← New search

2003 Ford Windstar

Owner reports · Recalls · Investigations

More warning signs than most Windstar years

Owner complaints for the 2003 Ford Windstar are substantially higher than the model-year median of 192.

About this comparison →

When problems were reported

Mileage at the reported incident

1,283 reports with mileage · 227 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 296 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 282 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 280 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports27 fire reports28 injury reports

Power Train complaints

225 reports
Clear category filter
38,000 miles · Feb 29, 2008
Electrical SystemEngine And Engine CoolingLatches/locks/linkages

SINCE PURCHASE I HAVE HAD TO REPLACE TRANSMISSION, AIRCONDITIONER, AND THE ALTERNATOR--THIS HAS BEEN REPLACED 4 TIMES. THERE IS STILL AN ISSUE WITH THE INTERIOR LIGHTS COMING ON. THIS HAS BEEN REPORTED TO FORD AND THEY STATE THERE IS NO ISSUE ON THEIR PART. *TR

NHTSA ODI #10219648

Mileage unknown · Feb 11, 2008
Power Train

MY WIFE PULLED UP TO STOP AND WHEN THE LIGHT CHANGED SHE HAD NO GEARS FROM THE TRANSMISSION. NO WARNING SIGNS OR SOUNDS. WE HAD THE VAN TOED TO THE NEAREST DEALERSHIP( CHAMPION FORD) IT WAS DIAGNOSED AS A INTERNAL TRANSMISSION FAILURE. WE WERE TOLD IT WOULD BE 3,319.94 TO REPLACE THE TRANSMISSION AND FLUSH THE SYSTEM. IF WE WAN…

Read full complaint

MY WIFE PULLED UP TO STOP AND WHEN THE LIGHT CHANGED SHE HAD NO GEARS FROM THE TRANSMISSION. NO WARNING SIGNS OR SOUNDS. WE HAD THE VAN TOED TO THE NEAREST DEALERSHIP( CHAMPION FORD) IT WAS DIAGNOSED AS A INTERNAL TRANSMISSION FAILURE. WE WERE TOLD IT WOULD BE 3,319.94 TO REPLACE THE TRANSMISSION AND FLUSH THE SYSTEM. IF WE WANTED TO HAVE THE TRANSMISSION TAKEN APART TO FIND THE FAILURE WE WOULD HAVE TO PAY FOR THE TEAR DOWN AND IF IT STILL HAD TO BE REPLACED THEN THE REPLACEMENT COST WOULD BE ADDED. WHAT DO YOU DO? THE VAN ONLY HAS ABOUT 75K MILES ON IT. I AUTHORIZED THE REPLACEMENT. UPON TALKING WITH A PRIOR FORD MECHANIC (RETIRED NOW) I WAS TOLD THAT THIS IS AN ONGOING PROBLEM WITH THE WINDSTAR TRANSMISSION. AFTER DOING A LITTLE RESEARCH ON THE WEB I SEE THAT IT IS STILL A PROBLEM IN VANS NEWER AND WITH LOWER MILEAGE THAN MY OWN. THERE IS A PROBLEM HERE FORD. FIX IT! *TR

NHTSA ODI #10217736

Mileage unknown · Jan 14, 2008
Power TrainFire

WHILE DRIVING, THE VEHICLE STARTED TO LOOSE FORWARD SPEED. THEN TRANSMISSION FLUID BEGAN TO POUR OUT FROM THE TRANSAXLE, APPARENTLY CONTACTING THE CATALYTIC CONVERTER OR ENGINE MANIFOLD. THE LATEST CAUSED THE VEHICLE TO CATCH FIRE, RESULTING IN TOTAL A LOSS AND DAMAGE TO THIRD-PARTY PROPERTY. AT THE TIME OF EVENT THE VEHICLE WAS…

Read full complaint

WHILE DRIVING, THE VEHICLE STARTED TO LOOSE FORWARD SPEED. THEN TRANSMISSION FLUID BEGAN TO POUR OUT FROM THE TRANSAXLE, APPARENTLY CONTACTING THE CATALYTIC CONVERTER OR ENGINE MANIFOLD. THE LATEST CAUSED THE VEHICLE TO CATCH FIRE, RESULTING IN TOTAL A LOSS AND DAMAGE TO THIRD-PARTY PROPERTY. AT THE TIME OF EVENT THE VEHICLE WAS ONLY 4 YEARS OLD. THIS IS A SERIOUS DEFECT. *TR

NHTSA ODI #10214692

103,000 miles · Jan 13, 2008
Power Train

I AND MY WIFE WERE RETURNING HOME FROM A LONG TRIP TO SETTLE MY SON AT A REHABILITATION CENTER FOR KIDS WITH RETARDATION WHEN THE TRANSMISSION STOPPED WORKING WITHOUT ANY WARNING AT ALL. IT WAS RAINING AND A TORNADO WARNING WAS ISSUED FOR WHERE WE WERE. I HAD TO COAST TO A STOP ON THE SIDE OF THE ROAD WITHOUT MUCH AVAILABLE SPAC…

Read full complaint

I AND MY WIFE WERE RETURNING HOME FROM A LONG TRIP TO SETTLE MY SON AT A REHABILITATION CENTER FOR KIDS WITH RETARDATION WHEN THE TRANSMISSION STOPPED WORKING WITHOUT ANY WARNING AT ALL. IT WAS RAINING AND A TORNADO WARNING WAS ISSUED FOR WHERE WE WERE. I HAD TO COAST TO A STOP ON THE SIDE OF THE ROAD WITHOUT MUCH AVAILABLE SPACE TO CLEAR TRAFFIC. I THEN PROCEEDED TO WALK TO THE NEAREST HOUSE WHICH WAS ABOUT 1000 YRDS AWAY DUE TO THE FACT THIS HAPPENED IN A RURAL AREA AND WITH CONSIDERABLE RISK TO MYSELF APPROACH A HOME OF PEOPLE WHO DID NOT KNOW ME, DURING A PERIOD OF DARKNESS AND RAIN, AND ASK FOR HELP GETTING A TOW TRUCK. MEANWHILE MY WIFE AND BROTHER WERE BACK AT THE VAN WITH 18 WHEELERS WHIRRING BY DURING A SEVERE THUNDERSTORM. THE CHANCE OF A COLLISION DUE TO POOR VISIBILITY WAS MOST DEFINITELY A POSSIBILITY. WHEN THE TOW TRUCK ARRIVED HE HAD TO HOOKUP MY VAN IN POURING DOWN RAIN AND TOW THE VAN TO A SAFE PLACE UNTIL MORNING SO I COULD THEN HAVE IT TOWED HOME. AT THIS TIME I BELIEVE THE TRANSMISSION NEEDS TO BE REPLACED BUT I CANNOT AFFORD TO HAVE IT DONE. UPON RESEARCH ON THE INTERNET I DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE FORD WINSTAR. *TR

NHTSA ODI #10214632

42,468 miles · Dec 31, 2007
Power Train

2003 FORD WINDSTAR TRANSAXLE JERKS VEHICLE FROM 1ST TO 2ND GEAR SHIFT UNDER LIGHT OR MODERATE THROTTLE. WAS SERVICED 4 TIMES IN 2006 BY DEALER. DEALER REBUILT TRANSAXLE YET PROBLEM STILL EXISTED. DEALER REPLACED THROTTLE POSITION SENSOR 2ND TIME AND PROBLEM WAS EVEN MORE PRONOUNCED. NOW VEHICLE WOULD POP OUT OF 2ND GEAR WITH ENG…

Read full complaint

2003 FORD WINDSTAR TRANSAXLE JERKS VEHICLE FROM 1ST TO 2ND GEAR SHIFT UNDER LIGHT OR MODERATE THROTTLE. WAS SERVICED 4 TIMES IN 2006 BY DEALER. DEALER REBUILT TRANSAXLE YET PROBLEM STILL EXISTED. DEALER REPLACED THROTTLE POSITION SENSOR 2ND TIME AND PROBLEM WAS EVEN MORE PRONOUNCED. NOW VEHICLE WOULD POP OUT OF 2ND GEAR WITH ENGINE RACE IMMEDIATELY AFTER 1ST TO 2ND GEAR SHIFT BECAUSE IT HAMMERED THE SHIFT SO BAD. DEALER REPLACED STATOR SUPPORT ON 3RD TIME IN YET STILL POPS DURING SHIFT FROM 1ST TO 2ND. CALLED FORD CONSUMER LINE IMMEDIATELY AFTERWARD TO COMPLAIN. VEHICLE WAS COMING OUT OF WARRANTY IN 8K MILES AND I WANTED TO VOICE MY CONCERNS THAT THE TRANSMISSION WAS NOT WORKING PROPERLY AFTER BEING SERVICE 3 TIMES. FORD CALLED DEALER. DEALER CALLED ME TO EXPLAIN THAT THE FORD SERVICE REP TOLD THEM THAT THE WINDSTARS WILL SHIFT LIKE THAT AND THAT IS THE WAY IT IS. 14 MONTHS LATER TRANSMISSION IS FAILING WHEN UNDER ANY STRESS (HILLS, MODERATE ACCELERATION, ETC..) WITH A RATCHETING OR GRINDING NOISE. HAVE TO DISENGAGE OD ON HIGHWAY HILLS TO MAINTAIN SPEED WITH HEAVY TRAFFIC. HAVE CALLED FORD AGAIN. THEY WANT TO HAVE DEALER PERFORM A DIAGNOSTIC TEST WHICH I WILL HAVE TO PAY FOR. IT IS OUT OF WARRANTY NOW EVEN THOUGH I COMPLAINED TO FORD A YEAR AGO WHEN IT WAS IN. *TR

NHTSA ODI #10213297

99,824 miles · Dec 7, 2007
Power Train

TL*THE CONTACT OWNS A 2003 FORD WINDSTAR. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STOPPED ACCELERATING WITHOUT WARNING. THE CONTACT PULLED OFF THE ROAD AND SHUT OFF THE VEHICLE. THE VEHICLE WAS RESTARTED AND PLACED INTO GEAR, BUT IT WOULD NOT MOVE IN DRIVE OR REVERSE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP AND …

Read full complaint

TL*THE CONTACT OWNS A 2003 FORD WINDSTAR. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STOPPED ACCELERATING WITHOUT WARNING. THE CONTACT PULLED OFF THE ROAD AND SHUT OFF THE VEHICLE. THE VEHICLE WAS RESTARTED AND PLACED INTO GEAR, BUT IT WOULD NOT MOVE IN DRIVE OR REVERSE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP AND THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER HAS NOT YET BEEN NOTIFIED. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 99,824.

NHTSA ODI #10211111

53,000 miles · Oct 29, 2007
Power Train

2003 FORD WINDSTAR, 50,000 MILES, AND THE TRANSMISSION NEEDS TO BE REPLACED. EVEN THOUGH PROPER MAINTENANCE DONE. VEHICLE SHIFTS OUT OF GEAR, AND REVERSE IS NOT HIT OR MISS. SEARCH ON THE INTERNET REVEALS THIS VEHICLE IS WORTHLESS AND A REBUILD IS RECOMMENDED OVER A USED ONE SINCE YOUR ONLY GOING TO GET OTHER PEOPLES PROBLEMS. A…

Read full complaint

2003 FORD WINDSTAR, 50,000 MILES, AND THE TRANSMISSION NEEDS TO BE REPLACED. EVEN THOUGH PROPER MAINTENANCE DONE. VEHICLE SHIFTS OUT OF GEAR, AND REVERSE IS NOT HIT OR MISS. SEARCH ON THE INTERNET REVEALS THIS VEHICLE IS WORTHLESS AND A REBUILD IS RECOMMENDED OVER A USED ONE SINCE YOUR ONLY GOING TO GET OTHER PEOPLES PROBLEMS. A NEW TRANSMISSION FROM FORD IS 3000$ THE REBUILD WILL COST $2000. *TR

NHTSA ODI #10207315

71,894 miles · Jun 10, 2007
Power Train

DRIVING SOUTHBOUND ON I65 IN LEBABNON, IN ON WAY TO WORK AT ABOUT 65-70 MPH. SUDDENLY THE VANS TARTED TO SLOW EVEN THOUGH I WAS MAINTAIING PRESSURE ON GAS PEDAL. VAN CONTINUED TO SLOW WITH TRACTOR TRAILERS RACING UP BEHIND ME, SWERVING SORUND ME AND HRONS BLARING. I WAS BALE TO GET OFF AT THE NEXT EXIT AN MADE IT TO THE END OF T…

Read full complaint

DRIVING SOUTHBOUND ON I65 IN LEBABNON, IN ON WAY TO WORK AT ABOUT 65-70 MPH. SUDDENLY THE VANS TARTED TO SLOW EVEN THOUGH I WAS MAINTAIING PRESSURE ON GAS PEDAL. VAN CONTINUED TO SLOW WITH TRACTOR TRAILERS RACING UP BEHIND ME, SWERVING SORUND ME AND HRONS BLARING. I WAS BALE TO GET OFF AT THE NEXT EXIT AN MADE IT TO THE END OF THE RAMP WHERE THE VHEICLE JUST STOPPED MOVING.

NHTSA ODI #10192843

44,087 miles · Feb 21, 2007
Power Train

TL*-THE CONTACT OWNS A 2003 FORD WINSTAR. THE CONTACT'S FAMILY MEMBER AND PASSENGER WERE IN TEHE VEHICLE WHILE DRIVING THROUGH A TRAFFIC LIGHT WHEN THE VEHICLE STOPPED MOVING FORWARD, BUT THE ENGINE CONTINUED TO OPERATE. THE VEHICLE WAS TOWED. THE MECHANIC REPLACED THE TORQUE CONVERTER. THERE WERE NO PREVIOUS FAILURES OR WARN…

Read full complaint

TL*-THE CONTACT OWNS A 2003 FORD WINSTAR. THE CONTACT'S FAMILY MEMBER AND PASSENGER WERE IN TEHE VEHICLE WHILE DRIVING THROUGH A TRAFFIC LIGHT WHEN THE VEHICLE STOPPED MOVING FORWARD, BUT THE ENGINE CONTINUED TO OPERATE. THE VEHICLE WAS TOWED. THE MECHANIC REPLACED THE TORQUE CONVERTER. THERE WERE NO PREVIOUS FAILURES OR WARNING LIGHT INDICATORS. THE CURRENT MILEAGE WAS 44,000, AND THE FAILURE MILEAGE WAS 44,087. *AK

NHTSA ODI #10183200

47,652 miles · Jan 30, 2007
Power Train

I STARTED THE VAN AND LEFT THE DRIVER'S DOOR OPEN TO RUN INSIDE THE HOUSE TO GET SOMETHING. WHEN I CAME BACK THE VAN WAS ROLLING BACKWARD ACROSS THE NEIGHBOR'S YARD. BECAUSE THE DOOR WAS OPEN IT WAS RIPPED BACKWARD AS IT LEFT THE GARAGE AND HIT THE SIDE OF THE GARAGE DOOR. IT HAD ROLLED OFF A RETAINING WALL WHICH PULLED THE FRON…

Read full complaint

I STARTED THE VAN AND LEFT THE DRIVER'S DOOR OPEN TO RUN INSIDE THE HOUSE TO GET SOMETHING. WHEN I CAME BACK THE VAN WAS ROLLING BACKWARD ACROSS THE NEIGHBOR'S YARD. BECAUSE THE DOOR WAS OPEN IT WAS RIPPED BACKWARD AS IT LEFT THE GARAGE AND HIT THE SIDE OF THE GARAGE DOOR. IT HAD ROLLED OFF A RETAINING WALL WHICH PULLED THE FRONT BUMPER OFF. IT WAS STILL ROLLING ACROSS THE NEIGHBOR'S YARD WHEN WE FINALLY CAUGHT IT. WHEN I GOT IN THE VAN IT WAS STILL IN PARK. THANKFULLY NO ONE WAS HURT. *JB

NHTSA ODI #10181081

Official recalls

8

15V608000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

Sep 29, 2015

Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.

Consequence & remedy

Consequence: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.

12V193000 · Power Train:axle Assembly

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence & remedy

Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

12V194000 · Suspension:front:control Arm

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.

Consequence & remedy

Consequence: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

12V195000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.

Consequence & remedy

Consequence: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

11V030000 · Structure:frame And Members:underbody Shields

Jan 26, 2011

FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.

Consequence & remedy

Consequence: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

10V385000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

Aug 26, 2010

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence & remedy

Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

09V399000 · Vehicle Speed Control

Oct 13, 2009

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence & remedy

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

03V459000 · Seats:mid/rear Assembly

Nov 6, 2003

CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." DURING TESTING, A THIRD ROW BENCH FLOOR-TO-SEAT LATCH RELEASED BEFORE THE STRENGTH REQUIREMENT WAS MET. IDENTICAL LATCHES ARE USED IN THE SECOND ROW OF SEATS.

Consequence & remedy

Consequence: IF THE LATCHES ON TH4E SECOND OR THIRD ROW SEATS OF THE VEHICLE RELEASE IN A CRASH, THE POTENTIAL FOR OCCUPANT INJURY IS INCREASED.

Remedy: DEALERS WILL REPLACE THE SEAT-TO-FLOOR LATCHES ON THE SECOND AND THIRD ROW OF SEATS. OWNER NOTIFICATION BEGAN ON NOVEMBER 21, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

6

EA10007 · Front Subframe Corrosion Failures

Opened Dec 20, 2010 · Closed Mar 17, 2011

Status: closed (inferred from source dates) · Structure:frame And Members; Suspension

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

Additional source detail variants (2)

Structure:frame And Members

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

Suspension

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

DP10005 · Rear Axle Fracture Recall Scope

Opened Dec 15, 2010 · Closed Dec 21, 2010

Status: closed (inferred from source dates) · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

On November 5, 2010, NHTSA received a Defect Petition from the owner of a MY 2003 Ford Windstar vehicle registered in the state of New York requesting that the scope of Recall 10V-385 be expanded to include additional MY 2003 vehicles experiencing the defect condition.The petitioner initially filed a complaint (VOQ 10345125) with ODI on July 25, 2010, two days after the axle failure.The complaint was subsequently amended and the petition filed after the consumer was denied compensation and repair under the recall.ODI has identified a total of five complaints from owners of MY 2003 Ford Windstar vehicles in Salt Belt states that were built after February 28, 2003, Ford's original cutoff date for 10V-385.On November 30, 2010, Ford submitted a letter supplementing recall 10V-385 (Ford 10S13) to add certain vehicles to the program.Ford's analysis of parts and information from the field showed: 1) that the revised heat treated axle introduced in production on February 28, 2003, may still have the potential for cracks due to corrosion related stress; and 2) that vehicles operated in Utah may be exposed to the same combination of environmental factors that can make them susceptible to cracks from stress related corrosion.Based on this analysis, Ford expanded the scope of 10V-385 to include MY 2003 vehicles built after February 28, 2003 and sold or currently registered in Salt Belt states and MY 1998 through 2003 vehicles sold or currently registered in Utah.Ford estimated that approximately 29,900 vehicles in the expanded scope may currently remain in service.Based on the above amended defect report submission, the petition has become moot and is therefore denied.

PE10026 · Front Subframe Corrosion Failures

Opened Jul 20, 2010 · Closed Dec 20, 2010

Status: closed (inferred from source dates) · Structure:frame And Members; Suspension

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

Additional source detail variants (2)

Structure:frame And Members

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

Suspension

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

PE10016 · Rear Axle Cracking

Opened May 13, 2010 · Closed Sep 22, 2010

Status: closed (inferred from source dates) · Suspension

In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly manufactured by Benteler automotive Corporation of Galesburg, MI.According to Ford, after many years of vehicle service in the Salt-Belt states, corrosion can weaken the rear axle, making it susceptible to torsional stress.There is a risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle.A completely fractured axle can affect vehicle handling and increase the risk of a crash.To correct the safety defect, Ford will initially inspect all of the subject vehicles brought into Ford/Lincoln-Mercury dealerships for possible cracked axles.Owners of vehicles without cracked axles will be notified when to return for the installation of reinforcement brackets to extend the axle durability in the presence of corrosion.Owners who have vehicles with cracked axles will either be offered a repair or alternative transportation until parts become available. On May 13, 2010, the Office of Defects Investigation (ODI) opened PE10-016 to investigate complaints of rear axle cracking in MY 1999 through 2003 Ford Windstar minivans.Combining ODI and Ford complaint data, ODI is aware of a total 891 complaints alleging rear axle cracking in the subject vehicles.Over a third of the complaints (334) allege that the cracking progressed to a complete fracture of the rear axle, including 8 allegations of crashes resulting in 3 injuries. Approximately 57 percent of the subject vehicles (524,661) were sold in Salt-Belt states covered by Ford's recall and Ford estimates that approximately 463,000 of these remain in service.Ninety-six percent of the complaints (858) and all of the complaints alleging complete fracture were from the recall region.The action taken by Ford is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.

EA08021 · Engine Compartment Fires

Opened Sep 17, 2008 · Closed Oct 14, 2009

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Additional source detail variants (7)

Electrical System

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Electrical System:wiring

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Vehicle Speed Control:cruise Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Vehicle Speed Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

PE08035 · Engine Compartment Fires

Opened May 13, 2008 · Closed Sep 17, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Additional source detail variants (3)

Electrical System

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Electrical System:wiring

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Vehicle Speed Control

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.