2023 Ford Maverick Hybrid

The CV Axle failed on the driver side around 26k miles. There are several other reports of this happening. They would only replace the one side under warrently. The other one is already going bad, but they won't replace yet. Just google "maverick cv alxe". You need tk recall all cv alxes on these trucks before something happens.

While driving on [XXX] [XXX] at approximately 9:15 PM vehicle suddenly lost power in the middle of traffic, couldn't keep speed (was driving roughly 70 mph) then started losing speed down to 30 mph although my foot was pressing the gas pedal to the floor. Warning lights came on, a message about being unable to engage a gear, loss of collision sensors and check battery, service engine light came on. Because I was on the truck and car portion of the highway (in further most left lane) I was nearly struck several times. Hazards were going on and off. When I made it to the shoulder I called FORD 24 hour service. I was on an out of town trip from PA to NYC a little more than halfway there. The rep told me Ford policy was to tow to the nearest dealership or within 50 miles, I'd have to cover the rest, quoted at $175 to take me to the dealership of origin & my home. By this time it was after 10:30. I was 49 miles from my destination so I asked for the closest dealership to that. Was charged $22.50 for 4 mile overage. Was NOT informed the tow service couldn't pick me up from the highway, rather was told I'd be texted with an eta, which came 10 minutes later with a 40-70 minute estimate. Then the tow company called to say I'd have to get state police to tow me off highway first, THEN call back with a pick up address. Not wanting to wait on the dangers shoulder ANOTHER 2 HOURS, I had to ride the shoulder with hazards on approximately 1 mile to get off highway. Car wasn't able to go past 30 mph and dropped as low as 10. The service center also gave tow driver wrong address (showroom not service) and tow driver dropped my car off in a tow zone once we found the service center. Disgusted with the lack of accountability and responsibilities, I wasn't safe until 2:30 AM. The next morning called service from hotel to beg for same day appointment as I was stranded, was almost sent home with a "few days or more" diagnostic estimate even after mentioning BCM recall news (no notice y INFORMATION REDACTED PURSUANT TO THE FREEDOM

I was on a freeway cruising around 85 mph when all of a sudden my truck lost power and went into limp mode. I had 3 dash warnings about powertrain malfunction, front end collision being unavailable, and something about engaging gear at low speeds. This has happened once before. Same three messages. The vehicle loses power and speed FAST. Luckily both times I was able to pull over and turn the vehicle off and back on and it just has a check engine light and drives normal again. I have had one software recall completed on my truck and I have 17,000 miles.

After having recall 23E09 performed the vehicle loses power and shifts to Neutral while driving. When this happens I am unable to shift back to Drive. The display reads “Gear Selected will Engage at Low Speed.” The "D" in the gear shift flashes. Once speed is reduced to around 5 MPH, the parking brake turns on automatically. The check engine light turns on, a "gear light" on the dash board is on, along with traction control light. The display then reads, “Shift to Park,” “Service AdvanceTrac,” “Hill Start Assist Not Available,” “Pre-Collision Assist Not Available,” and “Service vehicle soon.” After turning the vehicle off and back on again, the vehicle will drive normally with a check engine light still present. The check engine light eventually turns off until the cycle repeats itself and the same issue occurs again. Code: U1011 - Invalid Internal Control Module Monitoring Data Received from ECM/PCM Code: U1028 - ABS Control Module Received Invalid Data from ECM/PCM 'A' Code: U1010 - Invalid Internal Control Module Monitoring Data Received from Hybrid Powertrain Control Module These codes are present each time this issue occurs. This vehicle is unsafe to drive as it loses power on the freeway without notice. This has happened to me 5 times since having recall 23E09 performed on [XXX]. Many other Ford Maverick owners are reporting the same issue on online forums after having this recall. Ford needs to take action before this kills somebody. I have taken the vehicle to Tri State Ford in Amarillo, TX and they say that they are unable to replicate the issue and that they cannot reprogram the PCM & SOBDMC until Ford releases an official fix. The odometer readings when the vehicle has lost power have been 2135, 2437, 3130, 3201, and 3864. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Approximately around [XXX] a.m, [XXX], I was on my way to on the [XXX] . I was going driving around 75-78 mph when all of sudden my 2023 Maverick drop in speed and power suddenly. I looked at my dashboard and saw mph dropped to around 50. I had no knowledge of what was taking place at the time. I tried to press my acceleration pedal and the mph still was dropping, so I managed to get over to the far right lane so I could get to the shoulder. During this event several warning lights flashed, such as check engine soon, crash assist not available, power train malfunction ect. I turned the vehicle off and back on - it still had the same messages- I managed to drive the 5-10miles I had left on my route to work @ 33mph. Once at safe location I contacted a tow truck to haul my vehicle to Hennessey Ford for diagnostic and answers. I've never had any of these issues to take place since owning my truck. Never experienced Loss of power ever in my life. This is truly a event that has left me stunned and wondering will this truly be taken care of and addressed. It's a constant reminder in my head and and it also has prompted me to thank God for my life as well as others because if I hadn't left home to go to work about 30mins earlier than normally due to the traffic which would be pretty thick I may not be here today to tell this story, because there was no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the vehicle will suddenly flash a message about gear selection being unavailable until speed is reduced, followed by error messages about collision-assist disabled, ESC disabled, hill-start assist disabled, and service messages. Check engine light and service lights also come on. No response to throttle inputs, once vehicle decelerates to around 1-2 mph electronic parking brake is automatically applied leading to an abrupt stop. Parking brake can then be removed and vehicle put back into drive, however all drive mode selection is disabled and again there is no response to throttle inputs - truck will accelerate on its own up to above 30 mph (do not know top speed as all areas this occurred were 30mph or less, had to ride brakes to maintain speed limit as vehicle was attempting an uncontrolled/uncommanded acceleration). This has happened 3 times, and first occurrence happened after recalls 23E07, 23E09, and 23C41 were completed. Any attempts to clear faults or exit this limp mode condition fail unless the vehicle is turned off and allowed to sit for 5-10 minutes, at which point faults still remain in system however vehicle is no longer in limp mode with functionality now restored to previously disabled systems. Recorded faults from last occurrence on April 05 2024: SOBDMC DTC U1011:86-AF SOBDMC DTC U1028:00-26 PCM DTC U1010:00-AF OBDII DTC U1011-P ABS DTC U0401:00-2F ABS DTC U0131:00-2E ACM DTC U0255:00-28 IPMA DTC U0418:86-AF In my situation all 3 failure events occurred in a low-traffic, low-threat environment. 1st happened when turning onto a 30 mph road and accelerating in low traffic, able to safely pull over. 2nd happened when turning out of my driveway and began to accelerate, again able to safely pull over. 3rd happened when leaving spot in parking lot, able to safely pull over into another spot.

While driving vehicle at highway speed, error message stating “Gear Selected will Engage at Low Speed” and the vehicle lost all ability to drive at highway speed. Note: no buttons had been unintentionally selected, and it happened twice within a short period of time. Pulling to a safe location while in a rolling deceleration, the vehicle slammed on its brakes at about 5mph. It then showed error messages related to “advancetrac” “front collision avoidance” and “hill start not available” the vehicle would also only move in all electric mode. After turning off the vehicle and it sitting for a few minutes, it cranked and drove normally other than check engine light is still on. Same incident occurred ~1000 miles previous to this incident

Vehicle lost power while driving at highway speed. Pulled over and restarted vehicle. Vehicle proceeded to accelerate without driver input. Multiple warning lights/systems activated including: POWERTRAIN MALFUNCTION / REDUCED POWER; SERVICE ENGINE SOON WARNING; PRE-COLLISION ASSIST NOT AVAILABLE. Similar to issue described in NHTSA Campaign Number: 24V267000

Travelling around 60-70mph on the highway when a warning appeared saying there is a powertrain issue and engine issue. This forced my truck into low gear and I lost the ability to accelerate. This forced me to pull to the side of the highway with no acceleration capabilities which is highly dangerous. Multiple warning lights remained on the dashboard. This first event occured on Mar 10 2024, then happened AGAIN on April 12 2024.