IllustrationHEAD GASKET BLEW LEAVING ME STRANDED ON HIGHWAY, THE TRANSMISSION FAILED AND LOCKED UP ON THE HIGHWAY CAUSING THE CAR TO SLOW RAPIDLY AS IF BRAKING LEAVING ME TO CROSS SEVERAL LANES OF TRAFFIC TO PULL OVER TO THE SHOULDER WHERE I WAS STRANDED. *AK
1994 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1994 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 67 of 923 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 289 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports23 fire reports30 injury reports
Power Train complaints
269 reportsCONSUMER STOPPED FOR A STOP LIGHT AND VEHICLE DIED, TOOK TO A MECHANIC AND THEY SAID IT WAS TRANSMISSION. *AK *ML
VEHICLE EXPERIENCING PROBLEM WITH SPEEDOMETER OPERATING ERRATICALLY. REPLACEMENT HAVE BEEN MADE ON TWO OCCASIONS WITHIN 30,000 MILES. BUT PROBLEM REOCCURRED PRESENTLY AT 68,000 MILES. DEALER NOTIFIED,AND REFUSED TO REPAIR UNLESS COST GOES TO CONSUMER. *AK
WHILE DRIVING ON HIGHWAY ENGINE CHECK LIGHT CAME ON. PULLED OVER AND WAS TOWED TO THE DEALER. THEY PUT IN A NEW ENGINE. ALSO, UPON GOING DOWN THE STREET IT FELT LIKE VEHICLE WAS NOT IN GEAR AND WAS COASTING. TOWED TO A LOCAL MECHANIC, AND HE REBUILT THE TRANSMISSION. *AK
TRANSMISSION FAILURES (2ND NOW) INCLUDE INTERMITTENT NEUTRAL CONDITIONS AT 65 MPH. STEERING PROBLEM IS SOMETHING THAT MY DEALER HAS YET TO ,BUT IS REPRODUCIBLE. *AK
CONSUMER STATED THAT THERE WAS A CRACKED PISTON INSDE TRANSMISSION. DEALERSHIP HAD TO OVERHAUL ENTIRE TRANSMISSION BECAUSE MECHANIC SAW MORE DAMAGE THEN IT WAS ANTICIPATED. *AK
ON OR ABOUT 2/26/2000 WHILE DRIVING IN AIKEN, SC I ATTEMPETED TO MAKE A LEFT HAND TURN AND MY CAR DISENGAGED WHILE IN GEAR AND MY CAR WAS ALMOST HIT BY A SEMI-TRACTOR TRUCK. MY FATHER AND MY HUSBAND HAVE HAD IT CHECKED OUT BY QUALIFIED MECHANICS, AND THEY TELL US IT IS THE FORWARD CLUTCH PISTON IN THE TRANSAXLE. THERE HAVE BEE…
Read full complaint
ON OR ABOUT 2/26/2000 WHILE DRIVING IN AIKEN, SC I ATTEMPETED TO MAKE A LEFT HAND TURN AND MY CAR DISENGAGED WHILE IN GEAR AND MY CAR WAS ALMOST HIT BY A SEMI-TRACTOR TRUCK. MY FATHER AND MY HUSBAND HAVE HAD IT CHECKED OUT BY QUALIFIED MECHANICS, AND THEY TELL US IT IS THE FORWARD CLUTCH PISTON IN THE TRANSAXLE. THERE HAVE BEEN TECHNICAL SERVICE BULLITENS (TSB) PUT OUT BY FORD MOTOR COMPANY SINCE 1991 ABOUT THIS PROBLEM. I FEEL THAT THEY MADE MY CAR WITH A DEFECTIVE PART AND BOTH MYSELF AND ME TWO CHIRLREN COULD HAVE BEEN KILLED IF IT HADN'T BEEN FOR THE ALERT TRUCK DRIVER. FORD HAS BEEN AWARE OF THE PROBLEM THROUGH TSB'S 91-5-7,92-1-4,92-26A-6, 93-9-11 AND 94-24-7 WHICH EVEN TELLS THE DEALERS NOT TO USE THE ALUMINUM PISTON AND IF THEY HAVE ANY IN STOCK TO RETURN THEM TO THE PARTS DEPOT FOR CREDIT. MY FATHER MR. BOB PATTERSON HAS CONTACTED THE POLICE DEPARTMENT LAWYER WHO HAS REVIEWED THE TSB 94-24-7 AND HE FEELS THAT FORD IS TOTALLY RESPONSIBLE FOR THE REPAIR OF THE VEHICLE. MR. PATTERSON HAS CALLED THE DEALER WHO REFERED HIM TO FORD CUSTOMER SERVICE 1-800-392-3673(JOY) WHO STATED IT WAS OUT OF WARRANTY AND THAT THEY COULD DO NOTHING ABOUT IT. HE FURTHER CONTACTED MR. RON SUMNER FORD MOTER COMPANY PRIORITY SECTION 313-322-3000 WHO SAID IT WAS UP TO THE DEALER TO INITIATE ANY ACTION TO GET ASSISTANCE AND THEN STATED THAT HE DIDN'T THINK FORD WOULD OFFER ANY. WHEN YOUR OFFICE WAS MENTIONED HE SAID THAT FORD WASN'T SCARED OF YOU. ALSO HE WOULD NOT PUT ME IN CONTACT WITH MR. JAQUES NASSER (CEO FORD) WHEN ASKED TO FOR FURTHER ASSISTANCE. IN CALLING BACK THE DEALER AND TALKING TO MR. SATCHER HE STATED THAT IT WAS NOT HIS RESPONSIBLITY TO CONTACT FORD FOR A CUSTOMER COMPLAINT, BUT FORD'S RESPONSIBILITY TO ACT TO IT. AS A CERTIFIED ACCIDENT RECONSTRUCTIONIST FOR THE STATE OF SOUTH CAROLINA I ASK HOW MANY FATAL ACCIDENTS INVOLVING FORD VEHICLE HAVE BEEN LISTED AS DRIVER ERROR JUST BECAUSE THE INVESTIGATOR DIDN'T KNOW OF THIS SITUATION. *AK
CRUISE CONTROL FAILED TO RELEASE WHEN BRAKES WERE TAPPED TO SLOW DOWN. ALSO, THERE WERE NO REAR BRAKE LIGHTS, AND VEHICLE FAILED TO SHIFT OUT OF PARK. WOULD NEED TO APPLY BRAKES TO EDGE VEHICLE TO SHIFT. TOOK VEHICLE TO MECHANIC FOR REPAIRS. OWNER HAS PARTS. *AK *ML
TRANSMISSION FAILURE WAS DUE TO AN ALUMINUM RING BEING EATEN UP INSIDE TRANSMISSION. RING WAS REPLACED WITH A STEEL RING. DEALER NOTIFIED. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
98V009000 · Exterior Lighting:headlights:switch
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
97V019000 · Engine And Engine Cooling:cooling System:fan
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.