IllustrationDT*: THE CONTACT STATED LOSING CONTROL OF THE VEHICLE AND HITTING A GUARD RAIL WHILE TRAVELING 45 MPH. THE VEHICLE SUSTAINED MINOR PAINT DAMAGE. AFTER BEING DRIVEN TO THE CONTACT'S RESIDENCE, THE CONTACT REPAIRED THE VEHICLE AND REPLACED A STABILIZER BAR.
1996 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1996 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 93 of 825 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 214 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
69 crash reports12 fire reports45 injury reports
What owners actually said
825 reportsABOUT 30 SECONDS AFTER THE CAR HAD BEEN PARKED AND THE ENGINE TURNED OFF, THE FRONT LEFT TIRE EXPLODED. THE TIRE HAD A DAMAGED AREA ON THE INSIDE SIDEWALL. THE DAMAGED AREA WAS APPROXIMATELY 5 INCHES LONG AND WAS CENTERED ON THE SIDEWALL IN A CIRCUMFERENTIAL ORIENTATION. THE TIRE WAS REPLACED AT THE DEALER WHERE IT HAD BEEN P…
Read full complaint
ABOUT 30 SECONDS AFTER THE CAR HAD BEEN PARKED AND THE ENGINE TURNED OFF, THE FRONT LEFT TIRE EXPLODED. THE TIRE HAD A DAMAGED AREA ON THE INSIDE SIDEWALL. THE DAMAGED AREA WAS APPROXIMATELY 5 INCHES LONG AND WAS CENTERED ON THE SIDEWALL IN A CIRCUMFERENTIAL ORIENTATION. THE TIRE WAS REPLACED AT THE DEALER WHERE IT HAD BEEN PURCHASED. *NM
I HAVE A 1996 TAURUS GL. THE CAR LEAKS OIL, AND THEN IT LEAKED TRANSMISSION FLUID FROM THE PAN. THE MAIN PROBLEM WITH THIS CAR IS THE OIL LEAK. I SPENT 500 TO GET IT FIXED AND THE DARN THING STOPPED LEAKING AND NOW IT LEAKS AGAIN. I HAVE A FRIEND THAT HAS A 1997 AND HER CAR LEAKS ALSO. WHY DID FORD MAKE A PRODUCT THAT LEAKS LIK…
Read full complaint
I HAVE A 1996 TAURUS GL. THE CAR LEAKS OIL, AND THEN IT LEAKED TRANSMISSION FLUID FROM THE PAN. THE MAIN PROBLEM WITH THIS CAR IS THE OIL LEAK. I SPENT 500 TO GET IT FIXED AND THE DARN THING STOPPED LEAKING AND NOW IT LEAKS AGAIN. I HAVE A FRIEND THAT HAS A 1997 AND HER CAR LEAKS ALSO. WHY DID FORD MAKE A PRODUCT THAT LEAKS LIKE A SIV. *NM
I CURRENTLY OWN A 1996 FORD TAURUS. BY A FLUKE, I WAS RECENTLY NOTIFIED BY A MECHANIC THAT THE SUB-FRAME ON THE PASSENGER SIDE WAS CORRODED BEYOND REPAIR. I WAS ALSO TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE. THERE IS NO OTHER RUST ON THE VEHICLE, WHICH WOULD INDICATE A MANUFACTURERS DEFECT. I HAVE CONTACTED FORD CUSTOMER SE…
Read full complaint
I CURRENTLY OWN A 1996 FORD TAURUS. BY A FLUKE, I WAS RECENTLY NOTIFIED BY A MECHANIC THAT THE SUB-FRAME ON THE PASSENGER SIDE WAS CORRODED BEYOND REPAIR. I WAS ALSO TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE. THERE IS NO OTHER RUST ON THE VEHICLE, WHICH WOULD INDICATE A MANUFACTURERS DEFECT. I HAVE CONTACTED FORD CUSTOMER SERVICE AND THEY ARE UNWILLING TO DEAL WITH THE PROBLEM EVEN THOUGH I HAVE CHECKED THE INTERNET AND FOUND SEVERAL EXAMPLES OF THE SAME PROBLEM. THIS IS A HUGE SAFETY ISSUE. THIS IS THE MAIN SUPPORT, WHICH HOLDS UP THE ENGINE AND TRANSMISSION. IF IT WERE TO SUDDENLY DROP, STEERING WOULD BECOME IMPOSSIBLE. I HAVE TO BELIEVE THAT THERE ARE MANY PEOPLE OUT THERE DRIVING WITH THIS SAME PROBLEM AND DO NOT REALIZE IT, JUST AS I DIDN'T. I AM ASKING THAT YOU CHECK INTO THIS FURTHER AND TO PROTECT OUR CITIZENS. THANK YOU, JAMES MEHRING. *NM
WOULD NOT GO TO FOURTH GEAR WHILE EXCHANGING LANES WAS HIT IN THE REAR. *JB
FRONT DRIVER SIDE COIL UNEXPECTEDLY SNAPPED WHILE AT A STOP SIGN AND PUNCTURED TIRE. DRIVER WAS ABLE TO ROLL INTO A NEAR LOT. *JB
I BACKED MY 1996 FORD TAURUS OUT OF THE GARAGE AFTER A COUPLE OF WEEKS SITTING AND THE RIGHT FRONT SPRING BROKE AND PUNCTURED THE RIGHT TIRE. THERE WAS NO SAGGING OF THE CAR OR WARNING THAT THE SPRING WAS ABOUT TO BREAK. I TOWED THE CAR TO THE DEALER AND BOTH FRONT SPRINGS WERE FIXED. *NM
SPARE TIRE EXPLODED WHILE IN SIDE COMPARTMENT. *TS TWO YEARS AGO THE SPARE TIRE EXPLODED. THE CONSUMER REPLACED IT WITH A USED SPARE BECAUSE HE WAS UNABLE TO LOCATE A NEW SPARE. THE USED SPARE WAS PLACED IN THE SPARE TIRE COMPARTMENT WHERE IT LATER BLEWOUT. THE CONSUMER HAS THE TIRE IN HIS POSSESSION. *NM
AIRBAG WARNING LIGHT CAME ON FOR 2 DAYS. WENT OUT BEFORE SCHEDULED SERVICE AT DEALER. NO DIAGNOSTIC CODE WAS RETURNED. DEALER ADVISED TO RETURN CAR IMMEDIATELY IF LIGHT WENT ON AGAIN. APPROXIMATELY A WEEK LATER LIGHT WENT ON AGAIN, CAR WAS RETURNED TO DEALER WITH LIGHT ON AND AN "UNKNOWN CODE" WAS RETURNED BY DIAGNOSTIC UNIT. AP…
Read full complaint
AIRBAG WARNING LIGHT CAME ON FOR 2 DAYS. WENT OUT BEFORE SCHEDULED SERVICE AT DEALER. NO DIAGNOSTIC CODE WAS RETURNED. DEALER ADVISED TO RETURN CAR IMMEDIATELY IF LIGHT WENT ON AGAIN. APPROXIMATELY A WEEK LATER LIGHT WENT ON AGAIN, CAR WAS RETURNED TO DEALER WITH LIGHT ON AND AN "UNKNOWN CODE" WAS RETURNED BY DIAGNOSTIC UNIT. APPROX 3 WEEKS LATER, WITHOUT WARNING, PASSENGER SIDE FRONT AIRBAG DEPLOYED SPONTANEOUSLY. CAR FILLED WITH POWDER MAKING VISIBILITY IMPOSSIBLE, AND THE FORCE OF THE AIRBAG DEPLOYMENT SHATTERED AND PUSHED OUT THE PASSENGER SIDE OF THE WINDSHIELD, SCATTERING SHARDS OF GLASS ALL OVER THE FRONT SEAT. *JB
1996 FORD TAURUS LX BRAKE LINES HAVE DEVELOPED A RUST PROBLEM.***NO ANSWER REQUIRED***. *MR THE CONSUMER STATED NEARLY EVERY PART OF THE BRAKE LINE THAT WAS NOT RUBBER COATED HAD RUSTED THROUGH. *JB
Official recalls
698V067000 · Fuel System, Gasoline:storage:tank Assembly
Mar 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.
Consequence & remedy
Consequence: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.
96V176000 · Power Train:automatic Transmission
Sep 18, 1996
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.
96V166000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 5, 1996
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.
Consequence & remedy
Consequence: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.
96V151000 · Fuel System, Gasoline:fuel Injection System
Aug 12, 1996
THE FUEL PRESSURE REGULATOR LOCATED ON THE FUEL RAIL IN THE ENGINE COMPARTMENT HAS A VACUUM DIAPHRAGM THAT WAS DAMAGED DURING MANUFACTURE OF THE REGULATOR.
Consequence & remedy
Consequence: IF THE DIAPHRAGM TEARS OR RUPTURES, LIQUID FUEL COULD ENTER THE INTAKE MANIFOLD PLENUM THROUGH THE VACUUM LINE RESULTING IN EITHER RELEASE OF FUEL FROM THE AIR CLEANER ASSEMBLY OR THE EXHAUST SYSTEM. FUEL RELEASE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PRESSURE REGULATOR. THOSE REGULATORS PRODUCED DURING THE SUSPECT TIME PERIOD WILL BE REPLACED.
96V086000 · Power Train:automatic Transmission
May 14, 1996
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.
96V016000 · Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
Jan 25, 1996
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.
Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.