NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
19 reportsClear category filter81,700 miles · Mar 10, 2021
Electrical SystemEngine
FOLLOW-UP TO PRIOR PROBLEM REPORT ON THIS VIN. AFTER 24 HRS WITH BATTERY DISCONNECTED, I RECONNECTED BATTERY. PRIOR PROBLEM DID NOT REPRODUCE AND VEHICLE APPEARED TO POWER-UP NORMALLY. I USED THE KEY TO SUCCESSFULLY START AND RUN THE ENGINE. BUT THERE WERE NO INSTRUMENT READINGS, TACHOMETER READ ZERO. I MOVED THE KEY BACK TO THE…
Read full complaint
FOLLOW-UP TO PRIOR PROBLEM REPORT ON THIS VIN. AFTER 24 HRS WITH BATTERY DISCONNECTED, I RECONNECTED BATTERY. PRIOR PROBLEM DID NOT REPRODUCE AND VEHICLE APPEARED TO POWER-UP NORMALLY. I USED THE KEY TO SUCCESSFULLY START AND RUN THE ENGINE. BUT THERE WERE NO INSTRUMENT READINGS, TACHOMETER READ ZERO. I MOVED THE KEY BACK TO THE OFF POSITION, BUT THE ENGINE CONTINUED TO RUN. THE ONLY WAY TO KILL THE ENGINE WAS TO DISCONNECT THE BATTERY CABLE. THAT MEANS THE DEFECTIVE MODULE IS NOT FAILING SAFE.
NHTSA ODI #11400116
81,700 miles · Mar 9, 2021
Electrical SystemEngine
A CONTROL MODULE BEGAN MALFUNCTIONING BY FIRST CAUSING THE HEADLIGHTS TO COME ON SPONTANEOUSLY. THE VEHICLE WAS PARKED (AT HOME), HEADLIGHT SWITCH OFF, NO KEY IN IGNITION. AFTER REMOVING THE BATTERY NEGATIVE CABLE, ANY ATTEMPT TO RECONNECT THE BATTERY CAUSES THE STARTER MOTOR TO SPONTANEOUSLY ENERGIZE AND THE ENGINE TO START RUN…
Read full complaint
A CONTROL MODULE BEGAN MALFUNCTIONING BY FIRST CAUSING THE HEADLIGHTS TO COME ON SPONTANEOUSLY. THE VEHICLE WAS PARKED (AT HOME), HEADLIGHT SWITCH OFF, NO KEY IN IGNITION. AFTER REMOVING THE BATTERY NEGATIVE CABLE, ANY ATTEMPT TO RECONNECT THE BATTERY CAUSES THE STARTER MOTOR TO SPONTANEOUSLY ENERGIZE AND THE ENGINE TO START RUNNING, AGAIN WITH NO KEY IN THE IGNITION. I AM ABLE TO ALWAYS REPRODUCE THIS MALFUNCTION. I IMMEDIATELY DISCONNECT THE BATTERY EACH TIME, AS I CONSIDER THIS MALFUNCTION TO BE POTENTIALLY HAZARDOUS, AND I CANNOT PREDICT WHAT FURTHER MALFUNCTION MIGHT ENSUE. I ACQUIRED THIS VEHICLE USED ~12 MONTHS AGO, AND IT HAS RUN NORMALLY UNTIL NOW. CURRENT MILEAGE ~81,700. THERE HAVE BEEN NO MODIFICATIONS TO THE ELECTRICAL SYSTEM.
NHTSA ODI #11399982
109,000 miles · Dec 17, 2020
Electrical System
WHILE I WAS DRIVING, ALL THE DASHBOARD GAUGES QUIT WORKING AND THE LIGHTS WENT OFF. I WAS DRIVING AT NIGHT SO IT WAS A LITTLE CONCERNING SINCE I COULDN'T SEE ANYTHING ON MY DASHBOARD AND THE SPEEDOMETER WASN'T WORKING. I WAS TOLD THE BODY CONTROL MODULE IS BAD AND AFTER LOOKING AT FORUMS, IT SEEMS THIS IS AN ISSUE AMONGST MANY F…
Read full complaint
WHILE I WAS DRIVING, ALL THE DASHBOARD GAUGES QUIT WORKING AND THE LIGHTS WENT OFF. I WAS DRIVING AT NIGHT SO IT WAS A LITTLE CONCERNING SINCE I COULDN'T SEE ANYTHING ON MY DASHBOARD AND THE SPEEDOMETER WASN'T WORKING. I WAS TOLD THE BODY CONTROL MODULE IS BAD AND AFTER LOOKING AT FORUMS, IT SEEMS THIS IS AN ISSUE AMONGST MANY FORD TRANSIT OWNERS. IT SEEMS UNSAFE THAT THAT CAN HAPPEN WHILE DRIVING. I CHECKED TO SEE IF THERE WAS A RECALL SINCE IT SEEMS SO MANY PEOPLE HAVE AN ISSUE AND LOOKS LIKE THERE ISN'T.
NHTSA ODI #11383990
77,000 miles · Dec 1, 2020
Electrical System
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE CHECK AT WORLD FORD/KENDALL (15551 W DIXIE HWY, MIAMI, FL 33162, (800) 739-1959). AFTER RETRIEVING THE VEHICLE, THE CONTACT DROVE THE VEHICLE TO HIS RESIDENCE. THE FOLLOWING DAY DURING RAINY WEATHER, WHILE ATTEMPTING T…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE CHECK AT WORLD FORD/KENDALL (15551 W DIXIE HWY, MIAMI, FL 33162, (800) 739-1959). AFTER RETRIEVING THE VEHICLE, THE CONTACT DROVE THE VEHICLE TO HIS RESIDENCE. THE FOLLOWING DAY DURING RAINY WEATHER, WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE FAILED TO TURN OVER. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED AND DETERMINED THAT WATER ENTERED THE ELECTRICAL COMPARTMENT CAUSING THE FUSE TO FAIL. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED DURING A RAINY DAY. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 18V275000 (ELECTRICAL SYSTEM) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 77,000. THE VIN WAS NOT INCLUDED.
NHTSA ODI #11377282
24,500 miles · Jan 9, 2019
Electrical SystemEngineFuel/propulsion System
THE VEHICLE RANDOMLY DEVELOPED HESITATION TO START ONE DAY AS IF IT WASN'T GETTING ENOUGH FUEL OR AIR. IT DID START AND I DROVE HOME FROM WORK. I PLANNED TO TAKE IT TO A DEALERSHIP TO GET IT CHECKED OUT BUT THE NEXT DAY BUT THE VEHICLE WOULD NOT START. I ATTEMPTED TO JUMP-START BUT THE BATTERY WAS AT FULL VOLTAGE. I HAD TH…
Read full complaint
THE VEHICLE RANDOMLY DEVELOPED HESITATION TO START ONE DAY AS IF IT WASN'T GETTING ENOUGH FUEL OR AIR. IT DID START AND I DROVE HOME FROM WORK. I PLANNED TO TAKE IT TO A DEALERSHIP TO GET IT CHECKED OUT BUT THE NEXT DAY BUT THE VEHICLE WOULD NOT START. I ATTEMPTED TO JUMP-START BUT THE BATTERY WAS AT FULL VOLTAGE. I HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY DIAGNOSED THE CAR. I WAS INFORMED THE NEXT DAY BY THE TECHNICIAN THAT THERE WAS A TSB ABOUT THIS ISSUE AND THAT FORD MOTOR COMPANY WAS WELL AWARE OF THE PROBLEM AND THAT IT WOULD COST ME $850 PLUS TAX. APPARENTLY THE CABIN AIR FILTER IS NOT PROPERLY WEATHER SEALED AND UNDER NORMAL USE WATER WILL MAKE ITS WAY INTO THE FILTER, AND INTO THE MASS AIR SENSOR. FORD HAS MADE NEW REPLACEMENT PARTS FOR THIS ISSUE BUT BECAUSE I AM OUT OF WARRANTY BY A FEW MONTHS, I WILL HAVE TO PAY FOR THE ENTIRETY OF THE BILL. HAD THE PART GIVEN OUT WHILE DRIVING (ESPECIALLY AT HIGH SPEEDS) THE ENGINE WOULD SEIZE AND COULD HAVE LIKELY CAUSED A CRASH.
NHTSA ODI #11166133
48,000 miles · Dec 9, 2017
Electrical SystemFuel/propulsion System
SLIDING DOOR ALERT KEEPS GOING OFF. POSSIBLE SENSOR OR LATCH DEFECT. HAPPENS WHILE DRIVING OVER DIPS, BUMPS AND WHILE BRAKING. UNABLE TO READ DASH SYSTEM PANEL WHILE ALERT IS ON. POSSIBLE SAFETY ISSUE, AS CANNOT SEE OTHER ALERTS WHILE THIS ONE IS ON, AS IT REMAINS ON THE ENTIRE TIME I'M DRIVING AND IS A DISTRACTION. POSSIBLE SAF…
Read full complaint
SLIDING DOOR ALERT KEEPS GOING OFF. POSSIBLE SENSOR OR LATCH DEFECT. HAPPENS WHILE DRIVING OVER DIPS, BUMPS AND WHILE BRAKING. UNABLE TO READ DASH SYSTEM PANEL WHILE ALERT IS ON. POSSIBLE SAFETY ISSUE, AS CANNOT SEE OTHER ALERTS WHILE THIS ONE IS ON, AS IT REMAINS ON THE ENTIRE TIME I'M DRIVING AND IS A DISTRACTION. POSSIBLE SAFETY ISSUE. CHECK ENGINE LIGHT ON FUEL SYSTEM SENSOR ISSUES. AFTER PUTTING FUEL IN VEHICLE IT HAS TROUBLE RESTARTING, CAUSING ME TO FUEL VEHICLE WHILE STARTED TO REMEDY THIS. POSSIBLE FIRE HAZARD, COULD CAUSE VEHICLE TO CATCH FIRE RESULTING IN EXPLOSION/DEATH.
NHTSA ODI #11053687
Mileage unknown · Sep 15, 2017
Electrical System
CLUSTER HAVE MASSAGE FAULT FILTER IS OVERLOADED. I HAVE CHANGE DPF FILTER AND SENSORS 3 MINES AGO. AND DPF SISTEM IS WORKING PROPERLY NO ANY CODES BUT CLUSTER STILL HAVE A MASSAGE
NHTSA ODI #11023635
80,000 miles · Aug 18, 2017
Electrical System
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 40 MPH, THE INDICATORS ON THE INSTRUMENT CLUSTER BEGAN TO FLASH AND THE VEHICLE BEGAN TO CHIME. THE VEHICLE STALLED AND WAS UNABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO ALL AMERICAN FORD (HACKENSACK 520 RIVER ST, HACKENSACK, NJ 07601) WHERE IT WAS DIAGNOSED THAT A GPS I…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 40 MPH, THE INDICATORS ON THE INSTRUMENT CLUSTER BEGAN TO FLASH AND THE VEHICLE BEGAN TO CHIME. THE VEHICLE STALLED AND WAS UNABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO ALL AMERICAN FORD (HACKENSACK 520 RIVER ST, HACKENSACK, NJ 07601) WHERE IT WAS DIAGNOSED THAT A GPS IN THE VEHICLE CAUSED THE FAILURE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO ALL AMERICAN FORD. THE DEALER REVISED THE DIAGNOSIS AND STATED THAT THE ELECTRICAL CLUSTER FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO ALL AMERICAN FORD WHERE IT WAS DIAGNOSED THAT THE PCM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED ONCE AGAIN. THE VEHICLE WAS TAKEN BACK TO ALL AMERICAN FORD WHERE IT WAS DIAGNOSED THAT THE WIRING IN THE VEHICLE CAUSED THE FAILURE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V406000 (ELECTRICAL SYSTEM) AND THE CONTACT NEEDED TO CONTINUE TO WORK WITH THE DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 10/18/17*LJ *JS
NHTSA ODI #11016138
2,000 miles · Sep 12, 2016
Electrical SystemLatches/locks/linkagesPower Train
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 65 MPH ON A WET SURFACE, THE ACCELERATOR PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE ACCELERATOR PEDAL WAS DEPRESSED TO THE FLOORBOARD AND A KNOCKING SOUND EMITTED FROM THE VEHICLE. THE VEHICLE INDEPENDENTLY SHIFTED INTO FIRST GEAR. THE VEHICLE WAS TAKEN …
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD TRANSIT. WHILE DRIVING 65 MPH ON A WET SURFACE, THE ACCELERATOR PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE ACCELERATOR PEDAL WAS DEPRESSED TO THE FLOORBOARD AND A KNOCKING SOUND EMITTED FROM THE VEHICLE. THE VEHICLE INDEPENDENTLY SHIFTED INTO FIRST GEAR. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MAIN WIRING NEEDED TO BE WRAPPED WITH REFLECTIVE TAPE. THE VEHICLE WAS REPAIRED. IN ADDITION, THE REAR PASSENGER SIDE CARGO DOORS FAILED TO LATCH PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED NOR REPAIRED. WHILE DRIVING AT VARIOUS SPEEDS, THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,000.
NHTSA ODI #10905749
Official recalls
26Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
Oct 25, 2019
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
Apr 29, 2019
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
Apr 26, 2019
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
Apr 18, 2019
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
Apr 3, 2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
Mar 28, 2019
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
Mar 26, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
Mar 18, 2019
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
Mar 6, 2019
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Nov 6, 2018
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
Apr 30, 2018
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
Jun 26, 2017
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
Aug 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence & remedy
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Additional source detail variants (2)
Fuel System, Diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Engine And Engine Cooling:engine:diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
May 24, 2016
New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
May 20, 2016
National Van Builders, Inc. (National Van) is recalling certain model year 2015 Ford Transit vehicles manufactured July 1, 2015, to October 30, 2015, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: National Van will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 15, 2016. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon 2016.
Apr 4, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence & remedy
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
Feb 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence & remedy
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
Dec 22, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured May 1, 2015, to June 26, 2015, and equipped with dual rear wheels. The affected vehicles have a left or right rear axle drive shafts that may fracture, resulting in loss of drive power. Additionally, the vehicle may unexpectedly roll if it is parked without the parking brake applied.
Consequence & remedy
Consequence: A loss of drive power or vehicle rollaway after being parked can increase the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the left and right axle drive shafts, free of charge. The recall began February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S37.
Jun 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured March 1, 2015, to April 10, 2015. The affected vehicles may have been built with seat belt assemblies that have seat belt labels that are missing the required belt model and model year and instead state "prototype sample." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: In the event of a safety issue with the affected seat belts, the vehicle owner may not be able to identify the seat belt if the seat belt label does not include a date of manufacturer.
Remedy: Ford has notified the one fleet owner affected, and a Ford representative will travel to the vehicle locations to install a new label that includes all of the required information. There will be no charge for this service. The recall began on June 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C05.
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Transit vehicles manufactured July 28, 2014, to August 7, 2014. In the affected vehicles the fuel filter bracket mounting may detach from the frame cross member over time.
Consequence & remedy
Consequence: A separation of the fuel filter from the cross member will disrupt distribution of fuel to the engine, thereby inducing an engine stall. An unexpected engine stall while driving increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate, free of charge. The recall began on December 19, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S23.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence & remedy
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:disc:caliper
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain model year 2015 Transit vehicles manufactured April 3, 2014, to May 27, 2014. Brake fluid may leak from the brake hose/caliper junctions at the rear of the vehicle.
Consequence: A brake fluid leak may lengthen the distance needed to stop the vehicle. If both of the rear brake junctions leak, there may a complete loss of braking. Either of these scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the sealing washers on both rear brake caliper to brake hose joints, free of charge. The recall began in August 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S15.
Aug 6, 2014
Ford Motor Company (Ford) is recalling certain model year 2015 Transit cargo vans without rear seating positions manufactured March 12, 2014, to June 24, 2014 and equipped with windowless sliding doors. The affected vehicles may have been manufactured without the epoxy reinforcement on the windowless sliding doors.
Consequence & remedy
Consequence: A sliding door without the epoxy reinforcement has an increased potential of unlatching in certain side impact crashes. A door that unlatches may open, allowing for a vehicle occupant to be ejected in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will install a reinforcement plate into the windowless sliding door, free of charge. The recall began in September 22, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S16.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration