NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
271 reportsMileage unknown · Oct 5, 2015
Air Bags
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V322000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V322000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10779730
47,000 miles · Sep 23, 2015
Service BrakesUnknown Or OtherWheels
THE TRUCK IS A TOTAL RUST BUCKET THREE SETS OF WHEEL BEARINGS, FOUR SETS OF BRAKES,AIR CONDITIONER LINES,TRANSMISSION LINES ALL RUSTED OUT.FOUR WHEEL DRIVE MOTOR SHOT,LATCH ON TAILGATE BROKEN,REAR END LEAKS UPPER AND LOWER REPAIRED. AT LEST THE RADIO WOKS GREAT . I CAN SEE WHY THEY STOPPED MAKING THIS TRUCK
NHTSA ODI #10773904
Mileage unknown · Aug 12, 2015
Air Bags
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V322000 (AIR BAGS)HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CO…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V322000 (AIR BAGS)HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10748143
114,500 miles · May 25, 2015
Fuel/propulsion System
TRAVELING ON STATE ROUT 56 ENTERED THE OFF RAMP TO CONTINUE ON STATE RT.366, AFTER STOPPING AND ACCELERATING TO 50 MILES AN HOUR THE TRUCK JUST STALLED. WAS ABLE TO COAST TO BERM OF ROAD AND WAITED TO BE TOWED, WOULD NOT START.
NHTSA ODI #10721292
17,000 miles · Feb 12, 2015
Power TrainStructureSuspension
AWFUL BANGING SOUND WHILE DRIVING, INSPECTED TRUCK, FOUND REAR BUMPER HANGING HALF OFF. REAR PORTION OF BOTH FRAME RAILS HAD ROTTEN OFF. REAR SPRING SHACKLES ROTTEN AND NOT ATTACHED. I PULLED THE BUMPER OFF WITH MY BARE HANDS! IF IT HAD FALLEN OFF WHILE I WAS DRIVING IT COULD HAVE KILLED SOMEONE. THIS IS NOT AN OLD BEAT UP TR…
Read full complaint
AWFUL BANGING SOUND WHILE DRIVING, INSPECTED TRUCK, FOUND REAR BUMPER HANGING HALF OFF. REAR PORTION OF BOTH FRAME RAILS HAD ROTTEN OFF. REAR SPRING SHACKLES ROTTEN AND NOT ATTACHED. I PULLED THE BUMPER OFF WITH MY BARE HANDS! IF IT HAD FALLEN OFF WHILE I WAS DRIVING IT COULD HAVE KILLED SOMEONE. THIS IS NOT AN OLD BEAT UP TRUCK, AS A MATTER OF FACT IT ONLY HAS 17,000 MILE ON IT. IT STILL LOOKS BRAND NEW. THE FORD RANGER XLT 4X4 EXTENDED CAB WAS BOUGHT NEW IN 2006 FOR $20,000, NOW ITS USELESS, CAN NOT EVEN FIX THE SPRING SHACKLES, NOTHING TO ATTACH THEM TO. *TR
NHTSA ODI #10683098
115,000 miles · Jan 22, 2015
Structure
FRAME IS RUSTED OUT WILL NOT PASS INSPECTION. SPARE TIRE HOLDER RUSTED OUT. TIRE WOULD HAVE FALLEN OUT. CROSS MEMBER RUSTED OUT. WE HAVE A METALWORKING SHOP AND WILL WELD AND REPAIR OURSELVES AT GREAT TIME AND EXPENSE. POINT OF RUSTOUT IS NEAR WHERE THE FRONT BRACKET IS TO HOLD THE SPRING. GIVE E-MAIL AND I CAN SEND PICTURES. *…
Read full complaint
FRAME IS RUSTED OUT WILL NOT PASS INSPECTION. SPARE TIRE HOLDER RUSTED OUT. TIRE WOULD HAVE FALLEN OUT. CROSS MEMBER RUSTED OUT. WE HAVE A METALWORKING SHOP AND WILL WELD AND REPAIR OURSELVES AT GREAT TIME AND EXPENSE. POINT OF RUSTOUT IS NEAR WHERE THE FRONT BRACKET IS TO HOLD THE SPRING. GIVE E-MAIL AND I CAN SEND PICTURES. *TR
NHTSA ODI #10678187
90,700 miles · Jan 18, 2015
StructureSuspension
WAS DRIVING AND THE BRACKET AND CROSS MEMBER THAT HOLDS THE SPARE TIRE BRACKET UP BROKE DUE TO THE FRAME BEING ALL RUSTED/SCALELY AND ROTTED OUT WHICH ALSO LED TO THE SHACKLES BEING BROKEN. WHEN THIS BRACKET BROKE, MY SPARE TIRE WAS HANGING DOWN AND DRAGGING ON THE GROUND WHICH COULD HAVE CAUSED A SERIOUS ACCIDENT. AFTER THE TIR…
Read full complaint
WAS DRIVING AND THE BRACKET AND CROSS MEMBER THAT HOLDS THE SPARE TIRE BRACKET UP BROKE DUE TO THE FRAME BEING ALL RUSTED/SCALELY AND ROTTED OUT WHICH ALSO LED TO THE SHACKLES BEING BROKEN. WHEN THIS BRACKET BROKE, MY SPARE TIRE WAS HANGING DOWN AND DRAGGING ON THE GROUND WHICH COULD HAVE CAUSED A SERIOUS ACCIDENT. AFTER THE TIRE WAS TAKEN DOWN, THIS IS WHEN THE DEPLORABLE CONDITION OF THE FRAME WAS CLEARLY VISIBLE. THIS TRUCK SHOULD NOT EVEN HAVE BEEN SOLD TO ME OFF OF THE WYOMING VALLEY MOTORS DEALERSHIP LOT IN LARKSVILLE, PA. I HAVE HAD THE TRUCK LESS THAN 14 MONTHS AND PUT LESS THAN 3,000 MILES ON THE TRUCK. THE FRAME AND UNDERCARRIAGE IS UNFIT TO BE ON THE ROAD AND SHOULD NOT HAVE BEEN SOLD ESPECIALLY AT A BIG DEALERSHIP LOT. I HAVE ALSO CONTACTED FORD AND THEY WILL NOT STAND BEHIND THEIR TRUCK AND DO ANYTHING ABOUT IT. *TR
NHTSA ODI #10676344
128,000 miles · Sep 25, 2014
Engine
2006 FORD RANGER V6 3.0 BIGGEST PROBLEM. MULTIPLE CYLINDER MISFIRE. REPLACED MULTIPLE PARTS ALREADY NOTHING HAS WORKED. ENGINE CODE SHOWING MISFIRE IN CYLINDER 4,5,6. MULTIPLE MISFIRES. LOOKED ONLINE MANY OTHERS WITH THE SAME PROBLEM. *TR
NHTSA ODI #10639188
45,000 miles · Jul 22, 2014
StructureSuspension
WHILE DRIVING ON THE TCH IN NEWFOUNDLAND, I HEARD THIS UNUSUAL BANG OUT OF THE REAR OF MY FORD RANGER. I LOOKED IN THE REAR VIEW MIRROR AND SEEN SOMETHING COME FROM BENEATH THE REAR OF MY TRUCK. I PULLED OVER AS DID THE VEHICLE TRAVELING BEHIND ME. THE SPARE TIRE ASSEMBLY HAD RUSTED OFF WHICH LET THE TIRE LOOSE AND FALL OFF.…
Read full complaint
WHILE DRIVING ON THE TCH IN NEWFOUNDLAND, I HEARD THIS UNUSUAL BANG OUT OF THE REAR OF MY FORD RANGER. I LOOKED IN THE REAR VIEW MIRROR AND SEEN SOMETHING COME FROM BENEATH THE REAR OF MY TRUCK. I PULLED OVER AS DID THE VEHICLE TRAVELING BEHIND ME. THE SPARE TIRE ASSEMBLY HAD RUSTED OFF WHICH LET THE TIRE LOOSE AND FALL OFF. THE TIRE NARROWLY ESCAPED THE VEHICLE BEHIND ME. AFTER CLOSER INSPECTION ON THE TRUCK , THE MAIN FRAME HAD COMPLETELY CRACKED OFF AS DID THE SPRING HANGER. I CONTACTED FORD RELATIONS AND THERE WAS NOTHING THEY COULD DO. THIS IS TOTALLY UNSAFE OF FORD TO IGNORE THIS PROBLEM WITH THIS FORD AS IT ALMOST CAUSED A FAMILY OF 3 AN ACCIDENT. I HAVE TAKEN CARE OF THIS TRUCK AND HAVE HAD IT UNDER COATED EVERY TOO YEARS. THERE IS ONLY 85000 KILOMETERS ON THIS TRUCK AND THE FRAME IS COMPLETELY RUSTED OUT. MY PROBLEMS HAVE BEEN DOCUMENTED. *TR
NHTSA ODI #10615357
98,000 miles · May 21, 2014
EngineVehicle Speed Control
ROUGH IDLE NOTICED WHILE STOPPED AT AN INTERSECTION. CATASTROPHIC MISFIRE UPON ACCELERATION THROUGH AN INTERSECTION. TRUCK WAS ONLY ABLE TO "LIMP" 5 OR LESS MILES PER HOUR. CHECK ENGINE LIGHT HAD BEEN TURNING OFF AND ON HOWEVER DIAGNOSTICS SHOWED MISFIRE FOR UNKNOWN REASONS. SPARK PLUGS AND WIRES HAD BEEN REPLACED TWICE WITHIN…
Read full complaint
ROUGH IDLE NOTICED WHILE STOPPED AT AN INTERSECTION. CATASTROPHIC MISFIRE UPON ACCELERATION THROUGH AN INTERSECTION. TRUCK WAS ONLY ABLE TO "LIMP" 5 OR LESS MILES PER HOUR. CHECK ENGINE LIGHT HAD BEEN TURNING OFF AND ON HOWEVER DIAGNOSTICS SHOWED MISFIRE FOR UNKNOWN REASONS. SPARK PLUGS AND WIRES HAD BEEN REPLACED TWICE WITHIN A YEAR AS WELL. DEFECTED HEAD MANUFACTURED BY FORD. *TR
NHTSA ODI #10593297
Official recalls
12Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement front passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall expands and replaces previous recall number 23V-125.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement frontal passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed April 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall has been fully superseded by recall 23V-306.
Feb 17, 2021
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with passenger-side air bag inflators. As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles built with passenger-side air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the passenger side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with driver-side air bag inflators . As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the front driver side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 16V-036 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 15V322 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42.
Jan 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger vehicles manufactured March 24, 2003, to May 4, 2006. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the air bag inflators, free of charge. The recall began February 26, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S03. Note: This recall supersedes 14V-343 and only applies to Rangers manufactured in North America.
May 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger trucks manufactured March 24, 2003, to May 4, 2006. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on December 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S22. Note: This recall partially supersedes recall 14V-787.
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration