NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
35 reportsClear category filter151,500 miles · Feb 21, 2020
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP LEAKED INSIDE THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP WAS REPLACED AT ASHE COUNTY FORD DEALER, (409 E 2ND ST, WEST JEFFERSON, NC 28694) HOWEVER, THE FAILURE RE…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP LEAKED INSIDE THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE HIGH-PRESSURE FUEL PUMP WAS REPLACED AT ASHE COUNTY FORD DEALER, (409 E 2ND ST, WEST JEFFERSON, NC 28694) HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.*BF*JB
NHTSA ODI #11310509
31,853 miles · Jan 28, 2020
EngineFuel/propulsion System
THE VEHICLE STALLED UPON BACKING OUT OF A STEEP DRIVEWAY & TURNING TO THE LEFT. IT WOULD NOT RESTART. THE VAN HAD BEEN PARKED, AT A CUSTOMERS' HOME ALL DAY. HEAVY SNOW BEGAN FALLING A COUPLE OF HOURS BEFORE THE VAN WAS STARTED & WARMED UP TO MELT THE SNOW FROM THE WINDSHIELD. WHEN THE VAN STALLED, IT WAS BROADSIDE TO THE STREET,…
Read full complaint
THE VEHICLE STALLED UPON BACKING OUT OF A STEEP DRIVEWAY & TURNING TO THE LEFT. IT WOULD NOT RESTART. THE VAN HAD BEEN PARKED, AT A CUSTOMERS' HOME ALL DAY. HEAVY SNOW BEGAN FALLING A COUPLE OF HOURS BEFORE THE VAN WAS STARTED & WARMED UP TO MELT THE SNOW FROM THE WINDSHIELD. WHEN THE VAN STALLED, IT WAS BROADSIDE TO THE STREET, BLOCKING BOTH OPPOSING LANES OF TRAVEL AS THE HEAVY SNOW INCREASED IN INTENSITY. THE VAN WAS VIRTUALLY IMPOSSIBLE TO PUSH OFF TO THE SIDE OF THE ROAD, DUE TO THE QUICKLY ACCUMULATING SNOW, INITIALLY PREVENTING A PLOW & POLICE CRUISER FROM PASSING. AAA TOWING WAS CALLED BUT, DID NOT ARRIVE UNTIL 2 HOURS AFTER BEING SUMMONSED AS THE SNOW CONTINUED TO ACCUMMULATE. I HAD THE VAN TOWED TO OUR BUSINESS LOCATION AND DECIDED TO CHECK THE ENGINE AIR FILTER. WHEN I OPENED THE FILTER HOUSING, IT AND THE AIR FITER WERE WATER-SOAKED. I OBSERVED WATER RUNNING DOWN THE WINDSHIELD, DOWN ALONG THE FIREWALL AND ONTO/INTO THE AIR FILTER BOX. I CONTACTED MY LOCAL FORD DEALER (FORD OF WILBRAHAM, MA, TEL.: 413-543-2800) TO REPORT MY FINDINGS & TO MAKE AN APPOINTMENT TO REMEDY THE PROBLEM. THE SOLUTION WAS PERFORMED AS PER TSB (TECHNICAL SERVICE BULLETIN) #19-2091 AND AT A COST OF $488.45 (INVOICE #659506), WHICH I RELUCTANTLY PAID TO THE DEALER. I EXPLAINED THAT THIS A POOR DESIGN ALLOWING WATER TO RUN DIRECTLY INTO THE AIR FILTER BOX, WHICH, IN TURN, SHUTS DOWN THE ENGINE & RENDERS THE VEHICLE MOTIONLESS & CAN BE DANGEROUS, DEPENDING UPON WHERE & WHEN THE VEHICLES' ENGINE STALLS & THEN FAILS TO RESTART. THE SERVICE WRITER SAID THAT THERE WAS NOTHING SHE COULD DO TO HELP ME & THAT I AM STILL RESPONSIBLE FOR THE COST OF THE TSB. IN ADDITION, MY INVOICE INDICATES THAT RECALL #19S38 WAS PERFORMED, YET IT IS STILL OUTSTANDING ON THE RECALL WEBSITE UNDER MY VEHICLES' VIN. FOR THE RECORD, THIS VAN HAD ONLY 31,853 MILES ON IT, WHEN I BROUGHT IT IN FOR THIS PROBLEM.
NHTSA ODI #11302511
122,000 miles · Jan 3, 2020
Engine
TL* THE CONTACT OWNS A 2015 FORD TRANSIT 350. THE CONTACT STATED THAT THE AIR INTAKE WAS MOUNTED ON THE VEHICLE IN A WAY THAT ALLOWED WATER TO GET INSIDE AND RUST OUT THE BOLTS THAT SECURED THE AIR INTAKE IN PLACE. AS A RESULT, ANTI-FREEZE WOULD LEAK AND POSSIBLY CAUSE A FIRE. THE VEHICLE WAS LOSING ANTI-FREEZE AND THE TOP OF TH…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT 350. THE CONTACT STATED THAT THE AIR INTAKE WAS MOUNTED ON THE VEHICLE IN A WAY THAT ALLOWED WATER TO GET INSIDE AND RUST OUT THE BOLTS THAT SECURED THE AIR INTAKE IN PLACE. AS A RESULT, ANTI-FREEZE WOULD LEAK AND POSSIBLY CAUSE A FIRE. THE VEHICLE WAS LOSING ANTI-FREEZE AND THE TOP OF THE ENGINE WAS SMOKING WHILE THE VEHICLE WAS IN MOTION. THE BOLTS HAD COMPLETELY RUSTED AND THE WATER FROZE WHEN THE VEHICLE WAS PARKED. WHEN THE ICE MELTED AND THE ENGINE WARMED UP FROM DRIVING, A FIRE NEARLY OCCURRED. THE CONTACT SAW SMOKE, PULLED OVER, AND OPENED THE HOOD. THE CONTACT HAD TO CALL TO HAVE MORE ANTI-FREEZE DELIVERED TO REFILL THE VEHICLE. THE VEHICLE WAS TAKEN TO GARNET FORD (1610 WILMINGTON PIKE, WEST CHESTER, PA 19382 (610) 358-5600) WHERE IT WAS IN THE PROCESS OF BEING DIAGNOSED. THE MANUFACTURER WAS CALLED AND TRANSFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 122,000.
NHTSA ODI #11296802
72,000 miles · Nov 12, 2019
Engine
IT APPEARS THAT THIS MODEL HAS AN ENGINE FAILURE ISSUE RELATED TO WATER ENTERING THE AIR BOX AND CAUSING THE WATER TO TRAVEL TO COMPONENTS THAT DISABLES THE CAR. I WAS DRIVING IN THE RAIN AND GOT STRANDED ON THE SIDE OF THE INTERSTATE IN HEAVY TRAFFIC AND HEAVY RAIN ON I40 IN KNOXVILLE TN FOR AN HOUR WAITING FOR A TOW TRUCK TO …
Read full complaint
IT APPEARS THAT THIS MODEL HAS AN ENGINE FAILURE ISSUE RELATED TO WATER ENTERING THE AIR BOX AND CAUSING THE WATER TO TRAVEL TO COMPONENTS THAT DISABLES THE CAR. I WAS DRIVING IN THE RAIN AND GOT STRANDED ON THE SIDE OF THE INTERSTATE IN HEAVY TRAFFIC AND HEAVY RAIN ON I40 IN KNOXVILLE TN FOR AN HOUR WAITING FOR A TOW TRUCK TO GET ME OUT OF A DANGEROUS SITUATION. HAD IT TOWED TO A DEALER THAT PROCEEDED TO TELL ME THE NEXT DAY THAT THERE WAS A TSB ON THIS ISSUE AND THAT THERE WAS A KIT THAT REMEDIES THE PROBLEM. A DEFLECTOR OF SOME SORT TO KEEP WATER OUT OF THE AIR BOX. THE COST TO THE CONSUMER IS OVER $750 TO GET IT DONE. I STRONGLY BELIEVE THAT IS FORD KNOWS ABOUT ABOUT THIS ISSUE AND HAS COME UP WITH A SOLUTION, IT SHOULD BE A RECALL AND NOT JUST A TSB. THEIR POOR DESIGN AND NEGLIGENCE PUT ME IN A DANGEROUS SITUATION FOR ABOUT AN HOUR . I COULD HAVE BEEN RAMMED BY HIGHWAY TRAVELERS AND POSSIBLY KILLED BECAUSE MY VEHICLE WAS DISABLED BECAUSE OF A POOR DESIGN THAT FORD REFUSES TO REPAIR AT THEIR COST. SOMEONE PLEASE ADVISE FORD AND THEIR DEALERS THAT THIS IS NOT A CONVENIENCE ISSUE, BUT A LIFE THREATENING ISSUE THAT FORD SHOULD ISSUE A RECALL TO REMEDY THE POOR DESIGN AT THEIR COST. THANK YOU.
NHTSA ODI #11279558
257,655 miles · Oct 17, 2019
EnginePower Train
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SHOOK AND THE RPMS BEGAN TO LOWER. THE VEHICLE EVENTUALLY STALLED. THE CONTACT AND THE PASSENGER HAD TO PUSH THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO BLAKE UTTER FORD (LOCATED AT 215 HWY 75 NORTH, DENISON, TX 75020, 903…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SHOOK AND THE RPMS BEGAN TO LOWER. THE VEHICLE EVENTUALLY STALLED. THE CONTACT AND THE PASSENGER HAD TO PUSH THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO BLAKE UTTER FORD (LOCATED AT 215 HWY 75 NORTH, DENISON, TX 75020, 903-465-5671) WHERE IT WAS DIAGNOSED THAT THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE DEALER WAS STILL LOOKING TO SEE IF ANY OTHER FAILURES COULD BE PRESENT WITH THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 257,655.
NHTSA ODI #11269211
95,000 miles · Jul 10, 2019
Engine
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 10-80 MPH, THE ENGINE FAULT WARNING INDICATOR ILLUMINATED AND THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO EXIT THE ROADWAY. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR R…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. ON SEVERAL OCCASIONS, WHILE DRIVING APPROXIMATELY 10-80 MPH, THE ENGINE FAULT WARNING INDICATOR ILLUMINATED AND THE VEHICLE LOST POWER. THE CONTACT WAS ABLE TO EXIT THE ROADWAY. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. BARBEE'S FREEWAY FORD (4471 EAST EVANS AVENUE, DENVER, CO, (303) 584-6600) WAS CALLED, BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #11230735
24,500 miles · Jan 9, 2019
Electrical SystemEngineFuel/propulsion System
THE VEHICLE RANDOMLY DEVELOPED HESITATION TO START ONE DAY AS IF IT WASN'T GETTING ENOUGH FUEL OR AIR. IT DID START AND I DROVE HOME FROM WORK. I PLANNED TO TAKE IT TO A DEALERSHIP TO GET IT CHECKED OUT BUT THE NEXT DAY BUT THE VEHICLE WOULD NOT START. I ATTEMPTED TO JUMP-START BUT THE BATTERY WAS AT FULL VOLTAGE. I HAD TH…
Read full complaint
THE VEHICLE RANDOMLY DEVELOPED HESITATION TO START ONE DAY AS IF IT WASN'T GETTING ENOUGH FUEL OR AIR. IT DID START AND I DROVE HOME FROM WORK. I PLANNED TO TAKE IT TO A DEALERSHIP TO GET IT CHECKED OUT BUT THE NEXT DAY BUT THE VEHICLE WOULD NOT START. I ATTEMPTED TO JUMP-START BUT THE BATTERY WAS AT FULL VOLTAGE. I HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY DIAGNOSED THE CAR. I WAS INFORMED THE NEXT DAY BY THE TECHNICIAN THAT THERE WAS A TSB ABOUT THIS ISSUE AND THAT FORD MOTOR COMPANY WAS WELL AWARE OF THE PROBLEM AND THAT IT WOULD COST ME $850 PLUS TAX. APPARENTLY THE CABIN AIR FILTER IS NOT PROPERLY WEATHER SEALED AND UNDER NORMAL USE WATER WILL MAKE ITS WAY INTO THE FILTER, AND INTO THE MASS AIR SENSOR. FORD HAS MADE NEW REPLACEMENT PARTS FOR THIS ISSUE BUT BECAUSE I AM OUT OF WARRANTY BY A FEW MONTHS, I WILL HAVE TO PAY FOR THE ENTIRETY OF THE BILL. HAD THE PART GIVEN OUT WHILE DRIVING (ESPECIALLY AT HIGH SPEEDS) THE ENGINE WOULD SEIZE AND COULD HAVE LIKELY CAUSED A CRASH.
NHTSA ODI #11166133
56,000 miles · Dec 20, 2018
Engine
ENGINE WOULD STALL WHILE DRIVING AND DOESN'T WANT TO START THIS HAPPENED THREE TIMES ONCE WHILE DRIVING. THIRD TIME IT HAD TO TOWED AWAY . LOOKS LIKE FUEL NOT GETTING TO THE ENGINE OR PROBLEM WITH FUEL SYSTEM
NHTSA ODI #11162651
188,000 miles · Dec 13, 2018
Engine
2015 FORD TRANSIT CARGO E250 CAB FILLED WITH EXHAUST FUMES WHILE DRIVING ON INTERSTATE AND BECAME OVERWHELMING. TOOK VAN TO FORD DEALER AND THEY SAID THAT THE EXHAUST MANIFOLDS WERE LEAKING AND NEEDED TO BE CHANGED OUT. REPAIR ESTIMATE WAS $2,300.00 DOLLARS AND NOW I AM LOOKING AT A $9,000.00 DOLLAR REPAIR BILL.
NHTSA ODI #11161213
75,000 miles · Oct 22, 2018
EngineFuel/propulsion System
VEHICLE WAS BEING DRIVEN ON A TWO-LANE ROAD AT 45 MPH WHEN SUDDENLY THE ENGINE JUST STOPPED WITHOUT BEING ABLE TO EVEN PULL TO THE SIDE OF THE ROAD. I TRADED CARS WITH MY WIFE SO SHE COULD TAKE OUR 6 KIDS HOME. TOWED THE VEHICLE TO A FORD DEALERSHIP WHO DIAGNOSED A FAULTY FUEL PUMP CONTROL MODULE. SAID THIS HAPPENS A LOT. SEVERA…
Read full complaint
VEHICLE WAS BEING DRIVEN ON A TWO-LANE ROAD AT 45 MPH WHEN SUDDENLY THE ENGINE JUST STOPPED WITHOUT BEING ABLE TO EVEN PULL TO THE SIDE OF THE ROAD. I TRADED CARS WITH MY WIFE SO SHE COULD TAKE OUR 6 KIDS HOME. TOWED THE VEHICLE TO A FORD DEALERSHIP WHO DIAGNOSED A FAULTY FUEL PUMP CONTROL MODULE. SAID THIS HAPPENS A LOT. SEVERAL OTHER FORD VEHICLES HAVE BEEN RECALLED FOR THIS REASON BUT NOT THE 2015 TRANSIT.
NHTSA ODI #11141820
Official recalls
26Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
Oct 25, 2019
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
Apr 29, 2019
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
Apr 26, 2019
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
Apr 18, 2019
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
Apr 3, 2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
Mar 28, 2019
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
Mar 26, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
Mar 18, 2019
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
Mar 6, 2019
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Nov 6, 2018
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
Apr 30, 2018
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
Jun 26, 2017
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
Aug 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence & remedy
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Additional source detail variants (2)
Fuel System, Diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Engine And Engine Cooling:engine:diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
May 24, 2016
New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
May 20, 2016
National Van Builders, Inc. (National Van) is recalling certain model year 2015 Ford Transit vehicles manufactured July 1, 2015, to October 30, 2015, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: National Van will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 15, 2016. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon 2016.
Apr 4, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence & remedy
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
Feb 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence & remedy
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
Dec 22, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured May 1, 2015, to June 26, 2015, and equipped with dual rear wheels. The affected vehicles have a left or right rear axle drive shafts that may fracture, resulting in loss of drive power. Additionally, the vehicle may unexpectedly roll if it is parked without the parking brake applied.
Consequence & remedy
Consequence: A loss of drive power or vehicle rollaway after being parked can increase the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the left and right axle drive shafts, free of charge. The recall began February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S37.
Jun 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured March 1, 2015, to April 10, 2015. The affected vehicles may have been built with seat belt assemblies that have seat belt labels that are missing the required belt model and model year and instead state "prototype sample." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: In the event of a safety issue with the affected seat belts, the vehicle owner may not be able to identify the seat belt if the seat belt label does not include a date of manufacturer.
Remedy: Ford has notified the one fleet owner affected, and a Ford representative will travel to the vehicle locations to install a new label that includes all of the required information. There will be no charge for this service. The recall began on June 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C05.
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured July 28, 2014, to August 7, 2014. In the affected vehicles the fuel filter bracket mounting may detach from the frame cross member over time.
Consequence & remedy
Consequence: A separation of the fuel filter from the cross member will disrupt distribution of fuel to the engine, thereby inducing an engine stall. An unexpected engine stall while driving increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate, free of charge. The recall began on December 19, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S23.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence & remedy
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:disc:caliper
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit cargo vans without rear seating positions manufactured March 12, 2014, to June 24, 2014 and equipped with windowless sliding doors. The affected vehicles may have been manufactured without the epoxy reinforcement on the windowless sliding doors.
Consequence & remedy
Consequence: A sliding door without the epoxy reinforcement has an increased potential of unlatching in certain side impact crashes. A door that unlatches may open, allowing for a vehicle occupant to be ejected in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate into the windowless sliding door, free of charge. The recall began in September 22, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S16.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration