NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
271 reports65,200 miles · Jan 10, 2013
Structure
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT MERGED TO THE SHOULDER AND ATTEMPTED TO SECURE THE TIRE BACK IN THE SUPPORTING RACK BY USING HANGERS AND ROPE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT MERGED TO THE SHOULDER AND ATTEMPTED TO SECURE THE TIRE BACK IN THE SUPPORTING RACK BY USING HANGERS AND ROPE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE CHASSIS FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 65,200.
NHTSA ODI #10492126
85,000 miles · Oct 16, 2012
Fuel/propulsion System
THE FIRST INCIDENT I WAS DROPPING MY GRANDDAUGHTER OFF AT SCHOOL WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT HAD IT TOWED HOME AND IT STARTED ONCE OFF THE TOW TRUCK.THIE SECOND INCIDENT I WAS GOING THROUGH A PARKING LOT AND WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT, HAD TO HAVE IT TOWED AND THEY REPLACED THE FUEL PUM…
Read full complaint
THE FIRST INCIDENT I WAS DROPPING MY GRANDDAUGHTER OFF AT SCHOOL WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT HAD IT TOWED HOME AND IT STARTED ONCE OFF THE TOW TRUCK.THIE SECOND INCIDENT I WAS GOING THROUGH A PARKING LOT AND WENT OVER A SPEED BUMP AND THE TRUCK STALLED OUT, HAD TO HAVE IT TOWED AND THEY REPLACED THE FUEL PUMP. THE NEXT INCIDENT I WAS IN RUSH HOUR TRAFFIC ON A FEEDER ROAD AND IT STALLED WAS NEXT TO THE SERVICE STATION WHERE IT WAS PREVIOUSLY FIXED AND AFTER APOLICEMAN STOPPED TRAFFIC AND HAD ME PUSHED TO THE SERVICE STATION WAS TOLD BY A SENIOR TECHNICIAN THAT THIS WAS A KNOWN ISSUE ON THE RANGER AND TO PUSH THIS BUTTON WHENEVER IT HAPPENED. I HAVE BEEN DOING THIS A LOT SINCE THIS TIME AND HAVE HAD SOME VERY CLOSE CALLS DUE TO THE STALLING, WITH THE LATEST ALMOST CAUSING A MAJOR ACCIDENT DUE TO OCCURRING A HIGH SPEED AFTER HITTING A ROAD BUMP. THE INERTIA SWITCH ON FORD RANGER?S 2003 THROUGH 2006 ARE DEFECTIVE IN THREE MANNERS ONE THE CONNECTORS BURN DUE TO A HIGH CURRENT DRAW, THE SWITCH ACTIVATES WITHOUT WARNING, AND DUE TO NO KICKPLATE PASSENGERS CAN ACTIVATE THE SWITCH. THIS SWITCH IS USED TO CUT THE FUEL OFF DURING A ROLL OVER CRASH SCENARIO. THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET IN REGARD TO THE FIRE AND SAFETY ISSUES THIS DEFECTIVE PART HAS CAUSED. TO DATE FORD HAS NOT ISSUED A RECALL, OR NOTIFIED THE CONSUMER BASE OF THE POTENTIAL HAZARDS SURROUNDING THIS ISSUE, BUT HAS ISSUED A REDESIGNED SWITCH THAT NOW COMES WITH A COVER AND UPDATED CONNECTOR FOR PURCHASE WHEN REPLACING THE OLD SWITCH. PLEASE INVESTIGATE SINCE PEOPLE'S LIVES ARE BEING IMPACTED DUE TO THE MULTIPLE SAFETY ISSUES AND ALSO DUE TO THE COST ASSOCIATED WITH DIAGNOSING THIS ISSUE. MY COST TO DATE IS IN EXCESS OF $1300.00, AND I AM IN THE PROCESS OF REPLACING IT MYSELF DUE TO MY CONCERNS. *TR
NHTSA ODI #10480704
160,000 miles · Sep 24, 2012
Engine
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE ENGINE MISFIRED, CAUSING THE VEHICLE TO ROUGH IDLE AND STALL. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR DIAGNOSTIC TESTING. THE TEST RESULTS CONCLUDED THAT THE VEHICLE NEEDED A TUNE-UP. THE TUNE-UP WAS PERFORMED HOWEVER, THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE ENGINE MISFIRED, CAUSING THE VEHICLE TO ROUGH IDLE AND STALL. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR DIAGNOSTIC TESTING. THE TEST RESULTS CONCLUDED THAT THE VEHICLE NEEDED A TUNE-UP. THE TUNE-UP WAS PERFORMED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE CONTACT TOOK THE VEHICLE BACK TO THE LOCAL MECHANIC WHERE A SECOND DIAGNOSTIC WAS PERFORMED, CONCLUDING THAT THE VEHICLE WAS IN NEED OF A TUNE-UP. THE VEHICLE WAS NOT FURTHER SERVICED. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10476905
70,000 miles · Jul 27, 2012
Structure
THE DOOR AJAR LIGHT CAME ON AND WARNING BUZZER SOUNDED AND DOME LIGHT CAME ON TOO. AFTER DAYS OF REPLACING PARTS IN THE DOOR AND LUBE ADDED TO THE LATCHES IN BOTH THE MAIN DOOR AND SMALL DOOR THE SMALL DOOR LATCH WILL NOT STAY LATCHED !! KEEPING THE DOME LIGHT ON AND THE DOOR AJAR ON IN THE DASH. IT'S NOT THE LIGHT SWITCH THAT'S…
Read full complaint
THE DOOR AJAR LIGHT CAME ON AND WARNING BUZZER SOUNDED AND DOME LIGHT CAME ON TOO. AFTER DAYS OF REPLACING PARTS IN THE DOOR AND LUBE ADDED TO THE LATCHES IN BOTH THE MAIN DOOR AND SMALL DOOR THE SMALL DOOR LATCH WILL NOT STAY LATCHED !! KEEPING THE DOME LIGHT ON AND THE DOOR AJAR ON IN THE DASH. IT'S NOT THE LIGHT SWITCH THAT'S NOT WORKING IT TESTES GOOD AND NOTHING WRONG WITH IT. THE DOOR LATCH IS DEFECTIVE IN THE SMALL DOOR, WON'T STAY LATCHED OR IN THE CLOSED POSITION , IT ON LATCHES ON IT'S OWN OR AFTER HITTING A SMALL HOLE OR BUMP IN THE ROAD .AND IT DON'T TAKE MUCH TO ON LATCH IT YOU CAN DO IT VERY EASY BY JUST GRABBING THE BOTTOM OF THE DOOR AND PULL IT A LITTLE AND IT LETS GO!! NOT VERY SAFE AND VERY DANGEROUS I WOULD SAY IN A WRECK OR ROLL OVER IT WOULD FLY OPEN YOU WOULD BE THROWN FROM THE TRUCK I WOULD SAY!! THE SEATBELTS ARE ATTACHED TO THIS SMALL FOR YOU IN THE FRONT SEAT AND ANY BODY IN THE SMALL SEAT BEHIND YOU!! THIS SERIOUS AND FORD MADE TO RECALL THESE TRUCKS AND FIXED. *TR
NHTSA ODI #10468046
23,000 miles · Feb 22, 2012
SuspensionFire
TL* THE CONTACT OWNS A 2006 FORD RANGER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHIFT SIDEWAYS ABNORMALLY. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE WHEEL WAS EMITTING SMOKE AND THE WHEEL WAS PARTIALLY DETACHED F…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHIFT SIDEWAYS ABNORMALLY. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE WHEEL WAS EMITTING SMOKE AND THE WHEEL WAS PARTIALLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE MECHANIC STATED TO THE CONTACT THAT THE WHEEL BEARING WAS FRACTURED AND WOULD HAVE TO BE REPLACED. AFTER THE REPAIR, THE CONTACT NOTICED A WHINING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE MECHANIC STATED HAT THE FRONT WHEEL BEARING AND AXLE WOULD HAVE TO BE REPLACED. THE CONTACT WAS NOT AWARE IF THE FAILURE OCCURRED ON THE DRIVER OR PASSENGER SIDE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.
NHTSA ODI #10448975
18,000 miles · Feb 22, 2012
Electrical System
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THERE WAS A DEFECT WITH THE SAFETY SWITCH, WHICH CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SAFETY SWITCH, WHICH CUT FUEL LINES THAT ALLOWED THE VEHICLE TO OPERATE. THE DEALER REPLACED THE SAFETY SWITCH. THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THERE WAS A DEFECT WITH THE SAFETY SWITCH, WHICH CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SAFETY SWITCH, WHICH CUT FUEL LINES THAT ALLOWED THE VEHICLE TO OPERATE. THE DEALER REPLACED THE SAFETY SWITCH. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 23,000.
NHTSA ODI #10448901
Mileage unknown · Dec 27, 2011
Vehicle Speed ControlCrashInjury
THE FIRST INCIDENT OCCURRED ON 12/15/2011 AS I WAS TRAVELING FROM SAVANNAH, GA. TO ATLANTA, GA. I WAS GETTING OFF MY EXIT TO THE I675 AND SLOWED DOWN BY HITTING THE BRAKE AND THE VEHICLE STARTED TO SPEED UP. I WAS NOT USING THE SPEED CONTROL AT ALL AS I MISSED MY EXIT AND SHUT THE VEHICLE OFF IN ORDER TO STOP. ON 12/22/2011 I WA…
Read full complaint
THE FIRST INCIDENT OCCURRED ON 12/15/2011 AS I WAS TRAVELING FROM SAVANNAH, GA. TO ATLANTA, GA. I WAS GETTING OFF MY EXIT TO THE I675 AND SLOWED DOWN BY HITTING THE BRAKE AND THE VEHICLE STARTED TO SPEED UP. I WAS NOT USING THE SPEED CONTROL AT ALL AS I MISSED MY EXIT AND SHUT THE VEHICLE OFF IN ORDER TO STOP. ON 12/22/2011 I WAS COMING HOME TO DETROIT, MI. AND HAD AN ACCIDENT IN GA. I WAS TRAVELING AT 35 MPH, IT WAS RAINING HEAVILY AND AS I PROCEEDED TO SLOW DOWN AROUND A CURVE I IMMEDIATELY LOST CONTROL OF VEHICLE AS THE TRUCK FISHTAILED INTO ONCOMING TRAFFIC AND I TURNED MY WHEEL TO AVOID A COLLISION WITH 2 VEHICLES IN THAT LANE AND ENDED UP IN A CULVERT.I SUSTAINED MINOR INJURIES BUT LUCKILY THERE WERE NO OTHER INJURIES OR DEATHS AS THIS VEHICLE WAS THE ONLY ONE INVOLVED. AT THAT TIME I DID NOT PUT 2 AND 2 TOGETHER AS I THOUGHT THE ROAD WAS SLIPPERY AND I COULDN'T AVOID WHAT HAD HAPPENED. ON 12/24/2011, I VISITED MY FAMILY IN ROCHESTER, MI. AND WENT TO SLOW DOWN AT A LIGHT AND THE VEHICLE BEGAN SPEEDING UP AGAIN CAUSING ME TO GO THROUGH THE LIGHT AND I TURNED THE ENGINE OFF BECAUSE I COULD NOT STOP THE VEHICLE AND I REALIZED THE PEDDLE WAS TO THE FLOOR. LUCKILY I WAS DRIVING THIS VEHICLE INSTEAD OF MY SISTER WHO ACTUALLY OWNS THIS. THIS IS MY FIRST ACCIDENT SINCE I HAVE GOTTEN MY LICENSE BACK IN 1968 AND IT COULD HAVE BEEN A LOT WORSE. AT NO TIME WAS I USING THE SPEED CONTROL. *TR
NHTSA ODI #10441291
43,000 miles · Jul 6, 2011
Fuel System, Gasoline
DRIVING DOWN NJ GSP AND 2006 FORD RANGER ENGINE STOPPED COLD IN HEAVY TRAFFIC. FUEL CUT OFF SWITCH ACTIVATED. *TR
NHTSA ODI #10410633
Mileage unknown · Jun 22, 2011
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THE VEHICLE WAS COMPLETELY DESTROYED DUE TO A FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE AND THEY STATED THE FIRE COULD HAVE BEEN CAUSED BY THE BATTERY. THE CONTACT DID NOT CONTACT THE MANUFACTURER REGARDING THE FIRE. THE VEHICLE FIRE COULD HAVE BUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THE VEHICLE WAS COMPLETELY DESTROYED DUE TO A FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE AND THEY STATED THE FIRE COULD HAVE BEEN CAUSED BY THE BATTERY. THE CONTACT DID NOT CONTACT THE MANUFACTURER REGARDING THE FIRE. THE VEHICLE FIRE COULD HAVE BURNED DOWN HER HOME IF THE VEHICLE WAS PARKED CLOSER TO THE HOUSE. THE MILEAGE AND VIN WERE UNKNOWN.
NHTSA ODI #10408562
Mileage unknown · Jun 11, 2011
Service Brakes, Hydraulic
OWN 2006 FORD RANGER SPORT 4X4. TODAY, 06-11-11 I LOST THE REAR BRAKES FOR THE SECOND TIME. THE FIRST TIME WAS ABOUT A YEAR AGO. TRUCK WAS TAKEN TO A FORD DEALER FOR REPAIR. AFTER INSPECTING THE BRAKES, THEY ASKED ME IF I PARK IN STANDING WATER. I TOLD THEM NO, IN A PARKING LOT.THEY SAID THE REAR BRAKE COMPONENTS WERE FROZEN AND…
Read full complaint
OWN 2006 FORD RANGER SPORT 4X4. TODAY, 06-11-11 I LOST THE REAR BRAKES FOR THE SECOND TIME. THE FIRST TIME WAS ABOUT A YEAR AGO. TRUCK WAS TAKEN TO A FORD DEALER FOR REPAIR. AFTER INSPECTING THE BRAKES, THEY ASKED ME IF I PARK IN STANDING WATER. I TOLD THEM NO, IN A PARKING LOT.THEY SAID THE REAR BRAKE COMPONENTS WERE FROZEN AND CORODED. I FELT THE REAR DRUMS TODAY AND THEY ARE ICE COLD. IF THEY ARE WORKING PROPERLY, THE REAR DRUMS WOULD BE HOT. ITS A VERY SCAREY FEELING WHEN YOU HIT THE BRAKES AND THE TRUCK DOES NOT STOP. PLEASE CHECK TO SEE IF OTHER TRUCK OWNERS HAVE HAD THIS PROBLEM. *TR
NHTSA ODI #10405977
Official recalls
12Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement front passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall expands and replaces previous recall number 23V-125.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement frontal passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed April 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall has been fully superseded by recall 23V-306.
Feb 17, 2021
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with passenger-side air bag inflators. As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles built with passenger-side air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the passenger side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with driver-side air bag inflators . As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the front driver side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 16V-036 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 15V322 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42.
Jan 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger vehicles manufactured March 24, 2003, to May 4, 2006. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the air bag inflators, free of charge. The recall began February 26, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S03. Note: This recall supersedes 14V-343 and only applies to Rangers manufactured in North America.
May 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger trucks manufactured March 24, 2003, to May 4, 2006. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on December 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S22. Note: This recall partially supersedes recall 14V-787.
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration