Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
00–25K
425–50K
450–75K
375–100K
8100–150K
2150K+
21 reports with mileage · 15 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports8 fire reports1 injury reports
What owners actually said
36 reports
Mileage unknown · Apr 22, 2003
Tires
I HAVE NOTICED A SLOW AIR LEAK ON ONE OF MY TIRES INSTALLED ON MY 2001 F150 SUPERCREW. A LEAK TEST IN A TUBE OF WATER FOUND THE LEAK WAS DUE TO A SMALL HOLE IN THE SIDEWALL APPROXIMATELY 1 INCH FROM THE RIM. FURTHER INVESTIGATION REVEALED THAT ALL TIRES HAVE SPORADIC CRACKING AND MINOR BUBBLING ON THE SIDEWALL ON BOTH SIDES OF…
Read full complaint
I HAVE NOTICED A SLOW AIR LEAK ON ONE OF MY TIRES INSTALLED ON MY 2001 F150 SUPERCREW. A LEAK TEST IN A TUBE OF WATER FOUND THE LEAK WAS DUE TO A SMALL HOLE IN THE SIDEWALL APPROXIMATELY 1 INCH FROM THE RIM. FURTHER INVESTIGATION REVEALED THAT ALL TIRES HAVE SPORADIC CRACKING AND MINOR BUBBLING ON THE SIDEWALL ON BOTH SIDES OF ALL TIRES. THE TIRES ARE NOT OLD ENOUGH TO BE DRY-ROTTED. ALL TIRES ARE GOODYEAR WRANGLER RT/S P255/70R16. TIRES WERE MANUFACTURED 3/01 WHICH COINCIDES WITH THE MFR DATE OF MY VEHICLE. THE LOCAL GOODYEAR DEALER WILL PRO-RATE THE COST OF THE REMAINING TREAD TOWARDS THE PURCHASE OF A NEW SET OF TIRES. FORTUNATELY, I CHECK THE TIRES ON ALL MY VEHICLES AT LEAST WEEKLY AND HAVE PREVENTED A POSSIBLE FATALITY BEFORE IT HAS HAPPENED. THESE TIRE DEFINITELY APPEAR TO HAVE A SERIOUS MATERIAL DEFECT THAT WARRANTS FURTHER INVESTIGATION. *JB
NHTSA ODI #10016370
Mileage unknown · Feb 3, 2003
Unknown Or Other
2001 F150 SUPERCREW, PAINT ON TRUCK IS CRACKED ALL OVER. THE BODY SHOP MAN SAID THAT IT IS CALLED CROWS FOOT.
NHTSA ODI #10005189
35,000 miles · Jan 5, 2003
Engine And Engine Cooling
OIL LEAK AT HEAD GASKET. REPAIRED BY DEALERSHIP. WHAT ARE THEN CHANCES OF THIS HAPPENING AGAIN? HAS THIS PROBLEM CAUSED ANY DAMAG TO THE ENGINE?
NHTSA ODI #10000529
Mileage unknown · May 16, 2002
Tires
CONSUMER STATES THAT THERE IS TREAD SPLITTING THROUGH THE TIRE. GENERAL TIRE #2657516*JB
NHTSA ODI #8010006
Mileage unknown · Nov 19, 2000
Seats
HAVE NOT HAD AN INCIDENT AS OF YET, BUT AM CONCERNED ABOUT REAR SEAT PASSENGERS HEAD HITTING THE BACK GLASS IN THE EVENT OF A REAR END COLLISION. *AK
NHTSA ODI #736561
Mileage unknown · Nov 18, 2000
Seats
REAR SEATS DO NOT HAVE HEADRESTS. IN THE EVENT OF AN ACCIDENT, THE REAR PASSENGERS HEADS WOULD SLAM AGAINST THE REAR WINDOW. FORD NOW HAS REAR HEADRESTS IN THERE CURRENT MODEL. THE FIRST 2001 SUPERCREWS SHOULD HAVE THE REAR SEATS UPGADED WITH THE SAFER SEATS WITH THE HEADRESTS. I HAVE HAD PASSENGERS ALREADY HIT THEIR HEADS AGAIN…
Read full complaint
REAR SEATS DO NOT HAVE HEADRESTS. IN THE EVENT OF AN ACCIDENT, THE REAR PASSENGERS HEADS WOULD SLAM AGAINST THE REAR WINDOW. FORD NOW HAS REAR HEADRESTS IN THERE CURRENT MODEL. THE FIRST 2001 SUPERCREWS SHOULD HAVE THE REAR SEATS UPGADED WITH THE SAFER SEATS WITH THE HEADRESTS. I HAVE HAD PASSENGERS ALREADY HIT THEIR HEADS AGAINST THE REAR WINDOW. LUCKILY NO ONE HAS BEEN INJURED.*AK
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
Remedy: AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Seat Belts
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Seat Belts:front:buckle Assembly
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ04011 · Front Seat Belt Buckle Assembly
Opened Oct 22, 2004 · Closed Feb 17, 2005
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUCKLE TEST TOOL.FORD REPORTED THAT 829,927 VEHICLES HAD BOTH BUCKLES PASS THE TOOL TEST AND ANOTHER 167,336 VEHICLES HAD ONE BUCKLE PASS.ODI AND FORD RECEIVED COMPLAINTS ALLEGING SEAT BELT BUCKLE FAILURE SHORTLY AFTER PASSING THE ORIGINAL RECALL INSPECTION SERVICE.COMPLAINANTS ALLEGED THAT THE BUCKLE FAILED BY EITHER NOT LATCHING OR FALSE-LATCHING (PARTIAL ENGAGEMENT OF THE LATCH TO THE LATCH PLATE).A FALSE-LATCHED BUCKLE MAY RELEASE WITH MINOR MOVEMENT OR IMPACT AGAINST THE BUCKLE HOUSING INCLUDING INADVERTENT RELEASE WHILE THE VEHICLE IS IN MOTION.ODI IS UPGRADING THIS RECALL QUERY TO AN ENGINEERING ANALYSIS (EA05-004) TO FURTHER ANALYZE THE FIELD PERFORMANCE OF THOSE VEHICLES THAT FORD DEALERS PASSED (ONE OR BOTH BUCKLES) USING FORD'S INSPECTION TEST (997,263 VEHICLES).
2001 Ford Supercrew Problems, Complaints & Recalls | Skip That Year
Illustration