NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
19 reportsClear category filter41,500 miles · Jul 11, 2018
Service Brakes
WHILE AT FORD DEALER FOR CORRECTION OF A SAFETY RECALL ISSUE I REQUESTED THE DEALER TO CHECK VEHICLE OVER AND TO DETERMINE IF MY VEHICLE'S REAR BRAKE CALIPER ANCHOR PLATE OR BRACKEDS WERE INTALLED INCORRECTLY (AS THERE IS/WAS A TSB ISSUED FOR THIS MODEL AND MY VAN WAS INCLUDED. THE TSB # IS 15-0190. INSPECTION OF MY VEHICLE RE…
Read full complaint
WHILE AT FORD DEALER FOR CORRECTION OF A SAFETY RECALL ISSUE I REQUESTED THE DEALER TO CHECK VEHICLE OVER AND TO DETERMINE IF MY VEHICLE'S REAR BRAKE CALIPER ANCHOR PLATE OR BRACKEDS WERE INTALLED INCORRECTLY (AS THERE IS/WAS A TSB ISSUED FOR THIS MODEL AND MY VAN WAS INCLUDED. THE TSB # IS 15-0190. INSPECTION OF MY VEHICLE REVEALED THAT MY VEHICLE DOES IN FACT HAVE THIS ABNORMNAL ASSEMBLY (THE RIGHT SIDED BRACKET IS UPSIDE DOWN ON THE LEFT SIDE AND THE LEFT SIDED PLATE IS INSTALLED ON THE RIGHT. BECAUSE MY VEHICLE DOES NOT AT THIS TIME APPEAR TO BE EXHIBITING UNEVEN BRAKE WEAR AND IT HAS 41500 MILES FORD DOES NOT COVER OR REQUIRE A REPAIR AND I WAS TOLD I WOULD NEED TO HAVE A BRAKE JOB DONE AT ESTIMATED COST OF $825 DURING WHICH WOULD ALLOW THE ANCHOR PLATES TO BE CORRECTED. I FEEL THIS TSB SHOULD BE UPGRADED TO A RECALL TO CORRECT THIS MISASSEMBLY WHICH MAY AFFECT THE BRAKE PERFORMANCE OF MY VEHICLE IN THE FUTURE. I WAS TOLD I AM OUT OF WARRANTEE BY TIME AND MILEAGE AND BECAUSE MY VEHICLE HAS NOT YET BEEN EXHIBITING UNEVEN BRAKE WEAR THAT FORD DID NOT HAVE AN OBLIGATION TO FIX IT AS IT INVOLVES A TSB RATHER THAN A RECALL. MY VEHICLE WAS ONE OF THE FIRST BUILT WITH ASSEMBLY DATE 4/2014. I FEEL THAT THIS SHOULD BE MADE A RECALL IF THAT IS WHAT IT WILL REQUIRE TO MAKE FORD CORRECT THIS. I SIMPLY WANT MY VEHICLE PUT TOGETHER THE WAY IT WAS SUPPOSED TO HAVE BEEN AND TO PREVENT BRAKE ISSUES FROM OCCURING.
NHTSA ODI #11110731
Mileage unknown · Apr 2, 2018
Engine And Engine CoolingPower TrainService Brakes
2015 FORD TRANSIT. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS AND REQUESTS VEHICLE BUY-BACK INFORMATION. *LD THE CONSUMER STATED THE VEHICLE DOES NOT HAVE 6 CYLINDERS AND REQUESTED THAT THE DATA ENTRY ERROR BE CORRECTED WITH THE MVA. THE VEHICLE BEGAN TO EMIT AN EXHAUST ODOR, THE ENGINE OCCASIONALLY RUNS ROUGH, THE…
Read full complaint
2015 FORD TRANSIT. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS AND REQUESTS VEHICLE BUY-BACK INFORMATION. *LD THE CONSUMER STATED THE VEHICLE DOES NOT HAVE 6 CYLINDERS AND REQUESTED THAT THE DATA ENTRY ERROR BE CORRECTED WITH THE MVA. THE VEHICLE BEGAN TO EMIT AN EXHAUST ODOR, THE ENGINE OCCASIONALLY RUNS ROUGH, THE REAR BRAKES NEEDED TO BE REPLACED, PREMATURELY, AND THE POWER STEERING FAILED. *JS
NHTSA ODI #11021928
Mileage unknown · Jul 29, 2017
Service BrakesUnknown Or Other
I HAVE 2 TRANSIT VAN BOTH BRAKE WEAR AROUND 18000 N WHEN WEAR GO RIGHT TO THE MATEL AND BRAKE AND ROTOR GET HOTTER THAN NORMAL TAKE TO MANY PRIVATE MECHANICS THEY ARE SAY BRAKE UNDER SIZE OR DESIGN ISSUE
NHTSA ODI #11011488
42,932 miles · Jul 14, 2017
Service Brakes
OUR DRIVER WAS DRIVING ON THE BELTWAY WHEN HIS BRAKES LOCKED UP ON HIM. WE DROPPED IF OFF TO THE SHOP TO HAVE A LOOK AND FOUND THE RIGHT REAR CALIPER WAS FAULTY. SINCE WE WERE UNABLE TO GET THE TRUCK TO THE DEALER ( THE TRUCK IS STILL UNDER WARRANTY). WE HAD THE SHOP REPLACE THE FAULTY CALIPER. SO WE COULD GET THE TRUCK BACK …
Read full complaint
OUR DRIVER WAS DRIVING ON THE BELTWAY WHEN HIS BRAKES LOCKED UP ON HIM. WE DROPPED IF OFF TO THE SHOP TO HAVE A LOOK AND FOUND THE RIGHT REAR CALIPER WAS FAULTY. SINCE WE WERE UNABLE TO GET THE TRUCK TO THE DEALER ( THE TRUCK IS STILL UNDER WARRANTY). WE HAD THE SHOP REPLACE THE FAULTY CALIPER. SO WE COULD GET THE TRUCK BACK ON THE ROAD. NOW I NEED TO KNOW WHY THIS IS NOT A RECALL "BRAKES" ARE CERTAINLY A SAFETY ISSUE! AND HOW DO I GO ABOUT TRYING TO GET REIMBURSED FOR THE CHARGES FOR THIS?
NHTSA ODI #11005312
112,112 miles · May 24, 2017
EnginePower TrainService Brakes
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 70 MPH, A LOUD NOISE WAS HEARD AND THE BRAKES FAILED TO WORK WITHOUT WARNING. THE DRIVER STOPPED THE VEHICLE BY CHANGING THE GEAR AND PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER LOCATED AT 16005 VALLEY BLVD, FONTANA, CA 92335, WHERE IT WAS DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 70 MPH, A LOUD NOISE WAS HEARD AND THE BRAKES FAILED TO WORK WITHOUT WARNING. THE DRIVER STOPPED THE VEHICLE BY CHANGING THE GEAR AND PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER LOCATED AT 16005 VALLEY BLVD, FONTANA, CA 92335, WHERE IT WAS DIAGNOSED THAT THE DRIVE LINE, BRAKES, AND RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THEY WOULD REIMBURSE THE CONTACT $2,000. THE FAILURE MILEAGE WAS 112,112.
NHTSA ODI #10991427
153,522 miles · Dec 13, 2016
Power TrainService Brakes
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE DRIVESHAFT FRACTURED AND CAUSED DAMAGE TO THE TORQUE CONVERTER AND THE BRAKE LINES. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED. THE CONTACT STATED THAT THE DEALER REPLACED THE TRANSMISSION, THE TORQUE CONVERTER AND ALSO THE BRA…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE DRIVESHAFT FRACTURED AND CAUSED DAMAGE TO THE TORQUE CONVERTER AND THE BRAKE LINES. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED. THE CONTACT STATED THAT THE DEALER REPLACED THE TRANSMISSION, THE TORQUE CONVERTER AND ALSO THE BRAKE LINES WERE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,522.
NHTSA ODI #10935016
112,000 miles · Nov 15, 2016
Fuel/propulsion SystemPower TrainService Brakes
FORD TRANSIT WITH WAS GOING DOWN A STRAIGHT FOUR-LANE HIGHWAY AT 65 MILES PER HOUR WHEN WITHOUT WARNING THE FLANGE ON THE DRIVE SHAFT CAME APART. DRIVER HEARD WHAT SOUNDED LIKE A SMALL EXPLOSION. THE BRAKE LINES WERE BLOWN OFF, THE FUEL LINE WAS DAMAGED, THE DRIVE SHAFT WAS BROKEN, AND A HOLE WAS BLOWN INTO THE TRANSMISSION C…
Read full complaint
FORD TRANSIT WITH WAS GOING DOWN A STRAIGHT FOUR-LANE HIGHWAY AT 65 MILES PER HOUR WHEN WITHOUT WARNING THE FLANGE ON THE DRIVE SHAFT CAME APART. DRIVER HEARD WHAT SOUNDED LIKE A SMALL EXPLOSION. THE BRAKE LINES WERE BLOWN OFF, THE FUEL LINE WAS DAMAGED, THE DRIVE SHAFT WAS BROKEN, AND A HOLE WAS BLOWN INTO THE TRANSMISSION CASE. DRIVER HAD NO BRAKES, THE DRIVE SHAFT WAS SEPARATED FROM THE REAR WHEELS, AND TRANSMISSION COULD NOT BE DOWN SHIFTED. ENGINE REMAINED ON AND SHE WAS ABLE TO STEER. THERE WAS NO TRAFFIC NEAR HER OR AROUND HER AT THE TIME. ROAD WAS STRAIGHT. DRIVER PUT HAND ON EMERGENCY BRAKE INCASE SOME ONE PULLED IN FRONT OF HER AND COAST TWO MILES TO A STOP.
NHTSA ODI #10926224
38,000 miles · Oct 8, 2016
Service Brakes
I WAS GETTING THE TIRES ROTATED AND THE AUTO TECH SAID THE REAR BRAKE PADS WERE DANGEROUSLY THIN. THE FRONT PADS WERE FINE. I INSTRUCTED THE TECH TO REPLACE THE REAR PADS. THE MANAGER CAME IN AND SAID THE RIGHT REAR CALIPER WAS FROZEN AND WAS LEAKING BRAKE FLUID. THE VAN HAS 38,000 MILES ON IT.
NHTSA ODI #10914889
16,487 miles · Sep 8, 2016
Service BrakesWheels
COMPANY OWNS TWO FORD TRANSITS-SAME ISSUES ON BOTH FOUR TIMES IN FOR REPAIRS FOR SAME PROBLEMS SINCE SPRING BRAKES REPLACED, BROKEN CALIPERS, BROKEN CALIPER BOLTS, TWICE BROKEN AXLES
NHTSA ODI #10904636
Official recalls
26Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
Oct 25, 2019
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
Apr 29, 2019
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
Apr 26, 2019
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
Apr 18, 2019
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
Apr 3, 2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
Mar 28, 2019
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
Mar 26, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
Mar 18, 2019
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
Mar 6, 2019
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Nov 6, 2018
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
Apr 30, 2018
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
Jun 26, 2017
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
Aug 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence & remedy
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Additional source detail variants (2)
Fuel System, Diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Engine And Engine Cooling:engine:diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
May 24, 2016
New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
May 20, 2016
National Van Builders, Inc. (National Van) is recalling certain model year 2015 Ford Transit vehicles manufactured July 1, 2015, to October 30, 2015, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: National Van will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 15, 2016. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon 2016.
Apr 4, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence & remedy
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
Feb 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence & remedy
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
Dec 22, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured May 1, 2015, to June 26, 2015, and equipped with dual rear wheels. The affected vehicles have a left or right rear axle drive shafts that may fracture, resulting in loss of drive power. Additionally, the vehicle may unexpectedly roll if it is parked without the parking brake applied.
Consequence & remedy
Consequence: A loss of drive power or vehicle rollaway after being parked can increase the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the left and right axle drive shafts, free of charge. The recall began February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S37.
Jun 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured March 1, 2015, to April 10, 2015. The affected vehicles may have been built with seat belt assemblies that have seat belt labels that are missing the required belt model and model year and instead state "prototype sample." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: In the event of a safety issue with the affected seat belts, the vehicle owner may not be able to identify the seat belt if the seat belt label does not include a date of manufacturer.
Remedy: Ford has notified the one fleet owner affected, and a Ford representative will travel to the vehicle locations to install a new label that includes all of the required information. There will be no charge for this service. The recall began on June 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C05.
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured July 28, 2014, to August 7, 2014. In the affected vehicles the fuel filter bracket mounting may detach from the frame cross member over time.
Consequence & remedy
Consequence: A separation of the fuel filter from the cross member will disrupt distribution of fuel to the engine, thereby inducing an engine stall. An unexpected engine stall while driving increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate, free of charge. The recall began on December 19, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S23.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence & remedy
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:disc:caliper
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit cargo vans without rear seating positions manufactured March 12, 2014, to June 24, 2014 and equipped with windowless sliding doors. The affected vehicles may have been manufactured without the epoxy reinforcement on the windowless sliding doors.
Consequence & remedy
Consequence: A sliding door without the epoxy reinforcement has an increased potential of unlatching in certain side impact crashes. A door that unlatches may open, allowing for a vehicle occupant to be ejected in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate into the windowless sliding door, free of charge. The recall began in September 22, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S16.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration