IllustrationNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
1996 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 1996 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 80 of 413 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports18 fire reports30 injury reports
What owners actually said
413 reportsWHILE DRIVING, THE WINDSHIELD WIPERS COME ON WITHOUT BEING TURNED ON, THIS FAILURE HAPPENS AT LEAST ONCE A WEEK. *SLC
CONSUMER MADE AN APPOINTMENT AT DEALER'S TO REPAIR COIL SPRING THAT HAD TO BE ALIGNED. BUT, COULD NOT BE POSSIBLE WHERE CONSUMER HAD TO USE CUPS TO RAISE SPRING AND TRY TO FIX PROBLEM. *AK
WINDSHIELD WIPERS COME ON BY THEMSELVES, DOME STAYS ON, DOOR CHIME STAYS ON. *AK
ENGINE. KNOCKING ROD AT ONLY 56,000 MI. OVER $3,000 FOR NEW ENGINE. HEADLIGHTS FAILED TO TURN ON BEFORE LEAVING DRIVEWAY. CAME ON AFTER TURNING ON HIGH BEAMS AND TURN SIGNALS. ON 4 SEPARATE OCCASIONS, I'M ABOUT TO DOWNSHIFT TO MAKE A TURN AND THE ENGINE CUTS OFF. NO POWER STEERING, NEARLY LOST CONTROL.
WINDSHIELD WIPERS GO OFF WITHOUT TOUCHING THE SWITCH. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
LEFT FRONT COIL SPRING BROKE. NO VISIBLE SIGNS OF EXTERIOR DAMAGE. LOOKS LIKE METAL DEFECT. *AK
FIRESTONE ATX TIRES (P235 75 R15) WOULD NOT PASS INSPECTION ON TWO DIFFERENT OCCASIONS, THE FIRST TIME 2" WORE OFF AND THE STEEL BELTS WERE EXPOSED, THE SECOND TIME THERE WAS TREAD SEPARATION. *SLC
TIRE SEPARATED AFTER ONLY 3 MONTHS USE, NEARLY CAUSING AN ACCIDENT. *AK (DOT NUMBER: CHK6 TIRESIZE: 27/8.50R14)
Official recalls
209V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.