH HAS GONE OUT IN THIS VEHICLE, ON THE PASSENGER SIDE. I HAVE DISCUSSED WITH DEALER AND GM AND THEY ARE UNWILLING TO REPAIR THIS SAFETY ISSUE. THIS APPEARS TO BE A COMMON DEFECT IN THE 2007, 2008 GMC ACADIA AS WELL AS THE BUICK ENCLAVE AND EARLY CHEVY TRAVERSE. A SIMPLE INTERNET REVIEW WILL SHOW MULTIPLE COMPLAINTS. GM IS UNWILLING TO RECALL THESE VEHICLES FOR THIS PART WHICH WOULD BE THE PROPER CUSTOMER CARE BUT INSTEAD WILL COMPLAIN HERE FOR REVIEW. A REVIEW OF THE NUMBER OF VEHICLES AFFECTED BY THIS SAFETY ISSUE IS NEEDED. *TR

NHTSA ODI #10523791

84,000 miles · Jul 2, 2013

Power Train

Read full complaint

THE CAR SUDDENLY LOST POWER ON THE INTERSTATE. IT LOCKED DOWN INTO "LIMP HOME" MODE. WE HAD CRAWL ALONG THE BERM AT 30 MPH. THE PROBLEM WAS DIAGNOSED BY GM AS TRANSMISSION FAILURE DUE TO FAILING OF THE WAVE PLATE. THIS WAVE PLATE IS A KNOWN PROBLEM TO GM BUT AS OF NOW NO RECALL HAS BEEN ISSUED. I HAVE READ ONLINE BLOGS ABOUT THIS ISSUE AND IT IS A FREQUENT AND UNSAFE FAILURE OF THIS DRIVE-TRAIN. OUR CAR IS OUT OF WARRANTY BY YEARS BUT ONLY HAS 84K MILES ON IT. GM HAS OFFERED US A 50/50 SPLIT ON THE REPAIR WHICH THEY WOULD NEVER DO IF THEY WERE NOT AWARE OF THIS ISSUE. I THINK IT SHOULD BE THEIR FULL RESPONSIBILITY. PLEASE INVESTIGATE, THANK YOU. *TR

NHTSA ODI #10522782

93,000 miles · Jun 25, 2013

Power Train

Read full complaint

DRIVING UP HILL, LOOSING POWER, FINALLY MADE IT UP HILL CAR JUST STOPPED - ALMOST LIKE IT WAS IN NEUTRAL GEAR. COULDN'T GO ANYWHERE, CAR STARTED RIGHT UP AND WHEN I PRESSED ON GAS IT REVVED UP LIKE IT WANTED TO GO, BUT NO MOVEMENT. STILL LIKE IN NEUTRAL GEAR. FOUND OUT THAT LOTS OF 07 AND 08 ACADIA OWNERS HAVE HAD ISSUES WITH THE WAVE PLATE (WHICH IS WHAT MECHANIC AT DEALERSHIP TOLD ME IT IS). AND THE POWER TRAIN, WHICH ENDS UP MAKING THE TRANSMISSION FAIL. THERE ARE FAR TOO MANY ACADIAS OWNERS OUT THERE WHO HAVE HAD THESE ISSUES. I THINK IT'S WRONG THAT GMC DOESN'T INVESTIGATE OR RECALL THE CARS FOR THIS COST. I CALLED GMC CUSTOMER SERVICE AND FEEL AS IF THEY DON'T TRULY CARE, THEY JUST WANT TO SNUB OFF THE ISSUE AND TELL YOU TO HAVE A GREAT DAY! MY DAD WORKED FOR GMC FOR 20 YEARS, AND I ALWAYS HAD A HIGH OPINION OF THEM UP UNTIL NOW. I AM VERY DISAPPOINTED IN THEM. I FEEL LIKE THEY HAVE LOST THEIR LOYAL CUSTOMERS. BECAUSE OF THIS I WILL NEVER AGAIN BUY GMC WHICH IS A SHAME BECAUSE THAT'S ALL MY DAD BOUGHT IN THE PAST IS GMC. I AM GRATEFUL THAT THE CAR DIDN'T GIVE OUT WHILE I WAS GOING UP THE HILL AND I DIDN'T HAVE MY KIDS IN THE CAR. LUCKILY I WAS ABLE TO MAKE IT UP THE HILL. I FEEL GMC SHOULD STEP UP AND INVESTIGATE THIS ISSUE AND REPLACE THEM WITH MORE QUALITY PARTS. I FEEL AS IF THE ACADIA IS VERY CHEAPLY MADE. *TR

NHTSA ODI #10521671

95,000 miles · Jun 18, 2013

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2007 GMC ACADIA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE CONTACT HEARD RATTLING FROM THE FRONT END AND NOTICED A BURNING OIL SMELL. THE VEHICLE WAS INSPECTED BY A MECHANIC, WHO STATED THAT FOUR OF THE DRIVE-SHAFT BOLTS WERE MISSING AND TWO WERE BENT. THE VEHICLE WAS THEN TAKEN TO A DEALER BUT THEY WERE UNABLE TO DETERMINE THE CAUSE FOR THE FAILURE. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGE WAS 95,000. ...UPDATED 07/22/13 *BF

NHTSA ODI #10520444

80,000 miles · Jun 18, 2013

Power Train

Read full complaint

THIS ISSUE STARTED WHEN I WAS DRIVING DOWN THE ROAD AT 35MPG. THE ACADIA TRIED TO SHIFT INTO A HIGHER GEAR BUT CLUNKED VERY LOUDLY AND JOLTED THE WHOLE CAR. FROM THAT POINT FORWARD THE VEHICLE WAS STICK IN 3RD GEAR. IT WOULDN'T UP SHIFT OR DOWN SHIFT. THE CAR LIMPED HOME BUT STARTING ON HILLS OR AT STOP SIGNS WAS ALMOST IMPOSSIBLE. ONCE I GOT THE CAR HOME I CHECKED THE TRANSMISSION FLUID. TRANSMISSION FLUID OK. I THEN TESTED THE CAR AGAIN BY TRYING TO BACK OUT OF THE DRIVEWAY. THE TRANSMISSION MADE A LOUD GRINDING NOISE AND WOULD NOW LONGER MOVE IN REVERSE. I HAD THE CAR TOWED FROM MY HOUSE TO A LOCAL TRUSTED MECHANIC. THE MECHANIC STATED THAT THE WAVEPLATE FAILED. HE ALSO SAID THAT THIS WAS A KNOW DEFICIENCY IN THESE VEHICLES AND THAT THE TRANSMISSION WOULD NEED TO BE REPLACED OR REBUILT. I HAD TO SPEND $3950 TO REBUILD THE TRANSMISSION ON A 2007 VEHICLE WITH 80000 MILES. I WOULD APPRECIATE A REIMBURSEMENT FROM GM FOR THIS OBVIOUS QUALITY PROBLEM. *TR

NHTSA ODI #10520398

101,000 miles · Jun 18, 2013

Electrical SystemVisibility

PROBLEMS WITH WINDOW CONTROL WHILE DRIVING, UNABLE TO RAISE UP WINDOW ON PASSENGER SIDE FROM THE DRIVER CONTROLS. *TR

NHTSA ODI #10520371

Official recalls

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

07V062000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Feb 21, 2007

ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.

Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12003 · Loss Of Headlamp Illumination

Opened Jun 4, 2012 · Closed Jul 24, 2014

Status: closed (inferred from source dates) · Exterior Lighting:headlights

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

Electrical System

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring

Engine And Engine Cooling:engine

Engine And Engine Cooling

Visibility:windshield Wiper/washer

Visibility:windshield Wiper/washer:switch/wiring