IllustrationTRANSMISSION HAS FAILED TWICE. THE FIRST TIME WAS IN 5/97. MOTOR MOUNTS BROKE, CAUSING ENGINE TO LAY ON TRANSMISSION, WHICH ALSO WAS REPLACED. SECOND TIME, MOTOR MOUNTS BROKE, AND THE SAME THING HAPPENED. CONSUMER RECEIVED A RECALL NOTICE FOR MOTOR MOUNTS. *AK
1991 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1991 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 649 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 116 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports21 fire reports18 injury reports
What owners actually said
649 reportsWHILE DRIVING AND WITHOUT WARNING THE VEHICLE WENT INTO NEUTRAL, AND COULD NOT BE PUT INTO ANY OTHER GEAR, CAUSE UNKNOWN. *AK
CONSUMER HAS BEEN EXPERIENCING PROBLEMS WIT AUTOMATIC TRANSMISSION. VEHICLE ONLY HAS FIRST GEAR OR REVERSE. THE MANUFACTURER HAS BEEN CONTACTED. *AK
ORIGINAL TRANSMISSION WAS FIXED 3 TIMES AND THEN FINALLY REPLACED, ALL UNDER WARRANTY. THE REPLACEMENT TRANSMISSION LASTED ABOUT 70000 MILES, AND THEN HAS HAD THE SAME TYPES OF PROBLEMS, AND HAS BEEN REPLACED. THE FRONT RIGHT MOTOR MOUNT BROKE SEVERAL TIMES AND CONTINUALLY THE TOP BOLT VIBRATES LOOSE. THE MOUNT HAS JUST BEEN REP…
Read full complaint
ORIGINAL TRANSMISSION WAS FIXED 3 TIMES AND THEN FINALLY REPLACED, ALL UNDER WARRANTY. THE REPLACEMENT TRANSMISSION LASTED ABOUT 70000 MILES, AND THEN HAS HAD THE SAME TYPES OF PROBLEMS, AND HAS BEEN REPLACED. THE FRONT RIGHT MOTOR MOUNT BROKE SEVERAL TIMES AND CONTINUALLY THE TOP BOLT VIBRATES LOOSE. THE MOUNT HAS JUST BEEN REPLACED AGAIN. THE FRONT WHEEL ROTORS CONTINUALLY GO BAD, AND HAVE TO BE REPLACED, ESPECIALLY THE RIGHT ONE. *AK
THE CONSUMER NOTICED SMOKE IN THE PASSENGER'S COMPARTMENT. WHEN CONSUMER PULLED OVER TO CHECK THE ENGINE IT WAS AN FIRE AT THE TOP OF DRIVER,S SIDE OF THE ENGINE, CAUSE UNKNOWN. DEALER HAS NOT BEEN CONTACTED. *AK
FRONT RIGHT WHEEL STOPPED RESPONDING TO STEERING WHEEL, CAUSING LOSS OF VEHICLE CONTROL. COULD BE FATAL IF HAPPENS IN HIGHWAY BECAUSE ONLY ONE WHEEL WOULD RESPOND TO STEERING WHEEL. I'M ONLY DRIVER TO THIS CAR - PURCHASE NEW FROM SHEEHY'S FORD-ALL REPAIRS DONE ONLY AT DEALER- NEVER HAD AN ACCIDENT NOR A TRAFFIC TICKET-NEVE…
Read full complaint
FRONT RIGHT WHEEL STOPPED RESPONDING TO STEERING WHEEL, CAUSING LOSS OF VEHICLE CONTROL. COULD BE FATAL IF HAPPENS IN HIGHWAY BECAUSE ONLY ONE WHEEL WOULD RESPOND TO STEERING WHEEL. I'M ONLY DRIVER TO THIS CAR - PURCHASE NEW FROM SHEEHY'S FORD-ALL REPAIRS DONE ONLY AT DEALER- NEVER HAD AN ACCIDENT NOR A TRAFFIC TICKET-NEVER DRIVE CAR FASTER THAN 65 M/H-CAR WAS AT DEALER 2 MONTHS BEFORE BECAUSE IT HAD LOST A MOTOR SUPPORTING NUT-SAME DEALER WHO FIXED THIS TIME=JERRY'S FORD.- THANK YOU- LUCKY TO BE ALIVE. *AK
I HAVE FAILED TO UNDERSTAND WHY ALL I HAVE HAD WITH MY VEHICLE WAS PROBLEMS TILL THIS DAY. *AK
WHILE DRIVING IN OVERDRIVE, IT WOULDN'T MOVE. THEN THE VEHICLE STOPPED COMPLETELY. DEALER HAS NOT SEEN. *AK
ANTI-LOCK BRAKES SEEM TO ENGAGE DURING CORNERING TO THE RIGHT WITH YOUR FOOT ON THE BRAKE TO SLOW DOWN (OCCASSIONALLY). THE BRAKE PEDAL THEN VIOLENTLY JERKS YOUR FOOT, HARD ENOUGH TO BRUISE. THE SYSTEM ALSO ENGAGES UPON BRAKE APPLICATION ON WET OR SANDY SURFACE AND VIOLENTLY PUSHES PEDAL UP AGAINST THE FOOT APPLYING THE BRAKE,…
Read full complaint
ANTI-LOCK BRAKES SEEM TO ENGAGE DURING CORNERING TO THE RIGHT WITH YOUR FOOT ON THE BRAKE TO SLOW DOWN (OCCASSIONALLY). THE BRAKE PEDAL THEN VIOLENTLY JERKS YOUR FOOT, HARD ENOUGH TO BRUISE. THE SYSTEM ALSO ENGAGES UPON BRAKE APPLICATION ON WET OR SANDY SURFACE AND VIOLENTLY PUSHES PEDAL UP AGAINST THE FOOT APPLYING THE BRAKE, SOMETIMES BRUISING THE BOTTOME OF THE FOOT. THIS HAS KNOCKED MY FOOT OFF THE BRAKE PEDAL UPON OCCASION.
MOTOR MOUNTS FAILED AS WELL AS THE AXLES AS A DIRECT RESULT OF RECALL ON SUBFRAMES, CAUSING DIFFICULT STEERING.
Official recalls
498V323000 · Structure:frame And Members
Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
97V025000 · Vehicle Speed Control
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
92V065000 · Wheels
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
91V134000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14SQ98008 · Audio System Fires
Opened May 4, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Electrical System
SEE RESUME FOR DETAILS.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
DP91013 · ANTI-LOCK Brakes
Opened Sep 24, 1991 · Closed Jan 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ANTI-LOCK BRAKES
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available