2022 Ford Maverick Hybrid

After ~32000 miles of driving the truck was shuddering aggressively when accelerating. On 10/13/2023 truck was taken into a Ford Dealership, Preston Ford West in Randallstown, MD, for repair of this issue and was told this was due to both CV axles failing and it was no longer safe to drive. From my research, this part failing so early in the life of the vehicle is significantly earlier than what is typical of a CV axle.

CV Joins or front axles failed after 10k miles. The car shakes under acceleration always between 50mph and 60mph and also when you try to overtake other cars. It can shake pretty horribly depending on how hard you press the gas pedal. The problem was reproduced by the dealer but they don't have the parts to fix it. No warning lights.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the vehicle was shuddering upon acceleration. There were no warning lights illuminated. The vehicle was taken to the dealer, who was not able to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving up a hill, the vehicle lost motive power and was shaking vigorously. There were no warning lights illuminated. The contact was able to park the vehicle. The vehicle failed to start the next day. The contact jump-started the vehicle. The “Stop Safely Now” message was displayed. The vehicle was towed to the local dealer, who was unable to determine why the vehicle failed to start but informed the contact the CV axle needed to be replaced. The dealer informed the contact that the parts were on backorder. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 12,000.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at 40 MPH, the vehicle started shaking uncontrollably. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the failure was due to a faulty passenger’s side half-shaft axle. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

Parked in front of garage turn off and knew something was not right. truck loss all power . was dead ,,completely dead. The next day I was leaving for a trip. called for tow and tow could not jump it. truck would not go into neutral. Hybrid electric transmission would not go into neutral. I left for trip came back and still dead. had to call for another tow, tried to jump will not jump or turn over. would not go into neutral. could not push truck or unlock or turn steering wheel. this is a major safety issue. If you kid is in the truck you can not open the truck. If the truck is on fire and your kid is in the truck. you can not open the truck!. if the truck died at Rail road track. died on freeway , or when in traffic your doomed. It had to be put on four wheel dolly and towed to dealer at dealer over 30 days. still has a fire recall ford does not have a fix for. heat exchanger, hybrid cable, battery changed and dont feel safe to drive it.

5/21/2023 8:45pm Driving south on I-15 through Temecula, a “Service Vehicle Soon” warning showed up on display, I pushed “OK” to clear the message and then “Shift Sys Fault” warning showed up while the gear selector showed a flashing “D” 8:48pm (see Ford Pass app) mileage 5,286 Then “Powertrain Malfunction / Reduce Power” warning showed up and the truck started to lose speed. I put the Emergency Flashers on and started to maneuver to the right lane. The truck continued to lose power and the truck kept slowing even though I depressed the accelerator to try to increase speed and keep up with the freeway traffic so I could safely pull off the freeway onto the right shoulder. The gear selector was now flashing “P” even though we were going over 50 MPH. I turned the selector knob clockwise to try to move to “D” fearing that the transmission would self-destruct if it did engage Park. The selector did seem to change to D, still flashing, but I couldn’t say if it stayed there for sure because I was too busy avoiding traffic to get off the freeway. As I pulled onto the shoulder continuing to slow, the emergency brake engaged and the transmission shifted into Park while we were still moving at approximately 5 to 10 MPH and the truck skidded abruptly to a stop making grinding noises. The transmission would not shift out of Park and the parking brake would not release. Note: This Maverick experienced many similar "Shift Sys Faults" errors several months ago although never while the truck was moving. Ford replaced the transmission on Dec 5, 2022 and the vehicle was operating normally until this event. Ford file CAS-38767629-B5P4Y1 9:28pm When Ford Emergency Service advised no help was coming, I turned the key on and I was able to shift the transmission to Drive and continue home. In previous events, after waiting 20-30 mins the fault would clear and the transmission and parking brake would function again. We continued home, 39 miles, without incident. Faults attached