Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports3 injury reports

Forward Collision Avoidance complaints

7 reports

Clear category filter

Mileage unknown · Aug 11, 2026

Forward Collision AvoidancePower TrainSeat Belts

1. Transmission is going out dealership never said a word about the 6 recalls on it one being transmission 2. Front seat belts are in backwards and the child safety hook in back seat has a recall on it that the 3 of the 6 I know of Ford had told alm to replace the entire transmission before they ever sold it they did not do that…

Read full complaint

NHTSA ODI #11756331

20,000 miles · Feb 14, 2025

Electrical SystemForward Collision Avoidance

Read full complaint

The contact owns a 2020 Ford Ranger. The contact stated that while driving at various speeds, the "Pre-Collision Assist Not Available Sensor Blocked" message was displayed on the instrument panel. The contact stated that whenever the message was displayed with the Cruise Control activated, the Cruise Control would disengage independently. The dealer was notified of the issue but offered no assistance. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 20,000.

NHTSA ODI #11642687

21,000 miles · May 2, 2024

Back Over PreventionForward Collision Avoidance

Read full complaint

The contact owns a 2020 Ford Ranger. The contact stated that while driving at unknown speeds, the front camera fault service required and pre-collision assist not available, messages were displayed. There was an abnormal chiming sound detected. The safety features were disabled. The vehicle was taken to the local dealer, who informed the contact to clean the camera. The dealer used an ODB scanner but retrieved no codes and informed the contact to schedule a service appointment. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that there were no open recalls on the VIN. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 21,000.

NHTSA ODI #11586502

Mileage unknown · Aug 21, 2023

EngineForward Collision AvoidancePower Train

It’s been about 4 months on the forward collision alarm and 4 1/2 weeks on the jerking going when taking off the transmission seems to jerk and when driving down a highway when nothing what so ever is on front of me all the sudden my front collision alarm goes off with a sudden breaks being applied by themselves.I spoke to deale…

Read full complaint

NHTSA ODI #11539932

Mileage unknown · May 12, 2022

Forward Collision AvoidanceVehicle Speed ControlCrash

On two separate instances the truck accelerated on it own and the brakes were used but didn't stop the vehicle had to turn the key off and the second of these two incidences the truck hit a wall and kept accelerating digging the ground up

NHTSA ODI #11464340

10,000 miles · Dec 9, 2020

Forward Collision Avoidance

I GET AN ''IMMINENT COLLISION WARNING" DISPLAY AND AURAL SOUND AT RANDOM TIMES, APPROXIMATELY 1X WEEK, WHILE DRIVING STRAIGHT, MODERATE SPEEDS, DRY WEATHER.

NHTSA ODI #11378678

2,250 miles · Nov 21, 2020

Forward Collision AvoidanceService BrakesCrash

OUR NEW 2020 FORD RANGER XLT LISTED A FEATURE CALL PRE-COLLISION ASSIST W/AEB. THE TRUCK DID NOT GIVE A WARNING NOR DID IT APPLY THE BRAKES AUTOMATICALLY. NOTHING OCCURRED BEFORE WE RAN INTO THE REAR END OF THE CAR IN-FRONT OF US. THE CAR AHEAD WAS STOPPED AT A TRAFFIC LIGHT AND WE RAN INTO THE REAR END AT ABOUT 20 MPH.

NHTSA ODI #11375688

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

21V811000 · Seat Belts:front:webbing

Oct 15, 2021

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

21V765000 · Child Seat:vehicle Latch Anchor; Seats:mid/rear Assembly

Sep 30, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."

Consequence & remedy

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Additional source detail variants (2)

Child Seat:vehicle Latch Anchor

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Seats:mid/rear Assembly

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 3, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Consequence & remedy

Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.