NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
278 reportsClear category filter80,000 miles · Sep 21, 2007
Electrical SystemExterior LightingInterior Lighting
FIRST: WHILE TRAVELING 70 MPH ON AN INTERSTATE IN NC OUR VAN DIED. AFTER SAFELY PULLING OVER, CROSSING 3 LANES OF TRAFFIC, WE HAD THE VAN TOWED HOME TO VA AND THE MECHANIC SAID HE CHANGES 7-8 TRANSMISSIONS A WEEK IN FORD WINDSTAR VANS. WE HAD FALLEN VICTIM TO THIS. WE STILL HAVE PROBLEMS WITH THE O/D LIGHT COMING ON AND HAVING T…
Read full complaint
FIRST: WHILE TRAVELING 70 MPH ON AN INTERSTATE IN NC OUR VAN DIED. AFTER SAFELY PULLING OVER, CROSSING 3 LANES OF TRAFFIC, WE HAD THE VAN TOWED HOME TO VA AND THE MECHANIC SAID HE CHANGES 7-8 TRANSMISSIONS A WEEK IN FORD WINDSTAR VANS. WE HAD FALLEN VICTIM TO THIS. WE STILL HAVE PROBLEMS WITH THE O/D LIGHT COMING ON AND HAVING TO ADD TRANSMISSION FLUID FREQUENTLY. SECOND: OUR VAN INTERIOR AND EXTERIOR LIGHTS DIM AND BLINK AT RANDOM. THE ALERT WILL ALSO COME ON SAYING ONE OF THE DOORS IS AJAR LEAVING THE INTERIOR LIGHTS ON AND DOORS UNLOCKED. IT WILL RANDOMLY CHANGE DOORS WHILE DRIVING. NOW THE REAR TURNING LIGHTS DO NOT FLASH, THE LOCKS DO NOT WORK, THE INTERIOR AND BACK EXTERIOR LIGHTS DO NOT GO OUT EVEN WITH THE KEY OFF AND OUT. THERE WILL BE RANDOM BEEPING AND BUZZING NOISES. THE REAR HEAT/AIR TURNS OFF AND ON AT RANDOM EVEN WITH THE CONTROLS IN THE OFF POSITION. THERE IS A CLICKING UNDER THE DASH WHEN THE REAR HEAT OR AIR IS RUNNING. ON INSPECTION THE MECHANIC FOUND THE ALARM WIRES UNDER THE DASH BARE, UNHOOKED, AND EXPOSED. HE TAPED THESE HOPING IT WOULD SOLVE THE PROBLEM. IT HAS NOT. THE LOCAL FORD DEALER IS NOT REPUTABLE. IT IS A WELL KNOWN FACT IN THE COMMUNITY THAT THEY BREAK SOMETHING ELSE WHILE FIXING ANOTHER TO ENSURE A RETURN VISIT. WE HAVE TO TRAVEL 45-60 MINUTES TO ANOTHER DEALER AND THEY ARE SO BUSY BECAUSE THEY HAVE TO PROVIDE SERVICE FOR A LARGE RURAL AREA. FORD HAS NEVER ACKNOWLEDGED PHONE CALLS OR LETTERS SENT TO THEM. WE FEEL STUCK WITH A LEMON! *TR
NHTSA ODI #10203621
12,900 miles · Sep 8, 2007
Electrical SystemEngine And Engine CoolingPower Train
I WAS AT A STOP LIGHT AT A MAJOR INTERSECTION AND WHEN THE LIGHT TURNED GREEN I HEARD A LOUD SOUND. I TRIED TO ACCELERATE BUT MY CAR WOULD NOT MOVE FORWARD. THE ENGINE JUST REVVED. I THOUGHT I RAN SOMETHING OVER DUE TO THE SOUND SO INSPECTED GOT OUT TO INSPECT THE CAR. I FOUND NOTHING. I GOT BACK INTO THE CAR AND TURNED CAR…
Read full complaint
I WAS AT A STOP LIGHT AT A MAJOR INTERSECTION AND WHEN THE LIGHT TURNED GREEN I HEARD A LOUD SOUND. I TRIED TO ACCELERATE BUT MY CAR WOULD NOT MOVE FORWARD. THE ENGINE JUST REVVED. I THOUGHT I RAN SOMETHING OVER DUE TO THE SOUND SO INSPECTED GOT OUT TO INSPECT THE CAR. I FOUND NOTHING. I GOT BACK INTO THE CAR AND TURNED CAR OFF AND TURNED BACK. THE CAR WOULD NOT DRIVE. I PUT THE CAR IN REVERSE AND MANAGED TO GET OFF THE ROAD. I HAD THE CAR TOWED TO THE DEALERSHIP. I WAS TOLD BY THE DEALER SUTTON FORD IN MATTESON IL. THAT THE TRANSMISSION JUST BROKE AND WOULD COST ME $3000.00. I HAVE HAD THIS CAR LESS THEN 2 YEARS. I HAD AN EXTENDED WARRANTY THAT JUST EXPIRED A FEW MONTHS AGO. MY OBD LIGHT WAS ON BUT WAS TOLD BY THE DEALER IT WAS A SENSOR. THEY COULD TURN IT OFF BUT IT WASN'T ANYTHING MAJOR. AFTER READING ALL THE COMPLAINTS I'M SURE IT IS MAJOR. SINCE PURCHASING THIS CAR, I HAVE HAD TO REPLACE TIRES AT LEAST EVERY SIX MONTHS, MAJOR ENGINE REPAIR, ALTERNATOR REPAIR, AS WELL AS SPRING REPLACEMENT. OVERALL, I'VE PUT MORE THEN $3000.00 IN REPAIR NOT INCLUDING THE REPAIR OF THE TRANSMISSION I NOW NEED. I LOVED MY WINDSTAR BUT I AM NOW DISCOVERING THAT IT PUTS MY LIFE ENDANGER TO DRIVE IT. MY TWO KIDS WERE IN THE CAR WHEN THIS HAPPENED AND I FEARED SOMEONE WOULD HIT MY CAR. THE WORST PART ABOUT ALL THIS IS I AM UNABLE TO GET RID OF THIS CAR AS I STILL AM BUYING THIS CAR. I AM UNABLE TO REFINANCE THE DIFFERENCE. I WAS TOLD TO JUST SCARP THE CAR BY THE DEALER AND JUST GET ANOTHER CAR AS I AM EVEN MORE IN DEBT TRYING TO REPAIR THE CAR. I DON'T WANT TO RUIN MY CREDIT SO THERE HAS TO BE ANOTHER SOLUTION. I HAVE NO INKLING HOW I'M GOING TO MANAGE TO GET 3000.00 FOR A NEW CAR AND PAY MY BILLS AND FIND AN ALTERNATIVE METHOD. I REALLY WOULD APPRECIATE IT IF FORD WOULD JUST DO THE RIGHT THING FIX MY TRANSMISSION. SPLIT THE COST. I DID DAMAGE MY CAR IN THE MIST OF ALL THIS AND JUST WANT TO BE ABLE TO DRIVE TO WORK UNTIL THE CAR IS PAID OFF.*JB
NHTSA ODI #10202275
87,032 miles · Jun 14, 2007
Power Train
THE REAR AXLE BEAM ON A1999 FORD WINDSTAR (87,032 MILES) CRACKED AND SNAPPED INTO, CAUSING BOTH WHEELS TO PITCH THE BOTTOM OF WHEELS OUTWARD RESULTING IN UNSTABLE VEHICLE CONTROL (AT HIGHWAY SPEEDS COULD CAUSE AN ACCIDENT). ATER INSPECTION OF FAILED PARTS, I BELIEVE FORD HAS A MANUFACTURING PROCESS THAT CREATES STRESS RISERS IN …
Read full complaint
THE REAR AXLE BEAM ON A1999 FORD WINDSTAR (87,032 MILES) CRACKED AND SNAPPED INTO, CAUSING BOTH WHEELS TO PITCH THE BOTTOM OF WHEELS OUTWARD RESULTING IN UNSTABLE VEHICLE CONTROL (AT HIGHWAY SPEEDS COULD CAUSE AN ACCIDENT). ATER INSPECTION OF FAILED PARTS, I BELIEVE FORD HAS A MANUFACTURING PROCESS THAT CREATES STRESS RISERS IN THE PART THAT LEAD TO PREMATURE FAILURE. I HAVE THE PARTS AND CAN EMAIL A PPD FILE THAT SHOWS THE FAILURE SURFACES. THE DEALERSHIP TALKED TO FORD CUSTOMER RELATIONS AND DID PAY FOR HALF OF THE REPAIR. FORD CUSTOMER RELATIONS DO NOT WANT TO PUT ME IN CONTACT WITH THEIR ENGINEERING DEPARTMENT TO DISCUSS THIS ISSUE. I CONDUCT FAILURE ANALYSIS FOR A FORTUNE 100 COMPANY AND HAVE CONCERNS WITH THE SAFETY OF THIS PRODUCT. THE REPLACE PART IS MANUFATURED EXACTLY LIKE THE ORIGINAL FAILED PART.I DID FIND A REPORT ON THE INTERNET THAT DESCRIBES AN ACCIDENT CAUSED BY THE SAME FAILURE. *TR
NHTSA ODI #10193320
103,000 miles · Jun 5, 2007
Power Train
MY TRANSMISSION ON A 1999 FORD WINDSTAR IS LEAKING FROM THE BELL HOUSING ON THE TRANSMISSION, AS WELL AS SLIPPING THROUGH THE GEARS, THIS IS THE SECOND TIME IT HAS HAPPENED WITHIN 50,000 MILES. I HAVE ALSO NOTICED THAT FROM WHERE IT IS LEAKING FROM THE TRANSMISSION, MY CATALYTIC CONVERTERS AFFECTED BY THE FLUID THAT IS ON IT AS …
Read full complaint
MY TRANSMISSION ON A 1999 FORD WINDSTAR IS LEAKING FROM THE BELL HOUSING ON THE TRANSMISSION, AS WELL AS SLIPPING THROUGH THE GEARS, THIS IS THE SECOND TIME IT HAS HAPPENED WITHIN 50,000 MILES. I HAVE ALSO NOTICED THAT FROM WHERE IT IS LEAKING FROM THE TRANSMISSION, MY CATALYTIC CONVERTERS AFFECTED BY THE FLUID THAT IS ON IT AS WELL, CONSISTENTLY BURNING OFF AS IT GETS HOTTER. *TR
NHTSA ODI #10192449
Mileage unknown · Jun 1, 2007
Parking BrakePower Train
THE VEHICLE WHEN PARKED AT ANY DEGREE OF INCLINE OR DECLINE HAS HAD REPEATED TENDENCIES NOT TO SHIFT OUT OF PARK. ON THIS OCCASION, I HAD THE VEHICLE ON RAMPS CHANGING MY OIL AND WENT TO PUT IT IN NEUTRAL TO LEVEL IT OUT. THE VEHICLE APPEARED TO HAVE GOTTEN STUCK IN REVERSE AND NEITHER THE FOOT BRAKE NOR THE EMERGENCY BRAKE WOUL…
Read full complaint
THE VEHICLE WHEN PARKED AT ANY DEGREE OF INCLINE OR DECLINE HAS HAD REPEATED TENDENCIES NOT TO SHIFT OUT OF PARK. ON THIS OCCASION, I HAD THE VEHICLE ON RAMPS CHANGING MY OIL AND WENT TO PUT IT IN NEUTRAL TO LEVEL IT OUT. THE VEHICLE APPEARED TO HAVE GOTTEN STUCK IN REVERSE AND NEITHER THE FOOT BRAKE NOR THE EMERGENCY BRAKE WOULD STOP IT. IT WOULD NOT LET ME SHIFT INTO ANY OF GEAR UNTIL IT REACHED LEVEL GROUND. I HAD AN APPOINTMENT WITH THE DEALER TO LOOK AT THE TRANSMISSION ON MAY 31, 2007 BECAUSE I HAD BEEN HAVING TROUBLE WITH THE TRANSMISSION SHIFTING VERY ROUGH AND FEELING A JERKING SENSATION WHEN I SHIFTED FROM PARK TO EITHER DRIVE OR REVERSE. *TR
NHTSA ODI #10192265
Mileage unknown · Apr 17, 2007
Power Train
FOR THE SECOND TIME IN 2 YEARS I AM REPLACING THE TRANSMISSION ON THE 1999 WINDSTAR. BOTH TIMES IT JUST STOPPED WORKING,, BUT WAS ABLE TO GET CAR TO SAFETY. NOW ON SECOND TRANSMISSION OVERHAUL AT A COST OF $1700 FOR HE FIRST TIME , AND 1$400 THE SECOND. THE MECHANIC SAID THERE WAS NO REASON FOR THE FAILURE.*AK
NHTSA ODI #10188136
28,000 miles · Apr 4, 2007
Power Train
ONLY 28,000 MILES ON CAR DRIVEN BY ELDERLY FATHER A FEW MILES EVERY DAY FOR PAST 7 YEARS. NO INDICATION OF PROBLEM WITH TRANSMISSION BEFORE THIS INCIDENT. PULLED FROM STOP ONTO STATE ROAD AT POINT WHERE A BLIND CURVE/NO SITE DISTANCE FOR ONCOMING TRAFFIC-SPEED LIMIT 45 MPH. CAR JERKED FORWARD AND TRANSMISSION FAILED, NO FORWARD…
Read full complaint
ONLY 28,000 MILES ON CAR DRIVEN BY ELDERLY FATHER A FEW MILES EVERY DAY FOR PAST 7 YEARS. NO INDICATION OF PROBLEM WITH TRANSMISSION BEFORE THIS INCIDENT. PULLED FROM STOP ONTO STATE ROAD AT POINT WHERE A BLIND CURVE/NO SITE DISTANCE FOR ONCOMING TRAFFIC-SPEED LIMIT 45 MPH. CAR JERKED FORWARD AND TRANSMISSION FAILED, NO FORWARD GEARS, LEAVING CAR SIDEWAYS ACROSS 2 LANES OF ONCOMING TRAFFIC. GOT CAR TO GO IN REVERSE TO GET OFF ROAD WHICH CREATED AN EVEN MORE DANGEROUS SITUATION FOR ME AND ALL ONCOMING TRAFFIC. TOLD WILL COST $2,500 FOR RE-BUILT TRANSMISSION. FORD SENT STANDARD REPLY TO MY COMPLAINT SUGGESTING GO TO DEALERSHIP AND HAVE CHECKED OUT. AMAZING THAT NO RECALL HAS BEEN ISSUED OR ANYTHING BEEN DONE AFTER SEEING THIS AND NUMEROUS WEBSITES WITH SAME COMPLAINTS. SO MANY OF US LUCKY. HOW MANY DEATHS DOES IT TAKE BEFORE ACTION WILL BE TAKEN? HAVE BEEN A FORD OWNER FOR YEARS AND WILL NEVER, EVER BUY FORD AGAIN. *AK
NHTSA ODI #10186968
97,000 miles · Oct 27, 2006
Power Train
1999 WINDSTAR ,98K, COMPLETE TRANSMISSION FAILURE. WENT INTO REVERSE , BUT NOT INTO ANY FORWARD GEAR. I'VE METICULOUSLY MAINTAINED THIS VEHICLE, NEVER TOWED. HAVE OWNED CARS FOR 30 YRS, NEVER HAD A VEHICLE THIS BAD. WILL NEVER BUY FORD AGAIN. *NM
NHTSA ODI #10171997
83,000 miles · Oct 16, 2006
Power Train
TRANSMISSION SLIPPAGE RESULTING IN LOSS OF DRIVE POWER/TORQUE AS A RESULT OF A MANUFACTURING DEFECT. *NM
NHTSA ODI #10170958
75,567 miles · Aug 27, 2006
Power Train
1999 FORD WINDSTAR SUSTAINED MAJOR TRANSMISSION FAILURE WITHOUT ANY PRIOR SYMPTOMS. VEHICLE WAS PARKED IN DRIVEWAY AND SHIFTED INTO DRIVE, A LOUD NOISE WAS HEARD FOLLOWED BY SEVERE GRINDING. TRANSMISSION WAS FOUND TO BE FILLED WITH METAL AND REQUIRED OVERHAUL. VEHICLE HAD JUST OVER 75000 MILES AND HAS NEVER BEEN USED FOR TOWING…
Read full complaint
1999 FORD WINDSTAR SUSTAINED MAJOR TRANSMISSION FAILURE WITHOUT ANY PRIOR SYMPTOMS. VEHICLE WAS PARKED IN DRIVEWAY AND SHIFTED INTO DRIVE, A LOUD NOISE WAS HEARD FOLLOWED BY SEVERE GRINDING. TRANSMISSION WAS FOUND TO BE FILLED WITH METAL AND REQUIRED OVERHAUL. VEHICLE HAD JUST OVER 75000 MILES AND HAS NEVER BEEN USED FOR TOWING. REPAIR COSTS WERE OVER 2000 DOLLARS. *JB
NHTSA ODI #10166667
Official recalls
11Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.
Consequence & remedy
Consequence: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.
Consequence & remedy
Consequence: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.
Consequence & remedy
Consequence: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jan 26, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Aug 26, 2010
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 15, 2001
VEHICLE DESCRIPTION: MINI VANS. CONTAMINANTS SUCH AS WATER, SALT, AND WINDSHIELD WASHER SOLUTION CAN ENTER THE WIPER MOTOR COVER ASSEMBLY THROUGH PINHOLES ON THE EXTERIOR OF THE COVER THAT ARE USED IN THE MOLDING PROCESS. IN ADDITION, ON CERTAIN OF THE VEHICLES BUILT BETWEEN FEBRUARY AND AUGUST 2000, A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT. EITHER OF THESE CONDITIONS COULD POTENTIALLY RESULT IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, SMOKE, OR IGNITION OF THE PLASTIC COVER MATERIAL. CONTAMINANT ENTRY COULD ALSO RESULT IN UNINTENDED WIPER MOTOR OPERATION.
Consequence & remedy
Consequence: SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER COVER WITH IMPROVED SEALING AND WATER RESISTANCE. OWNER NOTIFICATION BEGAIN AUGUST 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 15, 2001
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH AUXILIARY REAR AIR-CONDITIONING. IF THE AUXILIARY AIR-CONDITIONING BLOWER MOTOR STOPS TURNING WHILE IN THE MEDIUM-LOW BLOWER SPEED SETTING, THERE IS THE POTENTIAL THAT THE RESISTOR MAY BECOME HOT AND SMOKE.
Consequence & remedy
Consequence: THE MOTOR COULD POTENTIALLY CATCH ON FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER WIRE THAT WILL ENSURE THAT THE MEDIUM-LOW BLOWER SPEED SETTING IS PROTECTED BY THE THERMAL LIMITER. OWNER NOTIFICATION BEGAN AUGSUT 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Oct 30, 2000
VEHICLE DESCRIPTION: MINIVANS BUILT WITH INSTRUMENT CLUSTERS WITHOUT THE MESSAGE CENTER, FAIL TO COMPLY WITH THE REQUIREMENTS OF STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT DOORS ARE OPENED.
Consequence & remedy
Consequence: THE STANDARD REQUIRES THAT POWER OPERATED WINDOWS MAY BE CLOSED ONLY WHEN THE KEY IS IN THE "ON," "START," OR "ACCESSORY" POSITIONS, OR DURING THE INTERVAL BETWEEN THE TIME THE KEY IS TURNED OFF, AND THE OPENING OF EITHER OF THE VEHICLE'S FRONT DOORS.
Remedy: DEALERS WILL RECONFIGURE THE VEHICLE FRONT END ELECTRONIC MODULE.
Jun 14, 1999
VEHICLE DESCRIPTION: MINIVANS. THE BRAKE FLUID MASTER CYLINDER IS RECESSED AND ORIENTED IN THE ENGINE COMPARTMENT SO THAT THE BRAKE FLUID WARNING STATEMENT EMBOSSED ON BOTH THE TOP OF THE FILLER CAP AND THE SIDE OF THE RESERVOIR BODY ARE NOT ENTIRELY VISIBLE BY DIRECT VIEW. THESE VEHICLES MAY NOT FULLY COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE PROVIDED WITH NEW LABELS AND INSTALLATION INSTRUCTIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA10007 · Front Subframe Corrosion Failures
Opened Dec 20, 2010 · Closed Mar 17, 2011
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Additional source detail variants (2)
Structure:frame And Members
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
PE10026 · Front Subframe Corrosion Failures
Opened Jul 20, 2010 · Closed Dec 20, 2010
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Additional source detail variants (2)
Structure:frame And Members
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
PE10016 · Rear Axle Cracking
Opened May 13, 2010 · Closed Sep 22, 2010
Status: closed (inferred from source dates) · Suspension
In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly manufactured by Benteler automotive Corporation of Galesburg, MI.According to Ford, after many years of vehicle service in the Salt-Belt states, corrosion can weaken the rear axle, making it susceptible to torsional stress.There is a risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle.A completely fractured axle can affect vehicle handling and increase the risk of a crash.To correct the safety defect, Ford will initially inspect all of the subject vehicles brought into Ford/Lincoln-Mercury dealerships for possible cracked axles.Owners of vehicles without cracked axles will be notified when to return for the installation of reinforcement brackets to extend the axle durability in the presence of corrosion.Owners who have vehicles with cracked axles will either be offered a repair or alternative transportation until parts become available. On May 13, 2010, the Office of Defects Investigation (ODI) opened PE10-016 to investigate complaints of rear axle cracking in MY 1999 through 2003 Ford Windstar minivans.Combining ODI and Ford complaint data, ODI is aware of a total 891 complaints alleging rear axle cracking in the subject vehicles.Over a third of the complaints (334) allege that the cracking progressed to a complete fracture of the rear axle, including 8 allegations of crashes resulting in 3 injuries. Approximately 57 percent of the subject vehicles (524,661) were sold in Salt-Belt states covered by Ford's recall and Ford estimates that approximately 463,000 of these remain in service.Ninety-six percent of the complaints (858) and all of the complaints alleging complete fracture were from the recall region.The action taken by Ford is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
EA08021 · Engine Compartment Fires
Opened Sep 17, 2008 · Closed Oct 14, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Additional source detail variants (7)
Electrical System
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Electrical System:wiring
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE08035 · Engine Compartment Fires
Opened May 13, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Electrical System:wiring
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
PE04022 · Power Sliding Door Opening
Opened Mar 3, 2004 · Closed Jul 1, 2004
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Structure:body:door
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03004 · Wheel Stud Fracture
Opened Apr 10, 2003 · Closed Aug 30, 2004
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Wheels
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02085 · Wheel Stud Fracture
Opened Nov 18, 2002 · Closed Apr 10, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Additional source detail variants (2)
Wheels
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Wheels:lugs/nuts/bolts/studs
ANALYSIS OF ODI AND FORD DATA HAS IDENTIFIED 1619 INCIDENTS OF WHEEL STUD FRACTURE IN MY 1998 THROUGH 2000 FORD WINDSTAR VEHICLES, INCLUDING 69 WHEEL SEPARATIONS AND 11 CRASHES.FORD HAS NOT BEEN ABLE TO IDENTIFY ANY DESIGN OR MANUFACTURING DEFECTS IN ITS ANALYZIS OF THE PROBLEM.FORD MAINTAINS THAT THE FAILURES ARE CAUSED BY EITHER:(1) INADVERTENT OVERTORQUING OF LUG NUTS DURING REMOVAL OR INSTALLATION; OR (2) FATIGUE DUE TO INSUFFICIENT CLAMP LOAD BETWEEN THE WHEEL AND THE BRAKE ROTOR OR DRUM AND HUB ASSEMBLY.ACCORDING TO FORD, CORROSION, DIRT, OR DAMAGE PRESENT ON THE ROAD WHEEL AT THE NUT INTEFACE COULD CONTRIBUTE TO THE LATTER CONDITION. ANALYSIS OF ODI COMPLAINT DATA INDICATES THAT THE SUBJECT VEHICLES EXPERIENCE WHEEL STUD FAILURES AT SIGNIFICANTLY HIGHER RATES THAN PEER MINIVANS.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER ASSESS THE FREQUENCY, SCOPE, AND TREND OF THE ALLEGED DEFECT CONDITION IN MY 1997 THROUGH 2000 WINDSTAR MINIVANS.
Illustration