1997 Ford Thunderbird

MY WIFE DROVE HER 1997 FORD THUNDERBIRD TO WORK TODAY. SHE PARKED HER CAR IN THE COMPANY GARAGE AND WALKED INTO WORK. THE CAR THEN BEGAN TO BURN AND TOTALED THE CAR. AFTER HAVING IT TOWED TO A LOCAL GARAGE, BASED UPON THE KNOWLEDGE OF THE MECHANIC, TO WHOM, I HAVE USED TO SERVICE MY VEHICLES FOR OVER 10 YEARS, TOLD ME THAT THE INTENSITY OF THE FIRE WAS NEAR THE STEERING COLUMN, AND AND POWER STEERING SWITCHES. UPON RESEARCHING THE ABOVE FACTS, FOUND THE RECALL ABOUT THE VARIOUS FORD TRUCKS AND THIS SIMILAR PROBLEM. WE HAVE LIABILITY INSURANCE ON THIS CAR, AND NOW WE HAVE LOST THE CAR TO NO FAULT OF OUR OWN. ARE THERE OTHER FORD CARS WITH THE SAME PROBLEM?

TL*THE CONTACT OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 40 MPH, IN HEAVY TRAFFIC THE CONTACT NOTICED SMOKE RISING FROM UNDER THE HOOD. THE TEMPERATURE GAUGE NEEDLE SHIFTED TO THE HOT INDICATOR. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE ENGINE WAS LEAKING COOLANT AND THE PLASTIC INTAKE MANIFOLD WAS CRACKED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 73,500. *UPDATED 12/12/07 *BF UPDATED 12/12/07

TL*THE CONTACT'S DAUGHTER OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED AND THE CONTACT NOTICED THAT ANTIFREEZE WAS LEAKING. HER DAUGHTER NOTICED A CRACK ON THE INTAKE MANIFOLD, WHICH SHE BELIEVED MAY BE THE CAUSE OF FAILURE. AS OF AUGUST 31, 2007, THE DEALER HAS NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 60,000.

MY MECHANIC HAS INFORMED ME OF A DANGEROUS SITUATION WITH MY AUTOMOBILE THAT COULD LEAD TO AN ACCIDENT. ALL THE BALL JOINTS IN THE FRONT END ARE WORN EXCESSIVELY. HE SAYS THE EXCESSIVE WEAR IS A RESULT OF THE DUST SEALS DISINTEGRATING ALLOWING DIRT AND WATER TO ENTER THE BALL JOINTS. HE INDICATED THAT THIS IS PROBABLY A RESULT OF THE USE OF INAPPROPRIATE OR DEFECTIVE MATERIALS FOR THE SEALS. I AM GOING TO HAVE THE BALL JOINTS REPLACED. I WILL ASK THE MECHANIC TO KEEP THE OLD PARTS FOR ME. *NM

DT: THE CONTACT STATED THE FLOOR SHIFTER WAS STICKING IN PARK WHEN THE WEATHER WAS COLD. IT TOOK FIVE TO TEN MINUTES TO MOVE THE SHIFTER INTO OTHER GEARS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE DEALER SAID THE PART WAS UNAVAILABLE, AND THEY WOULD HAVE TO GO TO A JUNK YARD TO LOCATE ANOTHER SHIFTER. NO REPAIRS HAVE BEEN MADE. *AK

I PURCHASED THIS 1997 FORD THUNDERBIRD LX SPORT AS A USED VEHICLE IN OCT. 2002. I NOTICED THAT DURING THE FIRST FEW WEEKS OF OWNING THIS VEHICLE IT WOULD INTERMITTENTLY LEAK A SUBSTANTIAL AMOUNT OF COOLANT ONTO MY DRIVEWAY BUT I COULD NEVER SEE WHERE IT WAS COMING FROM. SOMETIMES IT WOULD GO FOR DAYS WITHOUT LEAKING AND THEN ONE DAY THERE WOULD BE OVER A QUART OF COOLANT ON THE DRIVEWAY. I BROUGHT THE CAR INTO A SHOP THAT PUT THE CAR ON A LIFT TO LOOK FOR THE LEAK BUT THEY COULD NOT FIND ONE. I CONTINUED TO DRIVE THE CAR AND ADD COOLANT EVERY TIME THE "LOW COOLANT" LIGHT APPEARED ON THE DASH PANEL. IN MAY 2005 I WAS ON THE 91 FREEWAY AND SUDDENLY WITHOUT WARNING THE "LOW COOLANT" LIGHT CAME ON AND THE TEMP CAME UP QUICKLY SO I TRIED TO CHANGE LANES TO THE RIGHT TO EXIT THE FREEWAY AND THE BACK OF THE CAR BROKE LOOSE AND I ALMOST TURNED SIDEWAYS. I FOUND OUT LATER THAT THE REAR TIRES AND WHEEL WELLS WERE SOAKED IN COOLANT. THIS WAS THE FIRST TIME THAT I FOUND OUT THAT MY INTERMITTENT LEAK THAT NO ONE COULD FIND WAS MY INTAKE MANIFOLD AT THE BASE OF THE THERMOSTAT HOUSING. I WENT TO RANCHO SANTA MARGARITA FORD AND ASKED ABOUT RECALLS AND THEY TOLD ME THAT THE RECALL FOR THE INTAKE MANIFOLD HAD EXPIRED A COUPLE OF MONTHS AGO AND THAT THERE WAS NOTHING THAT THEY COULD DO. I CALLED FORD MOTOR CO. CUSTOMER RELATIONS AND WAS TOLD THE SAME THING. THE CAR NOW SITS PARKED UNREPAIRED. I CANNOT AFFORD TO PAY ALMOST TWO THOUSAND DOLLARS TO CORRECT FORDS ENGINEERING BLUNDER. *JB