NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
289 reportsClear category filter79,000 miles · Feb 27, 2003
Engine And Engine Cooling
IT SEEMS AS THOUGH THE 1994 FORD TAURAS HAS A HEAD GASKET PROBLEM. I HAD THIS PROBLEM FIXED APPROXIMATELY 3 - 5 YEARS AGO. IT SEEMS AS THOUGH THE HEAD GASKET IS LEAKING AGAIN. FROMM READING SOME OTHER COMPLAINTS, IT SEEMS AS THOUGH THIS PROBLEM IS OCCURING ON SEVERAL 1994 FORD TAURAS'S. IS THERE ANY PLAN TO DO A RECALL FOR THIS …
Read full complaint
IT SEEMS AS THOUGH THE 1994 FORD TAURAS HAS A HEAD GASKET PROBLEM. I HAD THIS PROBLEM FIXED APPROXIMATELY 3 - 5 YEARS AGO. IT SEEMS AS THOUGH THE HEAD GASKET IS LEAKING AGAIN. FROMM READING SOME OTHER COMPLAINTS, IT SEEMS AS THOUGH THIS PROBLEM IS OCCURING ON SEVERAL 1994 FORD TAURAS'S. IS THERE ANY PLAN TO DO A RECALL FOR THIS HEAD GASKET PROBLEM.*JB
NHTSA ODI #10008213
28,396 miles · Feb 18, 2003
Engine And Engine Cooling
FAILURE OF HEAD GASKETS ON A 1994 FORD TAURUS WITH THE 3.8L V-6 MOTOR WITH ONLY 28,396 MILES (ORIGINAL) ON THE ODOMETER
NHTSA ODI #10007771
Mileage unknown · Feb 14, 2003
Engine And Engine Cooling
THE HEAD GASKET FAILED, WHICH CAUSED THE VEHICLE TO OVERHEAT.*JB
NHTSA ODI #10007478
Mileage unknown · Jan 21, 2003
Engine And Engine Cooling
WHILE DRIVING AT 60 MPH, CONSUMER STATES VEHICLE ENGINE SUDDENLY DIED OUT. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #10004195
Mileage unknown · Jan 15, 2003
Electrical SystemEngine And Engine CoolingFuel System, Other
MY CAR STALLS OR JUST STOPS IN THE MIDDLE OF TRAFFIC, IT WILL GO FROM 60MPH TO 0MPH. THIS HAS HAPPENED OVER 20 TIMES. I TOOK IT TO PEFFLEY FORD FOR REPAIRS, THEY CHARGED ME $669.36 AND 6 DAYS LATER MY CAR CUT OUT ON ME AGAIN AND THEY TOWED IT TO THEIR SHOP. THEY REFUSED TO LOOK AT MY CAR WITHOUT ME PAYING MORE MONEY FOR REPA…
Read full complaint
MY CAR STALLS OR JUST STOPS IN THE MIDDLE OF TRAFFIC, IT WILL GO FROM 60MPH TO 0MPH. THIS HAS HAPPENED OVER 20 TIMES. I TOOK IT TO PEFFLEY FORD FOR REPAIRS, THEY CHARGED ME $669.36 AND 6 DAYS LATER MY CAR CUT OUT ON ME AGAIN AND THEY TOWED IT TO THEIR SHOP. THEY REFUSED TO LOOK AT MY CAR WITHOUT ME PAYING MORE MONEY FOR REPAIRS AND THE TOW TRUCK. I HAVE SPENT THOUSANDS OF DOLLARS ON REPAIRS FOR MY CAR AND I FEAR FOR MY LIFE EVERY TIME I GET INTO THAT CAR. I NEVER KNOW WHEN IT WILL CUT OUT AND I CAN'T AFFORD TO BUY A NEW CAR. I FOUND OUT THAT 8 PEOPLE OWNED THAT CAR BEFORE ME, WHEN I BOUGHT THE CAR, THE SALESPERSON SAID THAT IT WOULD BE SAFE FOR MY TWO YOUNG GIRLS TO RIDE IN HE WAS WRONG. I HAVE ALL OF MY SUPPORTING DOCUMENTATION AND WILL SEND COPIES TO YOU. PLEASE DO SOMETHING BEFORE ONE OR ALL OF MY FAMILY END UP INJURED OR DEAD. THANKING YOU IN ADVANCE, KAREN JUDKINS.
NHTSA ODI #10002723
Mileage unknown · Dec 24, 2002
Engine And Engine Cooling
THE VEHICLE IS OVER HEATING DUE TO ANTIFREEZE GETTING INTO THE OIL. CONSUMER STATES' TOOK TO FORD AND THEY REPLACED THE RADIATOR, AND THE PROBLEM WAS STILL OCCURRING. CONSUMER TOOK VEHICLE TO ANOTHER MECHANIC AND THEY REPLACED THE HEAD GASKETS AND THE OVER HEATING STOPPED. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #10001448
8,500 miles · Dec 20, 2002
Engine And Engine Cooling
VEHICLE IS OVERHEATING AND CONSTANTLY LEAKING ANTI-FREEZE AND OIL. CAUSE OF LEAK UNKNOWN. THE DEALERSHIP REPLACED THE RADIATOR BUT THE PROBLEM STILL OCCURS. THEN THE DEALERSHIP REPLACED THE HEAD GASKET AND THE OVER HEATING STOPPED. PLEASE PROVIDE MORE DETAILS. TS
NHTSA ODI #10001341
Mileage unknown · Aug 26, 2002
Engine And Engine CoolingPower Train
1. 3.8L V6 HEAD GASKETS. GASKET(S) FAILED ON VEHICLE AT 80878 MILES. ENGINE BLOWS HEAVY ?!@#$% SMOKE FROM TAILPIPE, OVERHEATS AND LOSES COOLANT. VEHICLE IS 8 YRS OLD AND OUT OF EXTENDED FORD WARRANTY PROGRAM, (7YRS 100,000MI). CONTACTED BOTH LOCAL FORD DEALERSHIP AND FORD CUSTOMER SERVICE, BOTH SAYING THERE IS NO ASSISTANCE…
Read full complaint
1. 3.8L V6 HEAD GASKETS. GASKET(S) FAILED ON VEHICLE AT 80878 MILES. ENGINE BLOWS HEAVY ?!@#$% SMOKE FROM TAILPIPE, OVERHEATS AND LOSES COOLANT. VEHICLE IS 8 YRS OLD AND OUT OF EXTENDED FORD WARRANTY PROGRAM, (7YRS 100,000MI). CONTACTED BOTH LOCAL FORD DEALERSHIP AND FORD CUSTOMER SERVICE, BOTH SAYING THERE IS NO ASSISTANCE THEY COULD PROVIDE, EVEN THOUGH IT IS A KNOWN DEFECT WITH THE HEAD GASKETS. 2. TRANSMISSION FAILED, AT 79,392MI. WHEN VEHICLE WAS WARM, TRANSMISSION WOULD NOT ENGAGE 1ST GEAR, LEAVING YOU STRANDED WHEREVER YOU STOPPED. CONTACTED LOCAL FORD DEALERSHIP, WHO QUOTED $2500 + LABOR. HAD TRANSMISSION REPLACED AT LOCAL TRANSMISSION SHOP FOR $1800. THIS VEHICLE HAS BEEN CAREFULLY MAINTAINED. ALL MAINTENANCE ITEMS PERFORMED AT MANUFACTURERS RECOMMENDED INTERVALS FOR HEAVY DUTY USE. (EVERY 3000MI) OIL CHANGED EVERY 3,000MI, TRANSMISSION FLUID CHANGED PER MAINTENANCE SCHEDULE, FILTERS, TIRE ROTATION, SPARK PLUGS, EVERYTHING. IF FORD WON'T STAND BEHIND THEIR PRODUCT, WHICH HAS A KNOWN DESIGN / MANUFACTURERS DEFECT. THIS WAS THE LAST FORD PRODUCT I WILL EVER BUY. IT MAY BE ANYWAY. *AK
NHTSA ODI #766239
Mileage unknown · Aug 14, 2002
Engine And Engine Cooling
WHILE SITTING AT AN INTERSECTION VEHICLE STALLED. CONSUMER TRIED TO RESTART AND IT MADE A HORRIBLE METAL CLINKING SOUND. CONSUMER DROVE CAR TO A MECHANIC, AND MECHANIC STATED THAT ENGINE NEEDED TO BE REPLACED. THERE WASA RECALL ON HEAD GASKET, BUT THIS VEHICLE WAS NOT INCLUDED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8016296
Mileage unknown · Jul 17, 2002
Engine And Engine Cooling
VEHICLE STARTED SHAKING AT 40 MPH. CONSUMER REPLACED SHARKS/ STRUTS, AND TIRES; BUT VEHICLE STILL SHAKES. DEALER STATED THERE WERE SEVERAL ENGINE MOUNTS BROKEN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8014095
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
Illustration