IllustrationVEHICLE EXPERIENCED FAILURE OF THE RECALL COMPONENT (96V-071) PRIOR TO RECALL NOTICE, RESULTING IN FIRE. *MJS
1992 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 184 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports11 fire reports8 injury reports
Exterior Lighting complaints
40 reportsRECALL # 99V275000 FORD/HEADLIGHTS; AFTER RECALL WAS PERFORMED OWNER WAS DRIVING AND THE HEADLIGHTS WENT OUT. DEALER WAS CONTACTED. AFTER CHARGING $55.00, DEALER STATED THAT PROBLEM WAS NOT RELATED TO THE RECALL, EVEN THOUGH THIS PROBLEM HAD TO DO WITH THE WIRING AS WELL. PROBLEM HAS NOT BEEN CORRECTED. *ML
NHTSA RECALL NO:99V275000 AND MANUFACTURER'S RECALL NO:99S30 CONCERNING HEADLIGHTS. NO PARTS WERE AVAILABLE, AND DEALER DIDN'T SAY WHEN THEY WILL BE AVAILABLE. *AK
ENGINE HEAD GASKET HAS BEEN LEAKING FOR A WHILE AND FINALLY WENT. HEARD NUMEROUS REPORTS AND READ ARTICALS RANGING FROM A SHOW BY 'MOTOR TREND ' TO DEALER COMMENTS ON THE PROBLEM WITH DEFECTIVE HEAD GASKETS IN 3.8L ENGINES. ALSO, KNOW NUMEROUS PEOPLE WITH AN ENGINE LIKE MINE ,HAVE EXPERIENCED THE SAME PROBLEM. THE "LIGHT BAR"…
Read full complaint
ENGINE HEAD GASKET HAS BEEN LEAKING FOR A WHILE AND FINALLY WENT. HEARD NUMEROUS REPORTS AND READ ARTICALS RANGING FROM A SHOW BY 'MOTOR TREND ' TO DEALER COMMENTS ON THE PROBLEM WITH DEFECTIVE HEAD GASKETS IN 3.8L ENGINES. ALSO, KNOW NUMEROUS PEOPLE WITH AN ENGINE LIKE MINE ,HAVE EXPERIENCED THE SAME PROBLEM. THE "LIGHT BAR" INSIDE THE TAILLIGHTS ARE ANOTHER PROBLEM, YOU DON'T SEE A T-BIRD ON THE ROAD TODAY THAT DOESN'T HAVE AT LEAST PART OF THEIR TAIL LIGHTS BURNED OUT SO I KNOW ITS NOT JUST MINE AND THEY STARTED DOING THIS MANY MILES AGO! I TAKE GOOD CARE OF MY VEHICLES,SO I KNOW THIS IS NOT FROM ABUSE! LIKE I SAID WHEN DEALERS TELL YOU THEY'RE HAVING A PROBLEM WITH CERTAIN PARTS AND CAR SHOWS,MAGAZINES , AND CONSUMER REPORTS SAY THERE IS SOMETHING WRONG WITH AHEAD GASKET ON A CERTAIN ENGINE YOU KNOW YOU'RE NOT ALONE! REPLACING A HEAD GASKET IS AN EXPENSIVE REPAIR , I THOUGHT I WOULD CHECK INTO THIS BEFORE FOOTING THE BILL MYSELF. PLEASE LET ME KNOW AS SOON AS YOU CAN IF ANYTHING CAN BE DONE ABOUT THIS AS I'M NOT ABLE TO DRIVE THE CAR ...THANKS ,LYNN. *AK
MULTI-FUNCTION SWITCH FAILED. NLM
WHILE DRIVING HEADLIGHTS GO OFF UNKNOWNGLY. SOMETIMES THE HEADLIGHTS WILL COME BACK ON WITHIN A FEW SECONDS AND SOMETIMES THEY DO NOT. THERE HAS BEEN 3 DIFFERENT REPAIRS DONE TO THE HEADLIGHTS, WHICH HAVE NOT DONE ANY GOOD. WHEN CONTACTING FORD CUSTOMER SERVICE, OWNER WAS INFORMED THAT VEHICLE WAS NOT INCLUDED IN RECALL 99V275…
Read full complaint
WHILE DRIVING HEADLIGHTS GO OFF UNKNOWNGLY. SOMETIMES THE HEADLIGHTS WILL COME BACK ON WITHIN A FEW SECONDS AND SOMETIMES THEY DO NOT. THERE HAS BEEN 3 DIFFERENT REPAIRS DONE TO THE HEADLIGHTS, WHICH HAVE NOT DONE ANY GOOD. WHEN CONTACTING FORD CUSTOMER SERVICE, OWNER WAS INFORMED THAT VEHICLE WAS NOT INCLUDED IN RECALL 99V275000 FORD/HEADLIGHTS DUE TO VIN. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
WHEN USING THE FOG LIGHTS THEY FLASH ON AND OFF EVERYTIME HEADLAMPS ARE CHANGED, PROBLEM OCCURS REGULARLY. *AK
NO SUMMARY
THE HEADLIGHTS STARTED FLICKERING AFTER IGNITION SWITCH WAS RECALLED AND REPLACED. I WAS TRAVELING FROM A FUNERAL WHEN THE LIGHTS STARTED WHILE ON THE INTERSTATE AT AROUND 2300 HRS.
OIL PRESSURE GAUGE DESIGN IS A PHONEY GAUGE, CIRCUIT IS RUN THROUGH A FIXED RESISTOR WHICH READS NORMAL ON ALL OCCASIONS. MJS
Official recalls
399V275000 · Exterior Lighting:headlights:switch
Oct 12, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
97V159000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 22, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA99005 · Headlight Switch
Opened Jan 20, 1999 · Closed Dec 14, 1999
Status: closed (inferred from source dates) · Exterior Lighting
SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION.
RQ98015 · Headlight Circuit Breaker
Opened Sep 29, 1998 · Closed Jan 22, 1999
Status: closed (inferred from source dates) · Exterior Lighting:headlights:switch
HEADLIGHT SWITCH WITH AN ITERNAL, BIMETAL CIRCUIT BREALER THAT MAY OPEN DUE TO OVERHEATING DURING HEADLIGHT OPERATION
RQ97011 · Fuel Line Jumper
Opened Sep 25, 1997 · Closed Nov 16, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY
EA95030 · Rear Fuel Line Interference
Opened Oct 31, 1995 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE REAR FUEL TUBE BUNDLE MAY ABRADE AND FAIL IN THE VICINITY OF THE FUEL TANK.
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available