IllustrationCRACKED INTAKE ON MY 97 T BIRD. *JB
1997 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
00–25K
525–50K
2250–75K
1275–100K
6100–150K
3150K+
48 reports with mileage · 121 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports3 fire reports5 injury reports
Engine And Engine Cooling complaints
54 reportsENGINE MANIFOLD CRACKED ALLOWING ANTIFREEZE TO ESCAPE. TOOK CAR FOR REPAIR. LEARNED LATER THAT REPAIR WAS A RECALL. ASKED FORD FOR REIMBURSEMENT. REIMBURSMENT DENIED.*AK
I AM THE ORIGINAL OWNER OF A 1997 FORD THUNDER BIRD WITH THE 4.6 ENGINE. THE INTAKE MANIFOLD IS CRACKED . I HAVE BEEN INFORMED THIS IS A RECALLED PART ON SOME CARS BUT IT SEEMS MY CAR IS NOT INCLUDED IN THE RECALL. THE ORIGINAL REPAIR PART IS NOT AVAILABLE ANY LONG DO TO THE FLAW. SINCE THIS IS THE CASE IT WOUD SEEM TO ME ALL VE…
Read full complaint
I AM THE ORIGINAL OWNER OF A 1997 FORD THUNDER BIRD WITH THE 4.6 ENGINE. THE INTAKE MANIFOLD IS CRACKED . I HAVE BEEN INFORMED THIS IS A RECALLED PART ON SOME CARS BUT IT SEEMS MY CAR IS NOT INCLUDED IN THE RECALL. THE ORIGINAL REPAIR PART IS NOT AVAILABLE ANY LONG DO TO THE FLAW. SINCE THIS IS THE CASE IT WOUD SEEM TO ME ALL VEHICLES WITH THIS INTAKE MANIFOLD WOULD BE INCLUDED IN THE RECALL. *AK
I WAS DRIVING MY CAR TO PAY THE POWER BILL. I HAD MADE A COMPLETE STOP AND THEN TURNED LEFT UP THE ROAD ABOUT 4/10'S OF A MILE WHEN I PULLED INTO THE PARKING SPACE I NOTICED WHITE STEAM COMING FROM THE ENGINE COMPARTMENT. I OPENED THE HOOD A THE ENGINE WAS COVERED IN ANTIFREEZE. I CALLED FOR A TOW HOPING IT WAS A BLOWN HOSE OR…
Read full complaint
I WAS DRIVING MY CAR TO PAY THE POWER BILL. I HAD MADE A COMPLETE STOP AND THEN TURNED LEFT UP THE ROAD ABOUT 4/10'S OF A MILE WHEN I PULLED INTO THE PARKING SPACE I NOTICED WHITE STEAM COMING FROM THE ENGINE COMPARTMENT. I OPENED THE HOOD A THE ENGINE WAS COVERED IN ANTIFREEZE. I CALLED FOR A TOW HOPING IT WAS A BLOWN HOSE OR AT WORST A HEAD GASKET. SO I DIDN'T DRIVE IT FURTHER TO PREVENT FURTHER DAMAGE. THE DEALERSHIP LOOKS AT IT AND SAYS IT IS A CRACKED INTAKE MANIFOLD. WHICH LEADS TO A $1135 BILL FOR PARTS AND LABOR. SOME ONLINE RESEARCH BROUGHT A CONCERN...IS THE INTAKE MANIFOLD PLASTIC? IF SO, WHY!? *NM
REQUEST FOR REIMBURSEMENT FOR REPLACEMENT OF THE INTAKE MANIFOLD. *MR THE CONSUMER WAS TOLD THAT THE MANIFOLD WOULD ONLY BE REPLACED UPON FAILURE. THE VEHICLE HAD BEEN LOSING ANTIFREEZE. EACH TIME THE VEHICLE WAS TAKEN TO THE DEALER, HE WAS TOLD THAT EVERYTHING WAS FINE. THE MANIFOLD FINALLY FAILED AND WAS OUT OF WARRAN…
Read full complaint
REQUEST FOR REIMBURSEMENT FOR REPLACEMENT OF THE INTAKE MANIFOLD. *MR THE CONSUMER WAS TOLD THAT THE MANIFOLD WOULD ONLY BE REPLACED UPON FAILURE. THE VEHICLE HAD BEEN LOSING ANTIFREEZE. EACH TIME THE VEHICLE WAS TAKEN TO THE DEALER, HE WAS TOLD THAT EVERYTHING WAS FINE. THE MANIFOLD FINALLY FAILED AND WAS OUT OF WARRANTY. THE DEALER WOULD NOT HONOR THE OPEN RECALL. THE CHECK ENGINE LIGHT WAS INTERMITTENT DUE TO A BAD SENSOR. *SC *JB
INTAKE MANIFOLD LEAKS. CONSUMER HAS TO PUT COOLANT IN THE VEHICLE EVERY 2 TO 3 DAYS. *AK
INTAKE MONIFOLD FAILED TO CONTAIN 220 DEGREE F ENGINE COOLANT. *AK
I HAD TO REPLACE THE COOLANT INLET MANIFOLD ON MY 1997 FORD THUNDERBIRD. THIS SHOULD HAVE BEEN COVERED BY FORD RECALL #97M91 BUT FOR SOME REASON FORD HAS EXCLUDED MY VIN NO. FROM THE RECALL. THIS PROBLEM WAS CLEARLY CAUSED BY A DEFECTIVE PART AND WAS REPLACED WITH AN "UPGRADED" PART.*AK
WHILE DRIVING VEHICLE STARTED TO MISFIRE AND STALL. INTAKE MANIFOLD CRACKED AND LEAKED ANTI FREEZE WHICH CAUSED THE PROBLEM. MANUFACTURER HAD AN OWNER NOTIFICATION ON THIS ISSUE TO REPLACE THE PLASTIC INTAKE MANIFOLD, BUT THIS VEHICLE NOT COVERED FOR TWO MONTHS DUE TO VIN. *AK
ENGINE DEVELOPED A COOLANT LEAK DUE TO A SPLIT IN THE PLASTIC INTAKE MANIFOLD. RECALL 97M91 WHICH IS ONLY GOOD FOR 7 YEARS FROM THE START OF THE ORIGINAL WARRANTY WAS UP 2 DAYS PRIOR TO INCIDENT. FOMOCO AND DEALER WOULDN'T COVER, TO BAD FOR ME. RECALL DOESN'T COVER REPLACEMENT UNLESS IT IS LEAKING WITHIN THAT 7 YEARS. DESIGN HAS…
Read full complaint
ENGINE DEVELOPED A COOLANT LEAK DUE TO A SPLIT IN THE PLASTIC INTAKE MANIFOLD. RECALL 97M91 WHICH IS ONLY GOOD FOR 7 YEARS FROM THE START OF THE ORIGINAL WARRANTY WAS UP 2 DAYS PRIOR TO INCIDENT. FOMOCO AND DEALER WOULDN'T COVER, TO BAD FOR ME. RECALL DOESN'T COVER REPLACEMENT UNLESS IT IS LEAKING WITHIN THAT 7 YEARS. DESIGN HAS BEEN CHANGED TO AN ALUMINUM CROSSOVER THAT HOPEFULLY WONT SPLIT AND COSTS APPROX $800 TO FIX. *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.