NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
44 reportsClear category filterMileage unknown · Jan 15, 2004
Electrical SystemEngine And Engine CoolingEquipment
I CAN'T POSSIBLY REMEMBER THE DATES THESE THINGS HAPPENED. I PUT A NEW (USED) TRANSMISSION AND THIS ONE IS SLIPPING. I PUT MORE BRAKE PADS AND CALIPERS THAN YOU WOULD USE IN A LIFE TIME. THE SPRINGS ARE WEAK IN THE BACK, BUT TO EXSPENSIVE TO CHANGE. I PUT A NEW FUEL PUMP AND GAS TANK. I'VE PUT A NEW EGR VALVE, OXYGEN SENSOR…
Read full complaint
I CAN'T POSSIBLY REMEMBER THE DATES THESE THINGS HAPPENED. I PUT A NEW (USED) TRANSMISSION AND THIS ONE IS SLIPPING. I PUT MORE BRAKE PADS AND CALIPERS THAN YOU WOULD USE IN A LIFE TIME. THE SPRINGS ARE WEAK IN THE BACK, BUT TO EXSPENSIVE TO CHANGE. I PUT A NEW FUEL PUMP AND GAS TANK. I'VE PUT A NEW EGR VALVE, OXYGEN SENSOR, THROTTLE SENSOR, AIR TEMP SENSOR. I PUT A BLINKER SWITCH AND NEW STRUTS BECAUSE MINE BROKE. 3 OUT OF 4 OF MY DOORS WILL NOT OPEN BECAUSE OF THE HANDLES. THESE ARE JUST A FEW OF THE THINGS I WROTE DOWN OR CAN REMEMBER. NOW IT WILL NOT START UNLESS I PUMP THE GAS(IT'S FUEL INJECTED) AND KEEP TURNING IT OVER AND OVER. THEN I'M NOT SURE IF IT WILL START AGAIN WHEN I SHUT IT OFF. THE FUEL PUMP IS WORKING I THINK, I CAN HEAR IT. I BOUGHT THE CAR USED AND THE PERSON PUT A 1989 MOTOR INTO A 1991 BODY. THESE THINGS STILL WENT WRONG WITH THE CAR EITHER WAY. I DID NOT CHECK ANY BELOW BECAUSE I'M NOT SURE WHAT TO CHECK.
NHTSA ODI #10071118
Mileage unknown · Jul 24, 2002
Electrical System
CONSUMER STATED HE WAS NOT ABLE TO TURN OFF THE ENGINE WITH THE IGNITION KEY, THE CONSUMER TOOK THE VEHICLE DOWN TO A LOCAL GARAGE AFTER LOOKING AT THE EXTERIOR OF THE SWITCH THE MECHANIC INFORMED CONSUMER THE TYPE OF SWITCH WAS A NOTORIOUS HIGH FAILURE ITEM, HE WAS THEN ABLE TO FORCE THE KEY TO THE OFF POSITION ,THEN THE KEY W…
Read full complaint
CONSUMER STATED HE WAS NOT ABLE TO TURN OFF THE ENGINE WITH THE IGNITION KEY, THE CONSUMER TOOK THE VEHICLE DOWN TO A LOCAL GARAGE AFTER LOOKING AT THE EXTERIOR OF THE SWITCH THE MECHANIC INFORMED CONSUMER THE TYPE OF SWITCH WAS A NOTORIOUS HIGH FAILURE ITEM, HE WAS THEN ABLE TO FORCE THE KEY TO THE OFF POSITION ,THEN THE KEY WOULD ONLY TURN WITH A GREAT DEAL OF FORCE BUT NOW THE ENGINE WOULD NOT START, THEN AFTER CLEANING THE HOUSING AND REINSERTING THE INGITION KEY THE ENGINE STILL WOULD NOT START AND THE KEY WAS NOT AS FREE AS BEFORE. COMING TO THE POINT OF JUST REPLACING THE SWITCH THEY DISCOVERED THAT THE PLUG HOUSING WAS MELTED AROUND THE PINS A-4/B-4&A-2/B-2 WHICH COULD CAUSE A LOOSE CONNECTION THEREFORE HIGH RESISTANCE COULD CAUSE FUTURE FAILURE OF A NEW SWITCH OR FIRE IN THE STEERING COLUMN. *MJ.>*NLM *CB
NHTSA ODI #566780
Mileage unknown · May 31, 2002
Electrical SystemFire
VEHICLE WAS SITTING A COUPLE OF HOURS BEFORE CATCHING FIRE. VEHICLE WAS TOTALED DUE TO A FIRE STARTING FROM ENGINE COMPARTMENT AND SPREADING UNDER THE DASHBOARD. DEALER AND MANUFACTURER WERE NOT COTACTED. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8010869
Mileage unknown · Oct 29, 2001
Electrical System
THE CAR WOULD QUIT AND WOULDN'T START, A WRECKER SERVICE HAULDED IT IN TWICE. I HAD TO LEAVE IT WHERE IT WAS OVERNIGHT TWICE. I HAD IT HAULED TO BROWN'S AUTO IN PAINTSVILLE THE LAST TIME, WHERE IT STAYED FOR 1 MONTH. THEY DID A DIAGNOSTIC COMPUTER CHECK, TOLD ME THE IGNITION CONTROL MODULE WAS BAD, I HAVEN'T BEEN ABLE TO…
Read full complaint
THE CAR WOULD QUIT AND WOULDN'T START, A WRECKER SERVICE HAULDED IT IN TWICE. I HAD TO LEAVE IT WHERE IT WAS OVERNIGHT TWICE. I HAD IT HAULED TO BROWN'S AUTO IN PAINTSVILLE THE LAST TIME, WHERE IT STAYED FOR 1 MONTH. THEY DID A DIAGNOSTIC COMPUTER CHECK, TOLD ME THE IGNITION CONTROL MODULE WAS BAD, I HAVEN'T BEEN ABLE TO GET IT FIXED YET BECAUSE FORD ISN'T MAKING PARTS. THIS HAS BEEN OVER A YEAR. I LIVE IN KY. I HAVE TO PAY TAXES ON THIS TO LET IT SIT.*AK
NHTSA ODI #753830
Mileage unknown · May 6, 2001
Electrical System
I JUST CRANKED IT UP AND SOMETHING POPPED UNDER THE HOOD AND THEN SMOKE CAME GUSHING OUT FROM THE TAIL PIPE. I WAS TOLD IT CRACKED THE BLOCK NOTHING BUT ANTIFREEZE WAS COMING OUT OF THE TAIL PIPE. IS THERE SOMETHING WRONG WITH THESE 3.8L ENGINES?*AK
NHTSA ODI #744990
Mileage unknown · Mar 21, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
CAR STALLS INTERMITTENTLY. DEALER REPLACED PLUG WIRES, CAP & ROTOR, FUEL & AIR FILTERS, AND FUEL PUMP. TYPICALLY DOESN'T PRESENT COMPUTER FAILURE CODES. QUITS AT HIGHWAY SPEED, IN CITY TRAFFIC, WHEN COLD OR WARM. SOMETIMES RESTARTS IMMEDIATELY, OFTEN WON'T START FOR HOURS, OR UNTIL NEXT DAY. DEALER IS OUT OF SUGGESTIONS, AND I'M…
Read full complaint
CAR STALLS INTERMITTENTLY. DEALER REPLACED PLUG WIRES, CAP & ROTOR, FUEL & AIR FILTERS, AND FUEL PUMP. TYPICALLY DOESN'T PRESENT COMPUTER FAILURE CODES. QUITS AT HIGHWAY SPEED, IN CITY TRAFFIC, WHEN COLD OR WARM. SOMETIMES RESTARTS IMMEDIATELY, OFTEN WON'T START FOR HOURS, OR UNTIL NEXT DAY. DEALER IS OUT OF SUGGESTIONS, AND I'M AT WIT'S END. VEHICLE UNSAFE/UNUSABLE IN THIS CONDITION. *AK
NHTSA ODI #742783
Mileage unknown · Mar 2, 2001
Electrical System
WHILE PULLING INTO A PARKING SPACE VEHICLE DIED AND WOULD NOT RESTART. DEALER CLAIMS THAT IT IS TFI MODULE. *AK
NHTSA ODI #881977
Mileage unknown · Feb 5, 2001
Air BagsElectrical SystemSteering
AIR BAG LIGHT HAS BEEN ILLUMINATING ON DASH. CONSUMER HAS CONTACTED DEALER, DEALER NOTICED WIRING HARNESS HAD SHORT CIRCUITED, CAUSING LIGHT TO ILLUMINATE. ALSO, EXPERIENCED A PROBLEM WITH TOTAL LOSS OF STEERING POWER. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #879770
Mileage unknown · Nov 27, 2000
Electrical System
THE VEHICLE CONTINUALLY STALLS DUE TO FAILURE OF THE FLAWED IGNITION MODULE (TFI). *MJS
NHTSA ODI #557922
Mileage unknown · Oct 23, 2000
Electrical SystemEngine And Engine Cooling
VEHICLE STALLS WITHOUT WARNING , MOSTLY IN THE SUMMER . MECHANIC HAS SERVICED VECHICLE , CHANGED STARTER, BUT DEFECT STILL OCCURS.*AK
NHTSA ODI #873572
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14SQ98008 · Audio System Fires
Opened May 4, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Electrical System
SEE RESUME FOR DETAILS.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
DP91013 · ANTI-LOCK Brakes
Opened Sep 24, 1991 · Closed Jan 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ANTI-LOCK BRAKES
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration