Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports3 injury reports

Engine complaints

16 reports

Clear category filter

Mileage unknown · Nov 1, 2023

Engine

Read full complaint

The Ignition Coil and spark plug failed and caused the vehicle to misfire & lose power under load. The vehicle is available for inspection. Sudden loss of power could have caused a collision due to the vehicle suddenly slowing without warning in traffic conditions. Ford Motor company is aware of the problem and has a service bulletin describing how the lack of an engine cover allows water to get into the spark plug wells causing the failure to occur. Ford's fix is to install the engine cover and replace the damaged components. But will only do so under the standard warranty. Ford was notified of the problem with my vehicle while it was well within warranty. But because a dealer could not schedule an appointment until 9 days after the standard warranty expired, they have denied coverage. Dealership has inspected the components and confirmed problem is related to service bulletin. Check Engine light came on and was flashing when problem occurred. No prior warning or symptom until problem occurred.

NHTSA ODI #11553010

Mileage unknown · Aug 21, 2023

EngineForward Collision AvoidancePower Train

It’s been about 4 months on the forward collision alarm and 4 1/2 weeks on the jerking going when taking off the transmission seems to jerk and when driving down a highway when nothing what so ever is on front of me all the sudden my front collision alarm goes off with a sudden breaks being applied by themselves.I spoke to deale…

Read full complaint

NHTSA ODI #11539932

20,000 miles · Aug 18, 2023

Engine

Read full complaint

The contact owns a 2020 Ford Ranger. The contact stated that while his wife was driving at various speeds, the vehicle hesitated and violently shook while depressing the accelerator pedal. The check engine warning light was illuminated. The contact had the vehicle towed to a dealer where it was discovered that the spark plugs, and engine coils were damaged due to moisture from rain or a car wash. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 20,000.

NHTSA ODI #11539338

Mileage unknown · Jun 16, 2023

Electrical SystemEngine

Exactly what is described in TSB 22-2025 and 21-2147. Ford did not put an engine cover on my truck, and water has intruded into the spark plug wells and corroded the equipment. Ford is refusing to fix the issue, as the NHTSA didn't include my VIN in the two previously issues TSBs about this.

NHTSA ODI #11527452

860 miles · Dec 31, 2020

Engine

Read full complaint

MY TRUCK(2020 FORD RANGER) HAS FUEL CONTAMINATION IN THE ENGINE OIL. I CHANGED THE OIL FOR THE FIRST TIME WHEN THE TRUCK HAD 860 MILES ON IT. THE OIL REEKED OF GASOLINE WHEN I CHANGED IT. I SENT THE OIL INTO BLACKSTONE FOR ANALYSIS AND THE RESULTS SHOWED A 4.3% FUEL DILUTION OF THE OIL, WHICH ACCORDING TO THE COMPANY IS A CAUTIONARY LEVEL. THEY ALSO STATED THE OIL VISCOSITY WAS LOW AND PROBABLY DUE TO FUEL DILUTION. I OPENED A FORD CUSTOMER COMPLAINT (CAS-29025613) AND TOOK IT TO DEALER. THE DEALER INSPECTED THE VEHICLE AND SAID NOTHING IS NEEDING REPAIR AT THIS TIME. NO TSB'S ARE LISTED FOR THIS COMPLAINT. THE DEALER SAID THEY TRIED CALLING FORD TO UPDATE THE COMPLAINT CLAIM WITH THEIR FINDINGS BUT COULDN'T DO SO BECAUSE WAS ALREADY CLOSED! VERY FRUSTRATING. THERE ARE SEVERAL OTHER FORD RANGER OWNERS (ON RANGER5.COM FORUMS) WHO ALSO COMPLAIN OF HAVING FUEL DILUTION IN THEIR OIL AND FORD HAS YET TO TAKE THEM SERIOUSLY AND INVESTIGATE THE ROOT CAUSE.

NHTSA ODI #11385771

Mileage unknown · Dec 16, 2020

Engine

Read full complaint

WHEN I START THE CAR, IT MAKES A RATTLE NOISE AND WHEN THE ENGINE WARMS UP, IT GOES AWAY, BUT EVERY TIME I ACCELERATE, YOU CAN HEAR THE RATTLE AGAIN AND WHEN I REMOVE MY FOOT FROM THE ACCELERATION PEDAL, THE RATTLE GOES AWAY AND LIKE THAT EVERY TIME I ACCELERATE. I TOOK THE CAR TO THE DEALER AND EXPLAINED THEM ABOUT THE NOISE AND LATER THAT DAY, THEY CALLED AND TOLD THAT IN THE 2019 AND 2020 FORD RANGER, THE ENGINE CAME WITH A NOISE AND IT'S NORMAL IN THE ENGINE, THAT THEY WERE TOLD BY FORD NOT TO ATTEMPT TO FIX IT BECAUSE THE NOISE IS PART OF THE ENGINE. IT DOES NOT SOUND RIGHT AND IF IN THE FUTURE I WANT TO SELL I PROBABLY WOULDN'T BECAUSE OF THE NOISE. IF THEY HAVE TO REPLACE THE ENGINE I'M OKAY WITH IT, BUT I WANT THAT RATTLE NOISE OUT OF MY TRUCK

NHTSA ODI #11383782

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

21V811000 · Seat Belts:front:webbing

Oct 15, 2021

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

21V765000 · Child Seat:vehicle Latch Anchor; Seats:mid/rear Assembly

Sep 30, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."

Consequence & remedy

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Additional source detail variants (2)

Child Seat:vehicle Latch Anchor

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Seats:mid/rear Assembly

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 3, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Consequence & remedy

Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.