IllustrationDRIVING ON CITY STREETS, MY ACCELERATOR HAS BECOME STUCK IN THE CARPETING TWICE CAUSING TEMPORARY INABILITY TO CONTROL SPEED. I TRIED TO GLUE THE CARPET DOWN MYSELF, BUT THERE WAS NOT ENOUGH "GIVE" IN IT TO CORRECT THE PROBLEM.
2004 Ford Mustang
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Ford Mustang do not stand out strongly from the model-year median of 81.
About this comparison →How this year compares
Owner complaints by model year
Compare all Mustang years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
825–50K
850–75K
575–100K
5100–150K
4150K+
89 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports0 fire reports8 injury reports
Vehicle Speed Control complaints
33 reportsDT: THE CONTACT OWNS A 2004 FORD MUSTANG. SHE IS CALLING IN RESPONSE TO THE INVESTIGATION NUMBER PE05038. THE CONTACT STATES THAT THE VEHICLE SOUNDS LIKE IT IS REVVING TOO MUCH WHILE CHANGING GEARS BECAUSE THE RPM'S STAY UP TO HIGH. THE CONTACT HAS CHECKED WITH THE DEALERSHIP BECAUSE THEY THOUGHT SOMETHING WAS WRONG WITH THE CAR…
Read full complaint
DT: THE CONTACT OWNS A 2004 FORD MUSTANG. SHE IS CALLING IN RESPONSE TO THE INVESTIGATION NUMBER PE05038. THE CONTACT STATES THAT THE VEHICLE SOUNDS LIKE IT IS REVVING TOO MUCH WHILE CHANGING GEARS BECAUSE THE RPM'S STAY UP TO HIGH. THE CONTACT HAS CHECKED WITH THE DEALERSHIP BECAUSE THEY THOUGHT SOMETHING WAS WRONG WITH THE CAR WHEN THEY FIRST PURCHASED IT, AND THEY TOLD HIM IT WAS THE NATURE OF THIS CAR. THE DEALERSHIP MUST HAVE SPOKEN WITH FORD IN THE ENGINEERING DEPARTMENT. ALSO, THEY WROTE A LETTER TO FORD AND CONTACTED THEM AS WELL ABOUT THIS PROBLEM. *AK
I HAVE A 2004 FORD MUSTANG COBRA. I HAVE HAD THE ACCELERATOR PEDAL BECOME STUCK UNDER THE CARPET ON MORE THAN ONE OCCASION. ONE OF THE EVENTS HAPPENED WHILE I WAS ON A DYNO-JET TESTING HORSEPOWER, AND IT WAS CAPTURED ON VIDEO. THE OTHER EVEN HAPPENED WHILE DRIVING, AND I WAS NEARLY KILLED. I JUST HAPPENED TO THINK FAST AND S…
Read full complaint
I HAVE A 2004 FORD MUSTANG COBRA. I HAVE HAD THE ACCELERATOR PEDAL BECOME STUCK UNDER THE CARPET ON MORE THAN ONE OCCASION. ONE OF THE EVENTS HAPPENED WHILE I WAS ON A DYNO-JET TESTING HORSEPOWER, AND IT WAS CAPTURED ON VIDEO. THE OTHER EVEN HAPPENED WHILE DRIVING, AND I WAS NEARLY KILLED. I JUST HAPPENED TO THINK FAST AND SWITCH THE KEY OFF. I HAVE FIXED THIS BY CUTTING AWAY A SECTION OF CARPET UNDER THE PEDAL. I AM NOT HAPPY WITH THIS SOLUTION BECAUSE THIS IS A LIMITED PRODUCTION CAR, AND CUTTING CARPET IS NOT A THING THAT I WANTED TO DO. BUT I WAS AFRAID THAT IF I DID NOT DO THIS I WOULD BE INJURED OR KILLED THE NEXT TIME IT HAPPENED.
2004 MUSTANG COBRA BOUGHT NEW ONE MONTH PRIOR. DRIVING DOWN A QUIET ROAD, WENT FULL THROTTLE FOR SHORT DURATION, THROTTLE STUCK, I HAD TO TURN OFF THE IGNITION. ACCELLERATOR PEDAL WAS STUCK UNDER THE CARPET. TOOK IT TO THE DEALER, THEY SAID THEY FIXED IT, AND IT HAPPENED AGAIN UNDER THE SAME CIRCUMSTANCES. THE DEALER FINALLY…
Read full complaint
2004 MUSTANG COBRA BOUGHT NEW ONE MONTH PRIOR. DRIVING DOWN A QUIET ROAD, WENT FULL THROTTLE FOR SHORT DURATION, THROTTLE STUCK, I HAD TO TURN OFF THE IGNITION. ACCELLERATOR PEDAL WAS STUCK UNDER THE CARPET. TOOK IT TO THE DEALER, THEY SAID THEY FIXED IT, AND IT HAPPENED AGAIN UNDER THE SAME CIRCUMSTANCES. THE DEALER FINALLY CUT THE CARPET AND SCREWED IT TO THE FLOORPAN (THE REPAIR IS NOT VISIBLE) AND IT HASN'T HAPPENED SINCE.
DT: THE ACCELERATOR BECAME STUCK ON THE CONSUMERS 2004 MUSTANG SVT COBRA WHILE DRIVING AT A LOW SPEED. WHEN THE CONSUMER APPLIED THE BRAKES AND TRIED PLACING THE VEHICLE IN NEUTRAL, THE THROTTLE WAS WIDE OPEN AND THE ENGINE REVVED UP. THE CONSUMER SIMPLY TURNED OFF THE ENGINE AND PULLED OVER. THE CONSUMER HAD TO MANUALLY LI…
Read full complaint
DT: THE ACCELERATOR BECAME STUCK ON THE CONSUMERS 2004 MUSTANG SVT COBRA WHILE DRIVING AT A LOW SPEED. WHEN THE CONSUMER APPLIED THE BRAKES AND TRIED PLACING THE VEHICLE IN NEUTRAL, THE THROTTLE WAS WIDE OPEN AND THE ENGINE REVVED UP. THE CONSUMER SIMPLY TURNED OFF THE ENGINE AND PULLED OVER. THE CONSUMER HAD TO MANUALLY LIFT THE ACCELERATOR PEDAL AFTER STOPPING THE VEHICLE. THE CONSUMER DID NOT TAKE THE VEHICLE TO THE DEALER, HE IS WAITING TO SEE WHAT FORD IS GOING TO DO ABOUT THIS. THE HAS CONTACTED THE FORD MANUFACTURER WHO SAID THE CONSUMER NEEDED TO MAKE APPOINTMENT WITH THE DEALERSHIP BUT DENIED THERE WAS EVEN AN ISSUE. *JB
2004 MUSTANG - ACCELERATOR PEDAL STUCK AT FULL THROTTLE MULTIPLE TIMES. APPEARS TO BE CAUSED BY PEDAL COMPONENT STICKING UNDERNEATH CARPET.
THE GAS PEDAL ON MY 2004 FORD COBRA STUCK ALL THE WAY DOWN AND ALMOST CREATED AN ACCIDENT. I WAS VERY FORTUNATE TO HAVE NOT BEEN INJURED OR TO INJURE SOMEONE ELSE. FORD, THIS SHOULD BE A FACTORY RECALL PERIOD.
2004 FORD SVT COBRA MUSTANG THE THROTTLE PEDAL WILL HANG UP ON THE CARPET WHEN AT FULL THROTTLE. WHEN THE THROTTLE HANGS, THE ENGINE WILL REV UNTIL REDLINE, AND THEN THE REV LIMITER WILL SET IN. TO STOP THE CAR, THE DRIVER MUST KILL THE IGNITION SWITCH (BEING CARFUL NOT TO TURN IT SO FAR AS TO LOCK THE STEERING WHEEL) AND B…
Read full complaint
2004 FORD SVT COBRA MUSTANG THE THROTTLE PEDAL WILL HANG UP ON THE CARPET WHEN AT FULL THROTTLE. WHEN THE THROTTLE HANGS, THE ENGINE WILL REV UNTIL REDLINE, AND THEN THE REV LIMITER WILL SET IN. TO STOP THE CAR, THE DRIVER MUST KILL THE IGNITION SWITCH (BEING CARFUL NOT TO TURN IT SO FAR AS TO LOCK THE STEERING WHEEL) AND BRING THE CAR TO A STOP WITHOUT POWER BRAKES AND POWER STEERING. WITH OVER 390HP IN THE SVT COBRA, A STUCK THROTTLE WILL CAUSE THIS VEHICLE TO APPROACH OTHERS AT A VERY RAPID PACE. TO FIX THE PROBLEM, A 3"X3" PIECE OF CARPET MUST BE CUT FROM THE FLOOR BENEATH THE ACCELERATOR PEDAL.
