NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
43 reportsClear category filterMileage unknown · Sep 20, 1999
Power Train
I NOTICED THAT MY SPEEDOMETER WAS BEHAVING ERRATICALLY AT ABOUT 41000 MILES. I CONTACTED THE DEALER WHO SAID THAT IT WOULD HAVE TO BE REPLACED AT A COST OF $250 IF I WANTED IT FIXED. I SAID THAT I DIDN'T BELIEVE THE SPEEDOMETER SHOULD FAIL AT THAT LOW MILEAGE. THE MANUFACTURER CONTACTED ME ABOUT THIS AND SAID THERE WAS NOTHIN…
Read full complaint
I NOTICED THAT MY SPEEDOMETER WAS BEHAVING ERRATICALLY AT ABOUT 41000 MILES. I CONTACTED THE DEALER WHO SAID THAT IT WOULD HAVE TO BE REPLACED AT A COST OF $250 IF I WANTED IT FIXED. I SAID THAT I DIDN'T BELIEVE THE SPEEDOMETER SHOULD FAIL AT THAT LOW MILEAGE. THE MANUFACTURER CONTACTED ME ABOUT THIS AND SAID THERE WAS NOTHING THEY COULD DO (FINANCIALLY) TO HELP WITH THE REPLACEMENT. AT ABOUT 50000 MILES I WAS INFORMED THAT THE RIGHT TIE ROD END WAS WORN AND ADVISED IT SHOULD BE REPLACED. AGAIN, I PROTESTED BECAUSE OF THE LOW MILEAGE. I FINALLY HAD THE REPLACEMENT DONE FOR SAFETY REASONS AT MY EXPENSE. I WAS ALSO TOLD THAT THE RIGHT WHEEL BEARING WAS OUT OF TOLERANCE AT A MILEAGE OF APPROX. 40000 MILES. NONE OF THESE DEFECTS WERE MENTIONED AT THE PRE-36000 MILE SERVICING I HAD DONE OF THE VEHICLE. I AM VERY DISSATISFIED WITH THE DURABILITY OF THE VEHICLE, AND WILL PROBABABLY NOT PURCHASE ANOTHER FORD VEHICLE AGAIN. FORD HAS NOT BEEN HELPFUL IN HELPING WITH THE REPAIR COSTS ON THE VEHICLE AT THIS RELATIVELY LOW MILEAGE.
NHTSA ODI #711667
Mileage unknown · Aug 23, 1999
Power Train
MY VAN HAS BEEN PUTTING ITSELF INTO NEUTRAL WHEN I AM AT A STOP OR PULLING OUT OF A STOP. WHEN I HAVE WENT TO THE DEALERS IN DELEWARE (ON VACATION), PA. (ON VACATION) AND MY LOCAL DEALER, NO ONE CAN FIND A PROBLEM.NOW ALL OF A SUDDEN MY DEALER IN ROANOKE RAPIDS ,N.C. SAID HE WOULD RREPLACE SOME TRANSMISSION PARTS BUT I DO NOT KN…
Read full complaint
MY VAN HAS BEEN PUTTING ITSELF INTO NEUTRAL WHEN I AM AT A STOP OR PULLING OUT OF A STOP. WHEN I HAVE WENT TO THE DEALERS IN DELEWARE (ON VACATION), PA. (ON VACATION) AND MY LOCAL DEALER, NO ONE CAN FIND A PROBLEM.NOW ALL OF A SUDDEN MY DEALER IN ROANOKE RAPIDS ,N.C. SAID HE WOULD RREPLACE SOME TRANSMISSION PARTS BUT I DO NOT KNOW WHAT THEY DID. THEY TOLD ME IT WAS TO COMPLICATING. I AM MAD AND SCARED TO DRIVE MY VAN. I DO NOT KNOW WHAT THEY DID OF IF IT WILL HAPPEN AGAIN. I TRAVEL TO PA. ALOT WITH MY 9YR OLD DAUGHTER BY OURSELVES AND NOW I AM SCARED TO DO THIS. HELP!!! NO ONE ELSE WILL!!! I CAN NOT EVEN GET IN TOUCH WITH FORD!!!
NHTSA ODI #710397
Mileage unknown · Jul 30, 1999
Power TrainSteering
NHTSA RECALL 97V-097000 AUTOMATIC TRANSMISSION LEAKING OVER CATALYTIC CONVERTER AND PROBLEM WITH STEERING LOSS. DEALER WAS NOT NOTIFIED AT THIS TIME. *AK
NHTSA ODI #843859
Mileage unknown · Jul 13, 1999
Power TrainVehicle Speed Control
WHEN COMING TO A STOP, THE VEHICLE GOES INTO NEUTRAL EVEN THOUGH THE SHIFT INDICATOR IS IN THE DRIVE POSITION. WHEN ACCELERATING AFTER STOPPING THE VEHICLE MOVES UNEXPECTEDLY AFTER APPLYING GAS. MANUFACTURER HAS BEEN NOTIFIED ABOUT THE PROBLEM. THE PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER DETAILS.
NHTSA ODI #842182
Mileage unknown · Jun 24, 1999
Power TrainVehicle Speed Control
FORD HAS A TSB 98-22-1 REGARDING A FALSE NEUTRAL AFTER DRIVING. HERE IS WHAT HAPPENS- VEHICLE IS STOPPED IN DRIVE. WHEN THROTTLE IS REAPPLIED THE VEHICLE SOMETIMES DOESN'T MOVE. BUT, IT SOMETIMES ABRUPTLY DROPS BACK INTO DRIVE. THIS HAS CAUSED A SUDDEN UNEXPECTED LURCHING FORWARD COMPLETE WITH TIRE SQUEALING. IT WOULD BE …
Read full complaint
FORD HAS A TSB 98-22-1 REGARDING A FALSE NEUTRAL AFTER DRIVING. HERE IS WHAT HAPPENS- VEHICLE IS STOPPED IN DRIVE. WHEN THROTTLE IS REAPPLIED THE VEHICLE SOMETIMES DOESN'T MOVE. BUT, IT SOMETIMES ABRUPTLY DROPS BACK INTO DRIVE. THIS HAS CAUSED A SUDDEN UNEXPECTED LURCHING FORWARD COMPLETE WITH TIRE SQUEALING. IT WOULD BE VERY LIKELY TO CAUSE AN ACCIDENT IN STOP-AND-GO TRAFFIC WITH THIS DEFECT. FORD ADMITS THIS DEFECT, THEY JUST DON'T WANT TO FIX IT AFTER 3/36K WARRANTY.
NHTSA ODI #707846
Mileage unknown · Feb 28, 1999
Power Train
2ND TRANSMISSION FAILURE: 1/26/99 @71,800 MILES. PARKED/WHEN STARTED, NO REVERSE OR FORWARD GEARS. REPAIRED: MULTIPLE PARTS: IE AX4N, AX4S, BEARING PUMP SHAFT/PLATE ETC. EXTENDED WARRENTY CLAIM DENIED/ $3,500.00 OUT OF POCKET/ TRANS, STILL DYSFUNCTIONAL & POWER STEERING DEFECTIVE AFTER LAST REPAIR. BOTH FAILURES OCCURRED O…
Read full complaint
2ND TRANSMISSION FAILURE: 1/26/99 @71,800 MILES. PARKED/WHEN STARTED, NO REVERSE OR FORWARD GEARS. REPAIRED: MULTIPLE PARTS: IE AX4N, AX4S, BEARING PUMP SHAFT/PLATE ETC. EXTENDED WARRENTY CLAIM DENIED/ $3,500.00 OUT OF POCKET/ TRANS, STILL DYSFUNCTIONAL & POWER STEERING DEFECTIVE AFTER LAST REPAIR. BOTH FAILURES OCCURRED OUT OF STATE/REPAIRED OUT OF STATE. TOMORROW I HAVE TO TAKE VAN TO AKRON OH (WHERE LAST REPAIRED) HOPE THE TRANSMISSION &STEERING WILL GET ME THERE IN 1 PEICE!! PLEASE HELP!! (DON'T KNOW IF TRANS PROBLEMS RELATED TO RECALLED PARTS, THIS VEHICLE WAS NOT PUT INTO SERVICE UNTIL 10/97 & RECALL WAS 6/97. I HAVE EXAUSTED MY RESOURCES& WOULD APPRECIATE ANY HELP/ADVICE/DIRECTION. THOUGHT I HAD A FORD WARRENTY, BUT I WAS SOLD SOMETHING ELSE, UNFORTUNATELY.THANK YOU, SINCERELY, LINDA
NHTSA ODI #703834
Mileage unknown · Feb 10, 1999
Power Train
WHILE DRIVING CONSUMER NOTICED THAT SPEEDOMETER WAS NOT WORKING AT THAT TIME, AND HAD NOT WORKED SINCE. *AK
NHTSA ODI #834735
Mileage unknown · Jan 27, 1999
Power Train
WHEN SHIFTING GEARS VEHICLE MAKES A LOUD NOISE. ALSO, THE DRIVER'S SIDE WINDOW DOESN'T WORK PROPERLY, AND THERE IS A PROBLEM WITH THE SLIDER, IT WON'T WORK. *AK
NHTSA ODI #834107
Mileage unknown · Jan 23, 1999
Power Train
THE PART IS THE SPEEDOMETER WHICH HAS REPLACEMENT PART F682.17255.CB SUPPLIED BY THE FIRM ELECTRA-SOUND, INC., WEST PALMA, OHIO. ESTIMATED COSTS FOR REPLACEMENT OF THIS PART IS $54.00 DIAGNOSTIC; $166.66 FOR THE REPLACEMENT SPEEDOMETER; $65.00 FOR LABOR. PROBLEM: THE ORIGINAL SPEEDOMETER BEGAN BEING "JITTERY" AT 20,000 MILES. …
Read full complaint
THE PART IS THE SPEEDOMETER WHICH HAS REPLACEMENT PART F682.17255.CB SUPPLIED BY THE FIRM ELECTRA-SOUND, INC., WEST PALMA, OHIO. ESTIMATED COSTS FOR REPLACEMENT OF THIS PART IS $54.00 DIAGNOSTIC; $166.66 FOR THE REPLACEMENT SPEEDOMETER; $65.00 FOR LABOR. PROBLEM: THE ORIGINAL SPEEDOMETER BEGAN BEING "JITTERY" AT 20,000 MILES. AT 40,000 MILES, THE SPEEDOMETER FLUCTUATES WILDLY AT SPEEDS OF 40 MPH AND MORE. SO, IF YOU ARE TRAVELING ON THE HIGHWAY AT 60 MPH, FOR EXAMPLE, THE SPEEDOMETER WILL SHOW SPEEDS ANYWHERE FROM 40 TO 110 MPH. YOU DO NOT KNOW WHAT SPEED YOU ARE TRAVELING!!! MECHANICS AROUND HERE HAVE BEEN QUOTED AS SAYING THIS DEFECT IS COMMON IN SPEEDOMETERS USED IN WINDSTAR AND EXPLORER MODELS. THE DEALER THAT PROVIDED MY DIAGNOSTIC WORK SAID THERE IS A TWO-WEEK BACKLOG TO GET THIS PART. THE MECHANICS ALSO SAID THE FAILURE REASON IS ATTRIBUTABLE TO A PLASTIC COMPONENT IN THE SPEEDOMETER. NOTE: THE RPM GUAGE, AND COOLANT TEMPERATURE GUAGE DO NOT SEEM TO BE AFFECTED. I THINK IT IS A FUNDAMENTAL SAFETY DEFECT TO NOT KNOW WHAT SPEED YOU ARE DRIVING AT!!! PLEASE HELP...
NHTSA ODI #702494
Mileage unknown · Jan 13, 1999
Power TrainService Brakes, Air
NORM CONDITIONS 20 MPH STOP ABS ENGAGED,DELAYED STOP. NEAR ACCIDENT. DEALER FOUND NO PROBLEM, NOT REPEATABLE. ONE YEAR LATER PROBLEM RECURRED, AND ABS LIGHT ILLUMINATED. DEALER TO REPLACE LEFT WHEEL SENSOR. SEEMS THAT IF THE ON-BOARD COMPUTER DOESN'T THINK THERE IS A PROBLEM, THE TECHNICIANS CANNOT FIND IT. SENSORS COULD HAV…
Read full complaint
NORM CONDITIONS 20 MPH STOP ABS ENGAGED,DELAYED STOP. NEAR ACCIDENT. DEALER FOUND NO PROBLEM, NOT REPEATABLE. ONE YEAR LATER PROBLEM RECURRED, AND ABS LIGHT ILLUMINATED. DEALER TO REPLACE LEFT WHEEL SENSOR. SEEMS THAT IF THE ON-BOARD COMPUTER DOESN'T THINK THERE IS A PROBLEM, THE TECHNICIANS CANNOT FIND IT. SENSORS COULD HAVE BEEN REPLACED EARLIER AS A PRECAUTION. OTHER PROBLEM- DRIVING 55 ON HIGHWAY AND TRANSMISSION DOWNSHIFTED UNCOMMANDED. CHECK ENGINE LIGHT HAD BEEN ILLUMINATED SINCE EARLIER INCIDENT WITH THE DEALER UNABLE TO DIAGNOSE. SENSOR IN GEAR SELECTOR WAS BAD. HOPEFULLY, NO UNDUE WEAR AND TEAR ON TRANSMISSION RESULTED FROM THE HIGHWAY DOWNSHIFT.
NHTSA ODI #702197
Official recalls
5Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Jun 18, 2001
ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS COULD FRACTURE AS A RESULT OF CORROSION. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL PROTECTIVE SHIELDS AROUND THE FRONT COIL SPRINGS. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Jun 19, 2000
VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.
Consequence & remedy
Consequence: THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.
Remedy: DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
Jun 14, 1999
VEHICLE DESCRIPTION: MINIVANS. THE BRAKE FLUID MASTER CYLINDER IS RECESSED AND ORIENTED IN THE ENGINE COMPARTMENT SO THAT THE BRAKE FLUID WARNING STATEMENT EMBOSSED ON BOTH THE TOP OF THE FILLER CAP AND THE SIDE OF THE RESERVOIR BODY ARE NOT ENTIRELY VISIBLE BY DIRECT VIEW. THESE VEHICLES MAY NOT FULLY COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE PROVIDED WITH NEW LABELS AND INSTALLATION INSTRUCTIONS.
Jun 9, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AX4S AUTOMATIC TRANSAXLES. THE LOW/INTERMEDIATE SERVO COVER CAN SEPARATE FROM THE TRANSAXLE WHILE THE VEHICLE IS BEING DRIVEN. IF THIS OCCURS, TRANSMISSION FLUID WILL LEAK CONTACTING THE CATALYTIC CONVERTER.
Consequence & remedy
Consequence: THE CATALYTIC CONVERTER TEMPERATURE MAY BE HOT ENOUGH TO IGNITE THE TRANSMISSION FLUID AND CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION AND REPLACE THESE SERVO COVERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA08021 · Engine Compartment Fires
Opened Sep 17, 2008 · Closed Oct 14, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Additional source detail variants (7)
Electrical System
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Electrical System:wiring
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE08035 · Engine Compartment Fires
Opened May 13, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Electrical System:wiring
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA03004 · Wheel Stud Fracture
Opened Apr 10, 2003 · Closed Aug 30, 2004
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Wheels
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Wheels:lugs/nuts/bolts/studs
THE SUBJECT VEHICLES RANGE IN AGE FROM 4?7 YEARS IN SERVICE, WITH AVERAGE MILEAGES ESTIMATED TO RANGE FROM 50 TO 100 THOUSAND MILES.AT THESE MILEAGES, THE SUBJECT WHEELS ARE LIKELY TO HAVE BEEN REMOVED AND REINSTALLED MULTIPLE TIMES FOR VARIOUS SERVICE PROCEDURES.ODI IS CONCERNED ABOUT THE HIGH WHEEL SEPARATION RATES IN THE MY 1997-98 WINDSTAR VEHICLES EQUIPPED WITH ALUMINUM ALLOY WHEELS.HOWEVER, ANALYSIS OF FAILURE DATA INDICATES THAT MOST OF THE INCIDENTS IN THAT POPULATION OF VEHICLES OCCUR AFTER THE VEHICLES HAD ACCUMULATED 30 THOUSAND MILES OF SERVICE. THE FACTORS THAT INCREASE THE RISK THAT INADEQUATE CLAMP LOADS MAY BE ACHIEVED DURING SERVICE-RELATED WHEEL INSTALLATION ARE NOT UNIQUE TO THE SUBJECT VEHICLES.TESTING CONDUCTED BY FORD AND VRTC INDICATE THAT THE MY 1998 WINDSTAR ALUMINUM WHEEL FASTENING SYSTEM PERFORMS SIMILAR TO THE WHEEL FASTENING SYSTEMS ON PEER MINIVANS.NO DESIGN OR MANUFACTURING DEFECTS WERE IDENTIFIED IN THE WHEEL FASTENING SYSTEMS OF THE SUBJECT VEHICLES. FORD WILL SEND A MAILING TO OWNERS OF WINDSTAR VEHICLES WITH ALUMINUM WHEELS THAT HAVE HIGH WHEEL SEPARATION RATES THAT REVIEWS THE APPROPRIATE WHEEL FASTENING PROCEDURES AND STATES THAT THE WHEEL NUTS SHOULD BE TIGHTENED TO THE NOMINAL TORQUE, 100 FT-LBS (136 NM), AND RE-TIGHTENED TO THE SAME TORQUE AFTER 500 MILES.FORD?S LETTER ALSO STATES THAT IT IS ?A GOOD PRACTICE TO BE SURE THAT BEFORE INSTALLING THE WHEEL THE ALUMINUM WHEEL MOUNTING SURFACE, WHEEL LUG NUT AREA, AND THE MOUNTING FLANGE ARE FREE FROM DIRT, DEBRIS, AND LOOSE RUST TO ENSURE THE WHEEL IS SEATED CORRECTLY AND THE WHEEL LUG NUTS REMAIN FULLY TIGHTENED.? ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF WHEEL FASTENER FAILURES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA00027 · Suspension Coil Spring Breakage
Opened Dec 8, 2000 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
PE00024 · Suspension Coil Spring Breakage
Opened Jun 23, 2000 · Closed Dec 8, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99020 · Fuel Tank Cracks
Opened Jul 26, 1999 · Closed Dec 16, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline
There is no summary currently available
Illustration