JUST BOUGHT THIS TRUCK FROM HUBBARD TRAILERS, IN ARIZONA, WITH A RECEIPT FROM HAVING BOTH REAR BRAKES REDONE. DROVE IT HOME THEN TOOK IT TO THE LOCAL FL DEALERSHIP (NAMPA, ID) TO GET AN OFFICIAL INSPECTION. ON INSPECTION THE ABS AND BRAKE LIGHTS WERE ON. WORK WAS DONE, AND I WAS TOLD EVERYTHING WAS FINE ON THE TRUCK RE:BRAKES. I…
Read full complaint
JUST BOUGHT THIS TRUCK FROM HUBBARD TRAILERS, IN ARIZONA, WITH A RECEIPT FROM HAVING BOTH REAR BRAKES REDONE. DROVE IT HOME THEN TOOK IT TO THE LOCAL FL DEALERSHIP (NAMPA, ID) TO GET AN OFFICIAL INSPECTION. ON INSPECTION THE ABS AND BRAKE LIGHTS WERE ON. WORK WAS DONE, AND I WAS TOLD EVERYTHING WAS FINE ON THE TRUCK RE:BRAKES. I DROVE IT HOME, ABOUT 30 MILES AND NO PROBLEM. FIRST TIME I TRIED TO TAKE IT OUT ON A TRIP, THE REAR CALIPER LOCKED UP. CALLED NAMPA FREIGHTLINER, MULTIPLE TIMES, WHILE STOPPED ON SIDE OF ROAD. THEY ADVISED TO BLEED THE BRAKES, WHICH I DID. STARTED OFF AGAIN, REAR CALIPER LOCKED UP, PULLED TRUCK OVER AND FOUND FIRE IN THE REAR UNDERCHASSIS.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
Consequence & remedy
Consequence: THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.
Consequence & remedy
Consequence: A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.
DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.
Consequence & remedy
Consequence: CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Consequence & remedy
Consequence: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
CERTAIN 2004 AND 2005 THOMAS BUILT C2 SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2 HEAVY TRUCKS MANUFACTURED BETWEEN JUNE 2004 AND MARCH 2005. THE ANCHOR/PIVOT BOLT SUPPLIED WITH THE PARK BRAKE IS DEFECTIVE AND COULD FATIGUE FRACTURE PREMATURELY, RESULTING IN THE PARK BRAKE FAILING TO APPLY.
Consequence & remedy
Consequence: IF THE PARK BRAKE ANCHOR BOLT FATIGUES AND ULTIMATELY FRACTURES, THE PARK BRAKE MAY NOT FUNCTION AND THERE MAY BE NO INDICATION TO THE DRIVER OF THE MALFUNCTION WHEN THE PARK BRAKE IS SET. THIS MAY CAUSE THE VEHICLE TO ROLL AWAY WITHOUT WARNING, WHICH COULD RESULT IN A CRASH.
Remedy: FREIGHTLINER WILL NOTIFY ITS OWNERS AND INSPECT AND REPLACE DEFECTIVE ANCHOR BOLTS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
CERTAIN MY 2004 FREIGHTLINER BUSINESS CLASS M2 AND THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN JULY 26 AND OCTOBER 29, 2004, EQUIPPED WITH A CATERPILLAR C-7 ENGINE AND BORG-WARNER KYS 4735 35480 55 ENGINE FAN. THE FAN SHROUD MAY BE DRAWN BACK INTO THE FAN AT HIGH ENGINE SPEEDS WHEN THE FAN CLUTCH ENGAGES. DUE TO REDUCED CLEARANCE, HEAVY CONTACT BETWEEN THE FAN AND THE SHROUD MAY CAUSE THE FAN BLADE TO FRACTURE.
Consequence & remedy
Consequence: THE FAN MAY FRACTURE AND PIECES MAY SEPARATE FROM THE FAN BLADE. IN CERTAIN CONDITIONS, THIS MAY PRESENT A HAZARD TO PEOPLE NEAR THE VEHICLE WITH THE HOOD OPEN AND THE ENGINE RUNNING.
Remedy: FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ENGINE FAN WITH A FAN THAT HAS A DIFFERENT MOUNTING OFFSET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 16, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS AND FIRE TRUCKS EQUIPPED WITH KYS 4735-43782-02 ENGINE COOLING FANS AND BUILT ON CATERPILLAR 3126, C7, MBE906, MBE926, OR CUMMINS ISC ENGINES, THE STEEL FAN INSERT ON THE COOLING FANS CAN CRACK.
Consequence & remedy
Consequence: THIS CAN RESULT IN FAN BREAKAGE, RESULTING IN VEHICLE DAMAGE OR PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN FREE OF CHARGE. THE RECALL BEGAN ON JUNE 8, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS, INCORRECT SPRINGS WERE INSTALLED IN THE EXHAUST PORT OF CERTAIN AIR MANAGEMENT UNIT (AMU) SOLENOID VALVES AND THEY MAY NOT TURN OFF AFTER ACTUATION.
Consequence & remedy
Consequence: DEPENDING ON THE FUNCTION AFFECTED, THIS COULD RESULT IN REAR SUSPENSION AIR PRESSURE LOSS, MALFUNCTION OF THE ENGINE BRAKE, PERMANENT ENGAGEMENT OF THE REAR AXLE DIFFERENTIAL LOCK, OR PREVENT ENGAGEMENT OF THE FIFTH WHEEL SLIDE LOCK. IF THE WARNING INDICATORS IN THE DASH ARE NOT HEEDED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE AFFECTED VALVES. THE RECALL BEGAN JUNE 29, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.
Consequence & remedy
Consequence: IF SHIFT LEVER DETACHMENT OCCURS, THA ABILITY RO ACCELERATE OT MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-SECURE THE SHIFT LEVER TO THE TRANSMISSION USING THREADLOCK AND RE-TORQUING THE FASTENING BOLT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Additional source detail variants (3)
Suspension:front:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Suspension:front:wheel Bearing
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Wheels:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
2004 Freightliner Business Class M2 Problems, Complaints & Recalls | Skip That Year
Illustration