I WAS DRIVING THE CAR ON DRAGSTRIP AND THE GAS PEDAL STUCK UNDERNEATH THE CARPET AT FULL THROTTLE I AM NOT REFERRING TO A MAT, THE ACTUAL CARPET I CALLED MY FORD DEALER AND THEY HAVE NO SPECFIC FIX I AM CUTTING A SLIT IN THE CARPET AND GLUEING IT DOWN IF THIS HAPPENED ON THE HIGHWAY, WHO KNOWS?
A STUCK WIDE OPEN THROTTLE OCCURRED WHILE DRIVING MY 2004 FORD SVT COBRA MUSTANG... FORTUNATELY I AM AN EXPERIENCED DRIVER WITH SOME AUTO RACING IN MY BACKGROUND... I WAS ABLE TO QUICKLY PUSH IN THE CLUTCH(ENGINE WAS BOUNCING OFF THE REV LIMITER AT THIS POINT), AND TURN OFF THE KEY... THE COBRA MUSTANG HAS HYDRO-BOOST POWER BRA…
Read full complaint
A STUCK WIDE OPEN THROTTLE OCCURRED WHILE DRIVING MY 2004 FORD SVT COBRA MUSTANG... FORTUNATELY I AM AN EXPERIENCED DRIVER WITH SOME AUTO RACING IN MY BACKGROUND... I WAS ABLE TO QUICKLY PUSH IN THE CLUTCH(ENGINE WAS BOUNCING OFF THE REV LIMITER AT THIS POINT), AND TURN OFF THE KEY... THE COBRA MUSTANG HAS HYDRO-BOOST POWER BRAKES AND POWER STEERING SO AT THIS POINT, STEERING EFFORT AND BRAKE PEDAL EFFORT "WENT THROUGH THE ROOF"(WERE VERY HIGH). SINCE I AM AN ENTHUSIASTIC SUPPORTER AND BUYER OF FORD PRODUCTS I WOULD LIKE TO SEE A RECALL ON THIS VERY COMMON PROBLEM... BEFORE SOME ONE LESS EXPERIENCED GETS KILLED!!! THESE ARE VERY POWERFUL CARS!!! THINGS HAPPEN EXTREMELY FAST WHEN THE PEDAL IS DOWN!!! THE CAUSE OF THIS STUCK THROTTLE IS A PARTIAL BENDING OF THE ACCELERATOR PEDAL, AND THE CONTACT WITH AND STICKING UNDER OF THE CARPET BY THE PEDAL. A STUCK WIDE OPEN THROTTLE IN ANY CAR IS VERY DANGEROUS!!! A STUCK WIDE OPEN THROTTLE IN THIS PARTICULAR CAR IS INSANE!!! TO CORRECT THE PROBLEM AS SOON AS I ARRIVED HOME I TRIMMED THE CARPET THAT WAS CONTACTING THE THROTTLE WHEN DOWN... SO THAT IT WOULD NO LONGER TOUCH AT ALL. PLEASE NOTE---> AT FIRST I THOUGHT THAT THE FLOOR MAT HAD CAUSED THE PROBLEM. I WAS WRONG... WHILE STILL POSSIBLE IF DISLODGED FROM IT'S ANCHOR POINT... IT WAS NOT WHAT WAS STICKING THE PEDAL... IT WAS THE CARPET, WHICH WAS SHAPED POORLY AND RETAINED EVEN WORSE IN THAT CRITICAL THROTTLE AREA. PLEASE NOTIFY THE PROPER AUTHORITIES AS TO THE POTENTIAL FOR EXTREME CONSEQUENCES THIS DEFECT PRESENTS. PLEASE NOTE THAT THE DATE IN THE DATE FIELD IS A GUESS SINCE THIS OCCURRED OVER A YEAR AGO... I AM FILING NOW BECAUSE I HAVE READ ABOUT NUMEROUS OTHER INSTANCES OF THIS OCCURRING AND I FIND IT VERY TROUBLING.
Official recalls
106V108000 · Vehicle Speed Control:accelerator Pedal
Apr 7, 2006
ON CERTAIN MUSTANG COBRA PASSENGER VEHICLES, THE REAR SURFACE OF THE ACCELERATOR PEDAL MAY COME INTO CONTACT WITH FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION. THE UNIQUE SURFACE PROFILE OF THE ACCELERATOR PEDAL MAY CATCH IN THE CUTOUT ON THE FLOOR CARPETING BEHIND THE ACCELERATOR PEDAL.
Consequence & remedy
Consequence: THIS COULD INTERFERE WITH THE PEDAL'S ABILITY TO RETURN TO AN IDLE POSITION. UNEXPECTED, CONTINUED THROTTLE APPLICATION AND/OR INCREASED STOPPING DISTANCES MAY OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE CUTOUT IN THE CARPET BEHIND THE ACCELERATOR PEDAL. THE RECALL BEGAN ON APRIL 26, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA05014 · Accelerator Pedal Interference
Opened Sep 13, 2005 · Closed Apr 10, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
ON APRIL 3, 2006, FORD MOTOR COMPANY SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING A DEFECT CONDITION THAT COULD RESULT IN INTERFERENCE BETWEEN THE ACCELERATOR PEDAL AND FLOOR CARPETING IN APPROXIMATELY 19,140 MODEL YEAR 2003 AND 2004 MUSTANG COBRA VEHICLES (FORD RECALL NO. 06S43/NHTSA RECALL 06V-108, COPY ATTACHED).FORD WILL RECALL THE VEHICLES TO INSTALL A SHIELD BENEATH THE ACCELERATOR PEDAL TO PREVENT THE PIVOT PIN ON THE REAR SURFACE OF THE PEDAL FROM COMING INTO CONTACT WITH THE FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION.IN THOSE VEHICLES WHERE THE FLOOR CARPETING DOES NOT FIT FLUSH WITH THE SHEET METAL, THE UNIQUE REAR SURFACE PROFILE OF THE MUSTANG COBRA PEDAL MAY ALLOW THE PIVOT PIN OF THE PEDAL TO CATCH IN THE CUTOUT ON THE FLOOR CARPETING BEHIND THE PEDAL, INTERFERING WITH THE PEDAL'S ABILITY TO RETURN; THE RESULT OF WHICH COULD BE UNEXPECTED, CONTINUED THROTTLE APPLICATION.DURING THE ENGINEERING ANALYSIS STAGE OF THE INVESTIGATION, ODI ALSO EXAMINED THE POSSIBLITY OF THE SAME PHENOMENA OCCURING IN NON-COBRA MUSTANGS.HOWEVER, THE DIFFERENT DESIGN OF THE ACCELERATOR PEDALS ON THE NON-COBRA MUSTANGS RESULTS IN SIGNIFICANT DIFFERENCES IN THE POTENTIAL CONTACT BETWEEN THE ACCELERATOR PEDAL AND THE CARPETING, WITH THE BASE OF THE PEDAL PAD ACTING TO FORCE THE CARPET AWAY FROM THE PIVOT PIN.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
ON APRIL 3, 2006, FORD MOTOR COMPANY SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING A DEFECT CONDITION THAT COULD RESULT IN INTERFERENCE BETWEEN THE ACCELERATOR PEDAL AND FLOOR CARPETING IN APPROXIMATELY 19,140 MODEL YEAR 2003 AND 2004 MUSTANG COBRA VEHICLES (FORD RECALL NO. 06S43/NHTSA RECALL 06V-108, COPY ATTACHED).FORD WILL RECALL THE VEHICLES TO INSTALL A SHIELD BENEATH THE ACCELERATOR PEDAL TO PREVENT THE PIVOT PIN ON THE REAR SURFACE OF THE PEDAL FROM COMING INTO CONTACT WITH THE FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION.IN THOSE VEHICLES WHERE THE FLOOR CARPETING DOES NOT FIT FLUSH WITH THE SHEET METAL, THE UNIQUE REAR SURFACE PROFILE OF THE MUSTANG COBRA PEDAL MAY ALLOW THE PIVOT PIN OF THE PEDAL TO CATCH IN THE CUTOUT ON THE FLOOR CARPETING BEHIND THE PEDAL, INTERFERING WITH THE PEDAL'S ABILITY TO RETURN; THE RESULT OF WHICH COULD BE UNEXPECTED, CONTINUED THROTTLE APPLICATION.DURING THE ENGINEERING ANALYSIS STAGE OF THE INVESTIGATION, ODI ALSO EXAMINED THE POSSIBLITY OF THE SAME PHENOMENA OCCURING IN NON-COBRA MUSTANGS.HOWEVER, THE DIFFERENT DESIGN OF THE ACCELERATOR PEDALS ON THE NON-COBRA MUSTANGS RESULTS IN SIGNIFICANT DIFFERENCES IN THE POTENTIAL CONTACT BETWEEN THE ACCELERATOR PEDAL AND THE CARPETING, WITH THE BASE OF THE PEDAL PAD ACTING TO FORCE THE CARPET AWAY FROM THE PIVOT PIN.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Vehicle Speed Control
ON APRIL 3, 2006, FORD MOTOR COMPANY SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING A DEFECT CONDITION THAT COULD RESULT IN INTERFERENCE BETWEEN THE ACCELERATOR PEDAL AND FLOOR CARPETING IN APPROXIMATELY 19,140 MODEL YEAR 2003 AND 2004 MUSTANG COBRA VEHICLES (FORD RECALL NO. 06S43/NHTSA RECALL 06V-108, COPY ATTACHED).FORD WILL RECALL THE VEHICLES TO INSTALL A SHIELD BENEATH THE ACCELERATOR PEDAL TO PREVENT THE PIVOT PIN ON THE REAR SURFACE OF THE PEDAL FROM COMING INTO CONTACT WITH THE FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION.IN THOSE VEHICLES WHERE THE FLOOR CARPETING DOES NOT FIT FLUSH WITH THE SHEET METAL, THE UNIQUE REAR SURFACE PROFILE OF THE MUSTANG COBRA PEDAL MAY ALLOW THE PIVOT PIN OF THE PEDAL TO CATCH IN THE CUTOUT ON THE FLOOR CARPETING BEHIND THE PEDAL, INTERFERING WITH THE PEDAL'S ABILITY TO RETURN; THE RESULT OF WHICH COULD BE UNEXPECTED, CONTINUED THROTTLE APPLICATION.DURING THE ENGINEERING ANALYSIS STAGE OF THE INVESTIGATION, ODI ALSO EXAMINED THE POSSIBLITY OF THE SAME PHENOMENA OCCURING IN NON-COBRA MUSTANGS.HOWEVER, THE DIFFERENT DESIGN OF THE ACCELERATOR PEDALS ON THE NON-COBRA MUSTANGS RESULTS IN SIGNIFICANT DIFFERENCES IN THE POTENTIAL CONTACT BETWEEN THE ACCELERATOR PEDAL AND THE CARPETING, WITH THE BASE OF THE PEDAL PAD ACTING TO FORCE THE CARPET AWAY FROM THE PIVOT PIN.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE05038 · Accelerator Pedal Interference
Opened Jul 7, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control:accelerator Pedal
PE05-038 WAS OPENED ON JULY 7, 2005, WITH 11 CONSUMER COMPLAINTS TO ODI ALLEGING INCIDENTS OF THROTTLE STICKING DUE TO ACCELERATOR PEDAL INTERFERENCE WITH THE CARPET.ODI HAS RECEIVED AN ADDITIONAL 24 COMPLAINTS SINCE THE PE WAS OPENED.DURING PE05-038, FORD SUPPLIED COMPLAINT AND WARRANTY INFORMATION REGARDING 86 ADDITIONAL INCIDENTS OF ACCELERATOR PEDAL INTERFERENCE IN MODEL YEAR 2003 TO 2004 MUSTANG COBRA VEHICLES.EIGHTY-FIVE OF THESE HAD CONCERNS OF ACCELERATOR PEDAL STICKING, 70 OF WHICH WERE ANALYZED AS BEING RELATED TO CARPET INTERFERENCE.ODI IS CONTINUING ITS ANALYSIS OF THE CAUSAL FACTORS IN THE REMAINING 15 INCIDENTS.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.